Powerware Ferrups FE/QFE 500VA Manuel utilisateur

Powerware®FERRUPS

FE/QFE UPS

Installation Guide

500 VA–18kVA,50and60Hz

Powerware®FERRUPS

FE/QFE UPS

Installation Guide

500 VA–18kVA,50and60Hz

www.powerware.com

Class A EMC Statements

FCC Part 15

NOTE This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to

part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference when

the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate radio frequency

energy and, if not installed and used in accordance with the instruction manual, may cause harmful interference to radio

communications. Operation of this equipment in a residential area is likely to cause harmful interference in which case

the user will be required to correct the interference at his own expense.

ICES-003

This Class A Interference Causing Equipment meets all requirements of the Canadian Interference Causing Equipment

Regulations ICES-003.

Cet appareil numérique de la classe A respecte toutes les exigences du Reglement sur le matériel brouilleur du Canada.

For Users in Germany

We hereby certify that the uninterruptible power system (QFE 500 VA, 700 VA, 850 VA, 1.15 kVA, 1.4 kVA, 1.8 kVA,

2.1 kVA, 3.1 kVA, 4.3 kVA, 5.3 kVA, 7 kVA, 10 kVA, 12.5 kVA, and 18 kVA) complies with the RFI suppression

requirements of Vfg. 243/1991 and Vfg. 46/1992. The German Postal Service was notified that the equipment is being

marketed. The German Postal Service has the right to retest the equipment and verify compliance.

Hiermit wird bescheinigt, daß die unterbrechungsfreie Stromversorgung (QFE 500 VA, 700 VA, 850 VA, 1.15 kVA,

1.4 kVA, 1.8 kVA, 2.1 kVA, 3.1 kVA, 4.3 kVA, 5.3 kVA, 7 kVA, 10 kVA, 12.5 kVA, and 18 kVA) in Übereinstimmung mit

den Bestimmungen der Vfg. 243/1991 und Vfg. 46/1992 funkentstört ist. Der Deutschen Bundespost wurde das

Inverkehrbringen dieses Gerätes angezeigt und die Berechtigung zur Überprüfung der Serie auf Einhaltung der

Bestimmung eingeräumt.

Powerware reserves the right to change specifications without prior notice.

Powerware is a registered trademark of Powerware Corporation.

way without the express written approval of Powerware.

Powerware®FERRUPS FE/QFE UPS (500 VA–18 kVA) Installation Guide :Rev A www.powerware.com

TABLE OF CONTENTS

1 Introduction 1....................................................

Plug-Receptacle Installation 1.....................................................

Hardwired Installation 1.........................................................

2 Safety Warnings 3................................................

3 Setup 17.........................................................

Dimensions 17.................................................................

Equipment Clearances 19.........................................................

Location Requirements 20.........................................................

Storage and Operating Environment 21................................................

4 Electrical Installation 23............................................

Bypass Switches 24.............................................................

5 External Bypass Switch Installation 29.................................

Installation Wiring Diagrams for External Bypass Switches 34...............................

6 Internal Bypass Switch Installation 45.................................

Installation Wiring Diagrams for Internal Bypass Switches 48................................

7 Battery Cabinet Installation 53.......................................

Before Installing the Batteries 54....................................................

Installing and Connecting the Batteries 56.............................................

Replacing the Batteries 63........................................................

Recycling the Used Battery 64......................................................

8 Phase Check 65...................................................

Table of Contents

ii Powerware®FERRUPS FE/QFE UPS (500 VA–18 kVA) Installation Guide :Rev A www.powerware.com

Powerware®FERRUPS FE/QFE UPS (500 VA–18 kVA) Installation Guide :Rev A www.powerware.com

CHAPTER 1

INTRODUCTION

The Powerware

FERRUPS uninterruptible power system (UPS) is

available in plug-receptacle or hardwired models. The plug-receptacle

models have an input plug and receptacles on the rear panel. The

hardwired models have terminal strips that an electrician has to wire to

AC input.

See the following sections for steps on how to use this manual for your

UPS installation.

Plug-Receptacle Installation

Only a few sections in this manual are required for installing

plug-receptacle models:

:Be sure to read all safety warnings before installing the UPS as stated

in Chapter 2, “Safety Warnings.”

:Complete Chapter 3, “Setup” for setting up the location of the UPS.

:If you purchased an external battery cabinet, an electrician must wire

the battery to the UPS as described in Chapter 7, “Battery Cabinet

Installation.”

:Continue to the startup section in the Powerware FERRUPS FE/QFE

UPS (500 VA–18kVA) User’s Guide.

Hardwired Installation

Most of the sections in this manual are required for the electrician to

install the hardwired models:

:Be sure to read all safety warnings before installing the UPS as stated

in Chapter 2, “Safety Warnings.”

:Complete Chapter 3, “Setup” for setting up the location of the UPS.

:Chapter 4, “Electrical Installation” describes the electrical

requirements for hardwiring the UPS.

:Continue to either Chapter 5, “External Bypass Switch Installation”

or Chapter 6, “Internal Bypass Switch Installation” depending on the

thetypeofbypassswitchbeinginstalled.

Introduction

2Powerware®FERRUPS FE/QFE UPS (500 VA–18 kVA) Installation Guide :Rev A www.powerware.com

:If you purchased an external battery cabinet, see Chapter 7, “Battery

Cabinet Installation” for wiring connections.

:Complete the phase check as described in Chapter 8, “Phase Check.”

:Continue to the startup section in the Powerware FERRUPS FE/QFE

UPS (500 VA–18kVA) User’s Guide.

Powerware®FERRUPS FE/QFE UPS (500 VA–18 kVA) Installation Guide :Rev A www.powerware.com

CHAPTER 2

SAFETY WARNINGS

Read the following precautions before you install the UPS.

IMPORTANT SAFETY INSTRUCTIONS

SAVE THESE INSTRUCTIONS. This manual contains important instructions that you

should follow during installation and maintenance of the UPS and batteries. Please

read all instructions before operating the equipment and save this manual for future

reference.

DANGER

This UPS contains LETHAL VOLTAGES. All repairs and service should be performed

by AUTHORIZED SERVICE PERSONNEL ONLY. There are NO USER

SERVICEABLE PARTS inside the UPS.

WARNING

:This UPS contains its own energy source (batteries). The output receptacles may

carry live voltage even when the UPS is not connected to an AC supply.

:Do not remove or unplug the input cord when the UPS is turned on. This removes

the safety ground from the UPS and the equipment connected to the UPS.

:To reduce the risk of fire or electric shock, install this UPS in a temperature and

humidity controlled, indoor environment, free of conductive contaminants. Ambient

temperature must not exceed 40°C (104°F). Do not operate near water or

excessive humidity (95% max).

:To comply with international standards and wiring regulations, the total equipment

connected to the output of this UPS must not have an earth leakage current

greater than 1.5 milliamperes.

Safety Warnings

4Powerware®FERRUPS FE/QFE UPS (500 VA–18 kVA) Installation Guide :Rev A www.powerware.com

CAUTION

:Batteries can present a risk of electrical shock or burn from high short-circuit

current. Observe proper precautions. Servicing should be performed by qualified

service personnel knowledgeable of batteries and required precautions. Keep

unauthorized personnel away from batteries.

:Proper disposal of batteries is required. Refer to your local codes for disposal

requirements.

:Never dispose of batteries in a fire. Batteries may explode when exposed to flame.

Sikkerhedsanvisninger

VIGTIGE SIKKERHEDSANVISNINGER

GEM DISSE ANVISNINGER

DENNE BRUGERVEJLEDNING INDEHOLDER VIGTIGE

SIKKERHEDSANVISNINGER

FARE

Denne UPS indeholder LIVSFARLIG HØJSPÆNDING. Alle reparationer og

vedligeholdelse bør kun udføres af en AUTORISERET SERVICETEKNIKER. Ingen af

UPS’ens indvendige dele kan repareres af brugeren.

ADVARSEL!

:Denne UPS indeholder egen energiforsyning (batterier). Udgangsnetstikkene kan

lede strøm, selv når UPS’en ikke er tilsat en AC-energikilde.

:Netledningen må ikke fjernes og stikket må ikke trækkes ud, mens UPS’en er

tændt. Dette fjerner sikkerhedsjorden fra UPS’en og fra det udstyr, der er sat til.

:Installér denne UPS i et temperatur- og fugtighedskontrolleret indendørsmiljø, frit

for ledende forureningsstoffer for at formindske risikoen for brand og elektrisk

stød. Rumtemperaturen må ikke overstige 40°C. UPS’en bør ikke betjenes nær

vand eller høj fugtighed (maksimalt 95%).

:I overensstemmelse med internationale normer og bestemmelser for el-installation

må det udstyr, der er forbundet til udgangen af denne UPS, tilsammen ikke

overskride en jordafdelingsspænding på mere end 1,5 milliampere.

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Powerware UPS

Powerware

Powerware 5125 P33 Manuel utilisateur

Powerware

Powerware 9125 Manuel utilisateur

Powerware

Powerware 9155 Manuel utilisateur

Powerware

Powerware 5125 Manuel utilisateur

Powerware

Powerware 5105 Manuel utilisateur

Powerware

Powerware 5125 Manuel utilisateur

Powerware

Powerware 9330 Manuel utilisateur

Powerware

Powerware 5140 Manuel utilisateur

Powerware

Powerware 9125 Manuel utilisateur

Powerware

Powerware 5119 RM Manuel utilisateur

Powerware

Powerware 9315s Manuel utilisateur

Powerware

Powerware Prestige series 9 Manuel utilisateur

Powerware

Powerware PowerRite XT Manuel utilisateur

Powerware

Powerware 5115 RM Manuel utilisateur

Powerware

Powerware 9395 Manuel utilisateur

Powerware

Powerware 5125 9910 P18 Manuel utilisateur

Powerware

Powerware 3105 Manuel utilisateur

Powerware

Powerware 9125 Manuel utilisateur

Powerware

Powerware 9315 Manuel utilisateur

Powerware

Powerware 5115 Manuel utilisateur

Powerware

Powerware 8 - 15 kVA Manuel utilisateur

Powerware

Powerware P93 Manuel utilisateur

Powerware

Powerware BPIV Manuel utilisateur

Powerware

Powerware FERRUPS QFER Manuel utilisateur

Manuels UPS populaires d'autres marques

Pylontech

Pylontech Victron & Pylontech US5000 Manuel utilisateur

Tecnoware

Tecnoware EVO DSP PLUS MM 6.8 Manuel utilisateur

Mecer

Mecer ME-1000-WTU Manuel utilisateur

Mustek

Mustek PowerMust 530(B) Plus Manuel d'installation et d'exploitation

Emerson

Emerson Liebert NXL series Manuel utilisateur

MAKELSAN

MAKELSAN BOXER SERIES Manuel utilisateur

Block

Block PC-0524-400-0 Manuel utilisateur

CyberPower

CyberPower CP585LCD Manuel utilisateur

Eaton

Eaton 3S Instructions de montage

CyberPower

CyberPower Office Tower Series UPS 1000 Manuel utilisateur

CyberPower

CyberPower BM100 Manuel utilisateur

Best Power

Best Power 610 Manuel utilisateur

Best Power

Best Power Unity/I UT3K Manuel utilisateur

Mustek

Mustek PowerMust 400 Offline Manuel utilisateur

Xantrex

Xantrex Trace 512 UR-UPS Manuel utilisateur

Forza

Forza SL-1501UL Manuel utilisateur

LEGRAND

LEGRAND keor 310081 Manuel utilisateur

ABB

ABB Conceptpower DPA 500 Manuel utilisateur