Flowserve APS1 Manuel

Flowserve Corporation 765 South 100 East Phone: 801 373 3028

Flow Control Division Provo, Utah 84606 Facsimile: 801 489 2228

Automation Business Unit www.flowserve.com Email: [email protected]

LMR0015-0 (AUTO-15) 8/01

Automax Valve Automation Systems

Installation, Operation and Maintenance Instructions

Operation

The Automax APS1 with the Automax A25N solenoid valve

purges the spring chamber with exhaust air. This prevents

corrosive atmospheres from being pulled into the

spring chamber.

The APS1 consists of a single compact block with no

moving parts, sandwich mounted between the SuperNova

actuator and the Automax solenoid valve. There are no

tubing or fittings required.

Maintenance Instructions

Trouble Shooting the APS1

Actuator will not cycle.

1. Check for proper orientation of APS1 and

solenoid valve.

2. Check for plugged exhaust port.

3. Check for correct supply pressure.

Air leaks through breather exhaust when actuator

is held open.

1. Check for actuator leakage.

2. Check for solenoid valve leakage.

Installation Instructions

The Automax APS1 may be installed very easily to the

SuperNova series spring return actuators utilizing any

Automax A25N series NAMUR solenoid valve.

1. Place each O-ring provided into the O-ring bore on the

rear of the module (the side with two large ports). Each

O-ring should be completely seated in the bore.

2. Place the actuator with the two ports facing you, and the

stem pointing up. Orient the APS1 module with the

O-rings toward the actuator, and the central thru-port

hole to the right.

3. Place the Automax solenoid valve with the (3) O-rings

toward the APS1 and the operator toward the right.

4. The APS1 is then "sandwich" mounted between the

solenoid valve and the SuperNova actuator with the two

screws provided.

5. Install the pipe plug into port #3 of the solenoid valve

and the bronze breather vent into port #5.

6. Connect the air supply to port #1 and the assembly is

ready for operation.

APS1 Module

Page 1 of 2

SUPERNOVA ACTUATOR

AUTOMAX NAMUR

SOLENOID VALVE

BREATHER VENT

AIR SUPPLY

Flowserve Corporation 765 South 100 East Phone: 801 373 3028

Flow Control Division Provo, Utah 84606 Facsimile: 801 489 2228

Automation Business Unit www.flowserve.com Email: [email protected]

LMR0015-0 (AUTO-15) 8/01

Automax Valve Automation Systems

Installation, Operation and Maintenance Instructions

APS1 Profile View

Page 2 of 2

APS1 Exploded View with BOM

AUTOMAX NAMUR

SOLENOID VALVE

SUPERNOVA ACTUATOR

APS1 PURGE SYSTEM

Standard Components

Part # Description Material Qty P/N

1 APS1 Block Aluminum 1 105839

Anodized

2 O-Ring Nitrile 2 105775

3 M5-.8X40mm Steel 2 106008

SHCS

4 Vent Bronze 1 106200

5 Pipe Plug Steel 1 100933

AIR SUPPLY

(PORT #1)

SUPERNOVA

ACTUATOR

AUTOMAX NAMUR

SOLENOID VALVE

Table des matières

Autres manuels Flowserve Unité de contrôle

Flowserve

Flowserve Limitorque B320 series Manuel utilisateur

Flowserve

Flowserve Serck Audco Manuel utilisateur

Flowserve

Flowserve T4E-1 Manuel utilisateur

Flowserve

Flowserve Valtek Tek-Check Mode d’emploi

Flowserve

Flowserve ColdFlow 341000 Manuel utilisateur

Flowserve

Flowserve ASG 3 Manuel utilisateur

Flowserve

Flowserve NAF Duball DL Manuel utilisateur

Flowserve

Flowserve Valtek Mark Six Manuel utilisateur

Flowserve

Flowserve AKH2 Manuel utilisateur

Flowserve

Flowserve 158 Manuel utilisateur

Flowserve

Flowserve atomac AtoPro Series Manuel utilisateur

Flowserve

Flowserve Valtek Mark Mode d’emploi

Flowserve

Flowserve Argus EK 71 Manuel utilisateur

Flowserve

Flowserve Durco Sleeveline G4XZ Manuel utilisateur

Flowserve

Flowserve 035 000 Series Mode d’emploi

Flowserve

Flowserve Series 081000 Manuel utilisateur

Flowserve

Flowserve FlowTop V726 Instructions d'installation

Flowserve

Flowserve Valtek Valdisk Mode d’emploi

Flowserve

Flowserve NORDSTROM HYPREGUN PLUS 5Q Instructions d'installation

Flowserve

Flowserve Valtek Mark 100 Manuel utilisateur

Flowserve

Flowserve ASF Manuel utilisateur

Flowserve

Flowserve atomac AKH7 Series Manuel utilisateur

Flowserve

Flowserve Valtek Mark Two Manuel utilisateur

Flowserve

Flowserve Valtek FlowTop V746 Manuel utilisateur

Manuels Unité de contrôle populaires d'autres marques

Festo

Festo Compact Performance CP-FB6-E Manuel de la liste des pièces

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manuel utilisateur

JS Automation

JS Automation MPC3034A Manuel utilisateur

JAUDT

JAUDT SW GII 6406 Series Guide rapide

Spektrum

Spektrum Air Module System Manuel utilisateur

BOC Edwards

BOC Edwards Q Series Manuel utilisateur

KHADAS

KHADAS BT Magic Manuel utilisateur

Etherma

Etherma eNEXHO-IL Manuel utilisateur

PMFoundations

PMFoundations Attenuverter Manuel utilisateur

GEA

GEA VARIVENT Manuel utilisateur

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manuel utilisateur

Altronix

Altronix LINQ8PD Instructions de montage

Eaton

Eaton Powerware Series Manuel utilisateur

WAGO

WAGO 750-407/040-000 Manuel utilisateur

Sony

Sony CCU-590 Manuel utilisateur

Graco

Graco 25D614 Manuel utilisateur

Task Force Tips

Task Force Tips YE-RF-900 Manuel de programmation

Shini

Shini SPV-U Series Manuel utilisateur