Ekwb EK-Quantum RX 6800 Manuel utilisateur

INSTALLATION MANUAL

LIQUID COOLING KIT

EKQuantum

Power Kit RX 6800/6900 D-RGB P360 - AMD Edition

1st Revision, November 26, 2020

SAFETY PRECAUTIONS

1. Carefully read the manual before beginning with the

installation process.

2. Keep the product away from the reach of children.

3. Check the component list and condition of the product

before installation. If there is any problem, contact the

shop where you have purchased the product to get a

replacement or refund.

4. EKWB is not responsible for any damages due to external

causes, including but not limited to, mproper use, problems

with electrical power, accidents, neglect, alteration, repair,

improper installation, and improper testing.

5. CPU, GPU and motherboard are subject to damage if the

product is incorrectly installed.

6. This product is CPU and GPU liquid cooling kit, comprising

of individual, original EKWB parts. Combining this liquid

cooling unit with parts other than EK Water Blocks products

may lead to warranty loss.

7. Do not use pure distilled water! For best results EK

recommends the use of EK-CryoFuel coolants!

8. The use of corrosion inhibiting coolants is always

recommended for any liquid cooling system. EKWB

recommends any of the EK-Cryofuel for worry-free usage.

9. Only G1/4 ﬁttings with a parallel thread should be used (1/4”

BSPP), maximum thread engagement is strictly 5.75mm!

10. The EK ﬁttings require only a small amount of force to screw

them ﬁrmly in place since the liquid seal is ensured by the

rubber o-ring gaskets.

11. The product warranty period is 24 months.

These products are intended for installation by expert users only. Please

consult with a qualiﬁed technician for installation. Improper installation

may result in damage to your equipment. EK Water Blocks assumes no

liability whatsoever, expressed or implied, for the use of these products,

nor their installation. The following instructions are subject to change

without notice. Please visit our web site at www.ekwb.com for updates.

Before installation of this product please read all important notices,

disclosures and warranty conditions printed on the back of the box.

- 3 -

TABLE OF CONTENTS

SCOPE OF DELIVERY 4

REQUIRED TOOLS 5

RADIATOR SPACE REQUIREMENTS 6

INSTALLATION TIPS FOR NOVICES 7

LIQUID COOLING SYSTEM 7

INSTALLING THE CPU WATER BLOCK 8

BOX CONTENTS 9

REQUIRED TOOLS 10

GENERAL INFORMATION ON WATER BLOCK COMPATIBILITY 10

WATER BLOCK DIMENSIONS 11

WATER BLOCK SPECIFICATIONS AND MAIN PARTS 12

INSTALLING THE WATER BLOCK 13

AMx and FMx SOCKET MOTHERBOARDS 13

INSTALLING THE RADIATOR AND FANS 16

METHOD 1 16

METHOD 2 18

INSTALLING THE PUMP-RESERVOIR COMBO UNIT 20

INSTALLING THE PUMP-RESERVOIR UNIT DIRECTLY TO THE CHASSIS 22

INSTALLING THE PUMP-RESERVOIR UNIT WITH THE SUPPLIED MOUNTS 23

INSTALLATION OPTIONS 24

ATTACHING THE FITTINGS 26

INSTALLING THE GPU WATER BLOCK 27

BOX CONTENTS 28

WATER BLOCK DIMENSIONS 29

TECHNICAL SPECIFICATIONS AND WATER BLOCK PARTS 30

PREPARING THE GRAPHICS CARD 31

REMOVING THE STOCK BACKPLATE 31

REMOVING THE STOCK COOLER 31

CHANGING THE STOCK 2-SLOT I/O BRACKET FOR THE SINGLE-

SLOT I/O BRACKET 32

CLEANING THE PCB 33

CUTTING AND PLACING THERMAL PADS 33

APPLYING THERMAL COMPOUND 34

INSTALLING THE WATER BLOCK 35

PLACING THE BLOCK ON THE GRAPHICS CARD 35

ATTACHING THE WATER BLOCK 35

INSTALLING THE BACKPLATE 36

BACKPLATE DIMENSIONS 36

REQUIRED TOOLS 37

CUTTING AND PLACING THERMAL PADS 37

ATTACHING THE BACKPLATE 38

CHECKING THE CONTACT IN CASE OF HIGH TEMPERATURES 39

INSERTING THE GRAPHICS CARD INTO THE CHASSIS 39

INSTALLATION OF FITTINGS AND TUBING 40

CONNECTING THE TUBING 40

ELECTRICAL INSTALLATIONS 43

CONNECTING THE PUMP-RESERVOIR UNIT 43

CONNECTING THE FANS 44

RECOMMENDED FILLING AND LEAK TESTING PROCEDURE 45

CONNECTING THE FANS, PUMP AND CPU D-RGB LIGHTS 46

FILLING THE SYSTEM FOR THE FIRST TIME 47

MAINTENANCE TIPS 49

SUPPORT AND SERVICE 50

SOCIAL MEDIA 50

- 4 -

SCOPE OF DELIVERY

EK-Loop Multi Allen Key (1)

D-RGB Fans (3)

Fan Cable Y-Splitter (1)

Radiator (1)

ZMT Tub e

Single-Slot I/O Bracket (1)GPU Water Block (1) With a Backplate and Mounting Mechanism

CPU Water Block (1) With a

Mounting Mechanism

Reservoir (1) With a Mounting

Mechanism

EK-Quantum Torque STC-10/16

(8)

EK-Quantum Torque Rotary 90°

(4)

- 5 -

REQUIRED TOOLS

Scissors

Distilled Water

Phillips Head Screwdriver Mixing Bottle

EK-Loop Angled Bracket - 120mm

(1) With a Mounting Mechanism

EK-Loop Soft Tube Cutter (1)

Foldable Filling Bottle (1)

ATX Bridging Plug (1)

EK-Loop CMS (1)

EK-D-RGB 6-Way Splitter

Cable (1)

EK-CryoFuel Blood Red

Concentrate (1 x 100 mL)

EK-CryoFuel Clear Concentrate

(1 x 100 mL)

- 6 -

RADIATOR SPACE REQUIREMENTS

130mm (5.75 in)

400 mm (15.75 in)

40 mm (1.58in)

130mm (5.75 in)

400 mm (15.75 in)

40 mm (1.58in)

- 7 -

INSTALLATION TIPS FOR NOVICES

1. To lower the shipping cost, we have decided to enclose the coolant

concentrate only. Therefore, you need to provide 1 liter (1L) of

distilled water. You can ﬁnd it at every gas station or supermarket.

2. Never run this system on tap water and always use the

enclosed cooling concentrate in the right ratio.

3. Never use alcohol, alcohol derivatives, or alcohol-based

solvents in the system. Using alcohol might result in permanent

damage to water cooling KIT components, especially acrylic

parts of the system.

4. It is best practice to do a proper 24-hour leak test before using

your computer.

5. If you spot any leaks, turn off the power immediately.

6. Optimize tube length to prevent excessive bending and kinking

of the tubing.

7. Never let your pump run dry. If this is happening for a prolonged

period, you risk destroying the water pump’s bearing, ultimately

rendering the pump useless.

8. You are encouraged to periodically clean the radiator assembly as

it will collect dust over time. It’s best to be done with a soft wide-tip

brush and a vacuum cleaner. See chapter Cleaning Guide.

LIQUID COOLING SYSTEM

CPU WATER BLOCK

GPU WATER BLOCK

RADIATOR WITH FANS

AIR FLOW DIRECTION

RESERVOIR AND WATER-PUMP

COMBO

- 8 -

INSTALLING THE CPU WATER BLOCK

- 9 -

BOX CONTENTS

Thumb Nut (4)

Thermal Grease (1)

Allen Key 2.5mm (1)

Standoff (4)

EK-Quantum Velocity D-RGB - AMD Ryzen

Edition - CPU Water Block (1) Rubber Gasket (1)Metal Backplate (1)

M4 x 0.8 PA Washer (4)

Spring (4)

- 10 -

GENERAL INFORMATION ON WATER BLOCK COMPATIBILITY

This CPU liquid cooling unit is pre-assembled for use with modern AMD

desktop socket type motherboards. By default (out of the box) this water

block supports the following CPU sockets:

- AMD® socket AMx and FMx

Phillips Head Screwdriver

REQUIRED TOOLS

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels ekwb Matériel informatique

ekwb

ekwb EK-FC790 Mode d’emploi

ekwb

ekwb EK-FC980 GTX TF5 Manuel

ekwb

ekwb EK-FC590 GTX Manuel

ekwb

ekwb EK-Quantum Momentum Aorus X570 Master D-RGB -... Manuel utilisateur

ekwb

ekwb EK-Vector Trio RTX 2080 Manuel utilisateur

ekwb

ekwb EK-Classic 115 D-RGB Series Manuel utilisateur

ekwb

ekwb EK-FC WX9100 PRO BACKPLATE Manuel utilisateur

ekwb

ekwb EK-D5 Dual TOP Mode d’emploi

ekwb

ekwb EK-FB ASUS CROSSHAIR 3 Manuel

ekwb

ekwb EK-FC1080 GTX Ti TF6 Manuel utilisateur

ekwb

ekwb EK-FC770 GTX GW Mode d’emploi

ekwb

ekwb EK-FC780 GTX Ti Matrix Manuel

ekwb

ekwb EK-Supremacy Elite Edition series Manuel utilisateur

ekwb

ekwb MSI MPG X570S Carbon EK X Manuel utilisateur

ekwb

ekwb EK-Quantum Momentum2 ROG Strix Z690-I Gaming D-RGB -... Manuel utilisateur

ekwb

ekwb EK-PRO GPU WB H100 Rack - Nickel + Inox Manuel utilisateur

ekwb

ekwb EK-RAM Dominator Manuel

ekwb

ekwb EK-FB MSI X370 XPower Monoblock Manuel utilisateur

ekwb

ekwb EK-FC580 DCII Mode d’emploi

ekwb

ekwb EK-FC 6970 Manuel

ekwb

ekwb EK-Vector FTW3 RTX 2080 Ti Mode d’emploi

ekwb

ekwb EK-FC1080 GTX TF6 Backplate Manuel

ekwb

ekwb EK-FC780 GTX HOF Series Manuel

ekwb

ekwb Supremacy MX AMD Manuel utilisateur

Manuels Matériel informatique populaires d'autres marques

EMC2

EMC2 VNX Series Manuel du propriétaire

Panasonic

Panasonic DV0PM20105 Manuel utilisateur

Mitsubishi Electric

Mitsubishi Electric Q81BD-J61BT11 Manuel utilisateur

Gigabyte

Gigabyte B660M DS3H AX DDR4 Manuel utilisateur

Raidon

Raidon iT2300 Manuel utilisateur

National Instruments

National Instruments PXI-8186 Manuel utilisateur

Hauppauge

Hauppauge WinTV-HVR-2250 Manuel utilisateur

Kontron

Kontron CP6002 Manuel utilisateur

Manhattan

Manhattan 702843 Manuel utilisateur

Aphex

Aphex 230 Manuel utilisateur

AMD

AMD Phenom II Manuel d'exploitation

Intel

Intel NUC 12 Pro Manuel utilisateur

dbx

dbx Zone Pro 1260 Manuel utilisateur

Galaxy

Galaxy GHDX2-2430S-24F4D Manuel utilisateur

Intel

Intel AXXRMFBU4 Manuel utilisateur

Kontron

Kontron DIMM-PC/MD Manuel utilisateur

ST X-NUCLEO-SAFEA1B Mode d'emploi

STEINWAY LYNGDORF

STEINWAY LYNGDORF SP-1 Manuel utilisateur

ekwb EK-Quantum RX 6800 Manuel utilisateur

Manuels Matériel informatique populaires d'autres marques