DeWalt D55154 Manuel utilisateur

if you have questions or comments, contact us.

Pour route question ou tout commentaire, nous contacter.

Si tiene dudas o comentarios, cont&ctenos.

iNSTRUCTiON MANUAL

GUIDE D'UTILiSATION

MANUAL DE INSTRUCCIONES

INSTRUCTIVO DE OPERACI6N, CENTROS DE SERVICIO Y P6LIZA

DE GARANTiA. ADVERTENCIA: L#:ASE ESTE INSTRUCTIVO ANTES

DE USAR EL PRODUCTO.

D55154

Electric Wheeled Dolly-Style 4 Gallon Air Compressor

Compresseur d'air de 17,6 litres (4 gallons) de style diabolo, a roues _lectriques

Compresor de aire el_ctrico sobre ruedas, tipo remolque de 17,6 litros (4 galones)

Air Compressor

A. On/Off Switch

B. Air Tank Pressure Gauge

C. Regulated Pressure Gauge

D. Pressure Regulator

E. Quick Connects

F. Check Valve

G. Safety Valve

H. Air Tank Drain Valve

I. Power Cord Wrap

J. Pressure Switch

K. Pump Oil Dipstick

L. Pump Oil Drain Plug

M. Motor Reset

N. Air intake Filter

O. Handle

P. Handle Locking Knobs

Q. Top Panel for Cargo

iMPORTANT: Always pull handle

up and lock in place before using

as a dolly.

FIG. 1

0NOT A

STEP

B D

Specifications

MODEL D55154

WEIGHT 80 Ibs. (36.3 kg)

HEIGHT 20.0" (508.0 ram)

WIDTH 18.5" (469.9 ram)

LENGTH 23.0" (584.2 ram)

AIRTANK CAPACITY (GALLONS) 4.0 (15.1 liters)

APPROX CUT-IN PRESSURE 95 PSI (655 kPa)

APPROX. CUT-OUT PRESSURE 125 PSI (861.8 kPa)

SCFM @ 100 PSI (689.5 kPa) 3.8

MOTOR 1.1 HP (continuous)

Volts/Amps/Hertz 120V/14 A/60 Hz.

RPM 345O

Minumum Branch Circuit 15 Amp

Requirement

PUMP OIL CAPACITY 12 oz. (354.9 ml)

DUTY CYCLE 5 MINUTES ON /

5 MINUTES OFF

PUMP

CYLNDER

AND HEAD

OUTLET TUBE

CHECK

VALVE

Definitions: Safety Guidelirees

The definitions below describe the level of severity

for each signal word. Please read the manual and

pay attention to these symbols.

.&DANGER: Indicates an imminently hazardous

s#uation which, if not avoided, will result in death

or serious injury.

.&WARNING: Indicates apotentially hazardous

situation which, if not avoided, could result in death

or serious injury.

.&CAUTION: Indicates a potentially hazardous

situation which, if not avoided, may result in minor or

moderate injury.

CAUTION: Used without the safety alert .symbol

indicates a potentially hazardous situation which, if

not avoided, may result in property damage.

IF YOU HAVE ANY QUESTIONS OR COMMENTS ABOUT

THIS OR ANY DEWALT TOOL, CALL US TOLL FREE AT:

1-800-4-DEWALT (1-800-433-9258)

Irnportant Safety Instructions

.&WARNING: Do not operate this unit until you read and understand

this instruction manual for safety, operation and maintenance

instructions.

AWARNING: Some dust created by power sanding, sawing, grind-

ing, drilling, and other construction activities contains chemicals

known to the State of California to cause cancer, birth defects or other

reproductive harm. Some example of these chemicals are:

•lead from lead-based paints

•crystalline silica from bricks and cement and other masonry

products

arsenic and chromium from chemically-treated lumber

Yourrisk from these exposures varies, depending on how often you

do this type of work. Toreduce your exposure to these chemicals:

work in a weft ventilated area, and work with approved safety

equipment, always wear OSHA/MSHA/NIOSH approved, properly

fitting face mask or respirator when using such tools.

When using air tools, basic safety precautions should always be fol-

lowed to reduce the risk of of personal injury

i_WARNING: This product contains chemicals, including lead,

known to the State of California to cause cancer, and birth defects

or other reproductive harm. Wash hands after handling.

SAVE THESE INSTRUCTION

.&DANGER: RISK OF EXPLOSION OR FIRE

WHAT CAN HAPPEN HOWTO PREVENT iT

iSnormal for electrical • Always operate the corn'

contacts within the m0tQr pressor in a well ventilated

and pressure switch to area free of combustible

spark, materials, gasoline, or sol_

vent vapors.

• If electrical sparks from • If spraying flammable mate-

compressor come into rials, locate compressor at

contact with flammable least 20 feet (6.1 m) away

vapors, they may ignite, from spray area. An addi-

causing fire or explosion, tional length of hose may be

required.

• Store flammable materials in

a secure location away from

compressor.

oRestrictinganyofthe • Neverplaceobjectsagainst

compressorventilation

openingswillcause

seriousoverheating •

andcouldcausefire.

-Unattended operation of -

this product could result in

personal injury or property

damage. To reduce the •

risk of fire, do not allow

the compressor to operate

unattended.

or on top of compressor

pump.

Operate compressor in

an open area at least 12"

(30.5 cm) away from any

wall or obstruction that

would restrict the flow of

fresh air to the ventilation

openings.

Operate compressor in a

clean, dry well ventilated

area. Do not operate unit

indoors or in any confined

area.

Always remain in atten-

dance with the product

when it is operating.

Always turn off and unplug

unit when not in use.

,&DANGER: RISK TO BREATHING (ASPHYXIATION)

WHAT CAN HAPPEN HOWTO PREVENT IT

.The compressed air directly o Air obtained directly from the

from your compressor is not compressor should never

safe for breathing. The air be used to supply air for

stream may contain carbon human consumption. In order

monoxide, toxic vapors, to use air produced by this

or solid particles from the compressor for breathing,

air tank. Breathing these suitable filters and in-line

contaminant's can cause safety equipment must be

sedous injury or death, properly installed. In-line

filters and safety equipment

used in conjunction with the

compressor must be capable

of treating air to all applicable

local and federal codes pnor

to human consumption.

• Sprayed materials such as • Work in an area with good

paint, paint solvents, paint cross ventilation. Read and

remover, insecticides, weed follow the safety instructions

killers, may contain harmful provided on the label or

vapors and poisons, safety data sheets for the

materials you are spraying.

Always use certified safety

equipment: OSHA!MSHA/

NIOSH respiratory protection

designed for use with your

specific application.

.&DANGER: RISK OF INJURY OR PROPERTY DAMAGE WHEN

TRANSPORTING OR STORING

WHAT CAN HAPPEN

• Oil can leak or spill and =

could result in fire or

breathing hazard; serious

injuryor death can result. Oil

leaks will damage carpet,

paint or other surfaces in

vehicles or trailers.

HOWTO PREVENT IT

Always place compressor

on aprotective mat when

transporting to protect against

damage to vehicle from leaks.

Remove compressor from

vehicle immediately upon

arrival at your destination.

Always keep compressor level

and never lie on its side.

WARNING: RiSK OF BURSTING

Air Tank: The air tank on your Air Compressor is designed and

may be UM coded (for units with air tanks greater than 6 inch

diameter) according to ASME Section VIII, Div. 1rules. All pressure

vessels should be inspected once every two years. To find your

state pressure vessels inspector, look under the Division of Labor

and Industries in the government section of a phone book or call

1-800-4-DEWALT for assistance.

The following conditions could lead to a weakening of the air tank,

and result in a violent air tank explosion:

WHAT CAN HAPPEN HOWTO PREVENT IT

- Failure to properly drain • Drain air tank daily or after

condensed water from each use. If air tank develops

air tank, causing rust and a leak, replace it immediately

thinning of the steel air tank. with a new air tank or replace

the entire compressor.

-Modifications or attempted • Never drill into, weld, or make

repairs to the air tank. any modifications to the

air tank or its attachments.

Never attempt to repair a

damaged or leaking air tank.

Replace with a new air tank.

= Unauthorized modifications o The air tank isdesigned

to the safety valve or any to withstand specific

other components which operating pressures. Never

control air tank pressure, make adjustments or

parts substitutions to alter

the factory set operating

pressures.

Attachments & accessories:

• Exceeding the pressure

rating of air tools, spray

guns, air operated

accessories, tires, and other

inflatables can cause them

to explode or fly apart, and

could result in serious injury.

Follow the equipment

manufacturers

recommendation and never

exceed the maximum

allowable pressure rating

of attachments. Never use

compressor to inflate small

low pressure objects such

as children's toys, footballs,

basketballs, etc.

Tires:

= Over inflationof tires could

result in serious injuryand

property damage.

• Use a tire pressure gauge

to check the tires pressure

before each use and while

inflating tires; see the tire

sidewall for the correct tire

pressure.

NOTE: Air tanks, compressors

and similar equipment used to

inflate tires can fill small tires sim-

ilar to these very rapidly. Adjust

pressure regulator on air supply

to no more than the rating of the

tire pressure. Add air in small

increments and frequently use

the tire gauge to prevent over

inflation.

WARNING: RiSK OF ELECTRICAL SHOCK

WHAT CAN HAPPEN

• Your air compressor is

Like any other electrically

powered device, If it is not

used properly it may cause

electric shock.

HOWTO PREVENT IT

• Never operate the

compressor outdoors

when it is raining or in wet

conditions.

Never operate compressor

with protective covers

removed or damaged.

Repairs attempted by • Any electrical wiring

unqualified personnel can or repairs required on

result in serious injuryor this product should be

death by electrocution, performed by a DEWALT

Electrical Grounding:

Failure to provide

adequate grounding to

this product could result

in serious injuryor death

from electrocution. See

Grounding instructions

under Installation.

factory service center or a

DEWALT authorized service

center in accordance with

national and local electrical

codes.

Make certain that the

electrical circuit to which the

compressor is connected

provides proper electrical

grounding, correct voltage

and adequate fuse

protection.

AWARNING: RiSK FROM FLYING OBJECTS

WHAT CAN HAPPEN

• The compressea air

stream can cause soft

tissue damage to exposed

skin and can propel dirt,

chips, loose particles,

and small objects at high

speed, resulting in property

damage or personal injury.

HOWTO PREVENT iT

o Always wear certified safety

equipment: ANSi Z87.1 eye

protection (CAN/CSA Z94.3)

with side shields when using

the compressor.

e Never point any nozzle or

sprayer toward any part of

the body or at other people

or animals.

o Always turn the compressor

off and bleed pressure

from the air hose and air

tank before attempting

maintenance, attaching tools

or accessories.

_,WARNING: RISK OF HOT SURFACES

WHAT CAN HAPPEN HOWTO PREVENT IT

= Touching exposed metal • Never touch any exposed

such as the compressor metal parts on compressor

head, engine head, engine during or immediately after

exhaust or outlet tubes, can operation. Compressor

result in serious burns, will remain hot for several

minutes after operation.

Do not reach around

protective shrouds or

attempt maintenance until

unit has been allowed to

cool.

,&WARNING: RISK FROM MOVING PARTS

WHAT CAN HAPPEN HOWTO PREVENT IT

Moving parts such as the • Never operate the

pulley, flywheel, and belt compressor with guards or

can cause serious injuryif

they come intocontact with

you or your clothing.

Attempting to operate

compressor with damaged

or missing parts or

attempting to repair

compressor with protective

shrouds removed can

expose you to moving parts

and can result in serious

injury.

covers which are damaged or

removed.

® Keep your hair, clothing, and

gloves away from moving

parts. Loose clothes, jewelry,

or long hair can be caught n

moving parts.

* Airvents may cover moving

parts and should be avoided

as well.

, Any repairs required on this

product should be performed

by a DEWALT factory

service center or a DEWALT

authorized service center.

_, WARNING: RISK OF UNSAFE OPERATION

WHAT CAN HAPPEN HOWTO PREVENT iT

® Unsafe operation of your o Review and understand all

air compressor could lead nstructions and warnings n

to serious injury or death to this manual.

you or others. • Become familiar with the

operation and controls of the

air compressor.

o Keep operating area clear

of all persons, pets, and

obstacles.

® Keep children away from the

air compressor at all times.

- Do not operate the product

when fatigued or under the

influence of alcohol or drugs.

Stay alert at all times.

Never defeat the safety fea-

tures of this product.

- Equip area of operation with

afire extinguisher.

- Do not operate machine with

missing, broken, or unautho-

rized parts.

o Never stand on the

compressor.

J&WARNING: RiSK OF FALLING

WHAT CAN HAPPEN

A portable compressor

can fall from a table,

workbench, or roof

causing damage to the

compressor and could

result in serious injury or

death to the operator.

HOWTO PREVENT iT

• Always operate compressor

in a stable secure position

to prevent accidental

movement of the unit.

Never operate compressor

on a roof or other elevated

position. Use additional

air hose to reach high

locations.

Z&WARNING: RiSK OF iNJURY FROM LiFTiNG

WHAT CAN HAPPEN HOWTO PREVENT iT

serious injurycan result The CompreSs0r istoo heaVY

from attempting to lifttOO to be lifted by one person.

heavy an object, Obtain assistance from oth-

ers before lifting.

ACA UTION: RiSK FROM NOISE

WHAT CAN HAPPEN HOWTO PREVENT iT

Under some conditions • Always wear certified safety

and duration of use, noise equipment: ANSI S12.6

from this product may con- ($3.19) hearing protection.

tribute to hearing loss.

SAVE THESE INSTRUCTIONS

FOR FUTURE USE

FEATURES (Fig. 1)

ON/OFF SWITCH

Place this switch (A)in the ON position to

provide automatic power to the pres-

sure switch and OFF to remove power

at the end of each use.

PRESSURE SWITCH

The pressure switch (J) automatically starts the motor when the

air tank pressure drops below the factory set cut-in pressure, it

stops the motor when the air tank pressure reaches the factory

set cut=out pressure.

SAFETY VALVE

if the pressure switch does not shut off the air

compressor at its cut-out pressure setting, the

safety valve (G) will protect against high

pressure by popping out at its factory set

pressure (slightly higher than the pressure

switch cut-out setting).

Autres manuels pour D55154

Table des matières

Langues :

Autres manuels DeWalt Compresseur d'air

DeWalt

DeWalt DXCMH9919910-CA Manuel utilisateur

DeWalt

DeWalt DXCM601 Manuel utilisateur

DeWalt

DeWalt DXCM251 Manuel utilisateur

DeWalt

DeWalt U3A2008X Manuel utilisateur

DeWalt

DeWalt D55180T Manuel utilisateur

DeWalt

DeWalt D2002M Manuel utilisateur

DeWalt

DeWalt DXCMTA1980854 Manuel utilisateur

DeWalt

DeWalt Emglo D55151 Manuel utilisateur

DeWalt

DeWalt Emglo D55155 Manuel utilisateur

DeWalt

DeWalt D55146 Manuel utilisateur

DeWalt

DeWalt D55672 Manuel utilisateur

DeWalt

DeWalt DCC2560 Manuel utilisateur

DeWalt

DeWalt D55684 Manuel utilisateur

DeWalt

DeWalt D55690 Manuel utilisateur

DeWalt

DeWalt XR DCC1018 Manuel utilisateur

DeWalt

DeWalt DXCM603 Manuel utilisateur

DeWalt

DeWalt D55273 Manuel utilisateur

DeWalt

DeWalt DXCM804 Manuel utilisateur

DeWalt

DeWalt D55168 Manuel utilisateur

DeWalt

DeWalt D55270T Manuel utilisateur

DeWalt

DeWalt D55154-CA Manuel utilisateur

DeWalt

DeWalt DXCMH1608WB Manuel utilisateur

DeWalt

DeWalt D55250 Manuel utilisateur

DeWalt

DeWalt DXCMTA5090412 Manuel utilisateur

Manuels Compresseur d'air populaires d'autres marques

Sparmax

Sparmax DC-25XR Manuel utilisateur

KAESER

KAESER M122 Manuel utilisateur

GMC

GMC GAC1500 Manuel utilisateur

Briggs & Stratton

Briggs & Stratton Air Compressor Manuel utilisateur

Fini

Fini F3GST2TK Manuel utilisateur

Industrial Air

Industrial Air CP1580325 Manuel de programmation

Campbell Hausfeld

Campbell Hausfeld RP3300 Guide de démarrage rapide

Ingersoll-Rand

Ingersoll-Rand UP6 20 HP Manuel utilisateur

Hitachi

Hitachi EC99S Manuel de l'opérateur

Parkside

Parkside PKO 270 A1 Manuel utilisateur

Sullair

Sullair 185 Manuel utilisateur

Clas Ohlson

Clas Ohlson QIE-ZTH-15 Manuel utilisateur

Ferm

Ferm CRM1046 Manuel utilisateur

BE AC153 Manuel utilisateur

RIDGID

RIDGID OF25150A Manuel utilisateur

Johnson Controls

Johnson Controls QUANTUM LX Manuel

Sears

Sears Craftsman 919.167463 Manuel utilisateur

Ring Automotive

Ring Automotive RAC700 Manuel utilisateur