MasterChef 85-3129-6 Propane Manuel utilisateur

SELECT 5-BURNER

PROPANE BARBECUE

Assembly Manual

85-3129-6 (G55105) Propane

1 YEAR LIMITED WARRANTY

ANSI Z21.58-2015 / CSA 1.6-2015

ANSI Z21.58-2015 / CSA 1.6-2015 ANSI Z21.58-2015 / CSA 1.6-2015

ANSI Z21.58-2015 / CSA 1.6-2015

READ AND SAVE MANUAL FOR FUTURE REFERENCE.

Assemble your grill immediately.

Missing or damaged parts claims must be submitted within 30 days of purchase date.

For product inquiries, parts, warranty and troubleshooting support,

please call 1-855-453-2150.

DANGER

1. If you smell Gas:

a. Shut o gas to the appliance.

b. Extinguish any open ame.

c. Open lid.

d. If odor continues, keep away from

the appliance and immediately

call your gas supplier or your

re department.

2. Requires two people to complete the

assembly process.

3. Beware of sharp edges.

WARNING

Failure to follow all of the Manufacturer’s

instructions could result in hazardous res,

explosions, property damage, or serious

personal injury or even death.

Follow all leak check procedures carefully

prior to operation of barbecue, even if grill

was dealer assembled. Do not try to light

this barbecue without reading the Lighting

Instructions section of this manual.

THIS MANUAL MUST REMAIN WITH THE PRODUCT AT ALL TIMES

CAUTION

Read and follow all safety statements,

assembly instructions, use and care

directions before attempting to assemble

and cook.

WARNING

1. Do not store or use gasoline or other

ammable liquids or vapours in the

vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall

not be stored in the vicinity of this or any

other appliance.

WARNING

IN DIRECT SUN, AND IN OPERATION,

YOUR BBQ’S STAINLESS STEEL AND

PAINTED STEEL PARTS CAN BECOME

VERY HOT.

CAUTION

Sharp edges. Wear gloves when assembling

your grill.

THIS BARBECUE IS FOR OUTDOOR USE ONLY.

CONTACT CALL CENTRE IF ANY PARTS ARE MISSING.

1-855-453-2150

INSTALLER OR ASSEMBLER/CONSUMER

This manual should be kept with the BBQ at

all times.

HEAVY ARTICLE NEEDS 2 TO LIFT

To ORDER non-warranty replacement parts or accessories, or to register your warranty,

please visit us on the web at

www.masterchefbbqs.com

HARDWARE PACK

1/4”-20UNC X13 Screw

X 20

ST4.2X8 Tapping Screw

X 14

Wheel Spacer

X 2

Control Knob

X 1

NO.10-24UNC Nut

X 3

NO.8-32UNC X10 Screw

X 2

1/4’’-20UNC Nut

X 8

Aluminum Washer

X 8

Hitch Pin

X 1

NO.10-24UNC X18 Screw

X 3

M4 Wing Nut

X 1

Wheel Washer

X 1

Bezel, Control Knob

X 1

Venturi Clip, Side Burner

X 1

1 2 3

4 5 6

KEY # DESCRIPTION PART NUMBER QUANTITY

1 1/4”-20UNC X13 Screw 20120-13013-036 20

2 1/4”-20UNC Nut 31220-13000-036 8

3 ST4.2X8 Tapping Screw 24200-42008-136 14

4 Aluminum Washer G466-0042-9000 8

5 Wheel Spacer G650-0012-9091 2

6 Wheel Washer G650-0013-9091 1

7 Hitch Pin G306-0005-9088 1

8 Control Knob G312-B102-01 1

9 Bezel, Control Knob G430-0027-02 1

10 NO.10-24UNC X18 Screw 20124-10018-036 3

11 NO.10-24UNC Nut 31224-10000-036 3

12 Venturi Clip, Side Burner G405-0019-9200 1

13 M4 Wing Nut 33301-04000-032 1

14 NO.8-32UNC X10 Screw 20132-08010-250 2

TOOLS NEEDED FOR ASSEMBLY

• #2 Star-head screwdriver (long and short)

• ¼” Slotted screwdriver (long and short)

• Adjustable wrench

• Pliers

For correct hardware assembly, always position

the lock washer between the screw and the at

washer.

Caution:

Sheet metal can cause injury. Wear gloves when installing the grill.

Lock Washer

Flat Washer

Screw

BEFORE ASSEMBLING THIS BARBECUE, READ THE INSTRUCTIONS CAREFULLY.

Assemble the barbecue on a flat, clean surface. Grill is heavy. Two people are recommended

to complete assembly.

PARTS LIST PROPANE FOR 8531296 G55105

KEY # QUANTITY DESCRIPTION PART NO.

AA 1 Top Lid Assembly G551-6700-01

AB 1 Thermometer and Bezel G312-B201-01

AC 2 Lid Handle Brackets G352-0015-01

AD 1 Top Lid Handle G551-0001-01

AE 2 Lid Bumpers, Back G303-0038-01

AF 2 Lid Bumpers, Front G430-00B8-01

AG 2 Screws for Lid G430-0024-02

BA 1 Burner Box Assembly G551-0300-01

BB 5 Burner G432-B600-01

BC 1 Electrode Set, Main Burner G501-0010-01

BD 4 Burner Brace Assembly G551-0006-01

BE 5 Flame Tamer G432-0096-01

BF 3 Cooking Grate G551-0400-01

BG 1 Warming Rack G551-0005-01

CA 1 Control Panel G551-0013-01

CB 1 Manifold Assembly G551-5200-01

CC 1 Metal Hose, Side Burner G430-2403-01

CD 1 Side Burner Valve, LP G551-5201-01

CE 1 Regulator G311-0503-01

CF/#9 6 Bezel, Control Knob G430-0027-02

CG/#8 6 Control Knob G312-B102-01

CH1 1 Electronic Ignition Assembly G409-0021-A1

CH2 1 Electronic Ignition Button G409-0030-01

CI 1 Grease Cup Hook G305-0043-01

CJ 1 Grease Cup G430-0033-02

CK 1 Heat Shield G551-0003-01

DA 1 Cart Side Panel, Right G551-0900-01

DB 1 Cart Side Panel, Left G551-0800-01

DC 2 Back Brace G551-1000-01

DD 1 Upper Front Panel G551-0008-01

DE 1 Lower Front Panel G551-0009-01

DF 2 End Caps G430-0023-01

DG 2 Wheel G401-0058-01

DH 1 Wheel Axle G651-0027-01

DI 1 Match Holder G401-0079-01

DJ 3 Tank Exclusion G551-0011-01

DK 1 Gas Tank Support G551-0010-01

EA 1 Side Shelf Table, Right G451-0B00-01

EB 1 Side Shelf Fascia, Right G551-6901-01

EC 1 Side Shelf Table, Left G551-0600-01

ED 1 Side Shelf Fascia, Left G551-6801-01

EE 1 Side Burner Drip Pan G651-0038-01

EF 1 Side Burner G551-5500-01

EG 1 Electrode Set, Side Burner G430-0042-02

EH 1 Side Burner Grate G430-0053-01

EI 1 Side Burner Lid G430-0018-A1

F1 1 Hardware Pack G551-B005-01

F2 1 Assembly Instructions G551-M005-01

F3 1 Safe Use and Care Manual G551-M005-02

EXPLODED DIAGRAM PROPANE FOR 8531296 G55105

BG AB

CH2

CH1

HARDWARE

PACK

F2 F3

ASSEMBLY

MANUAL

SAFETY

AND CARE

MANUAL

Note: Two people required for all assembly steps.

Assemble the Upper Front Panel (DD) and Lower

Front Panel (DE) to the the Left and Right Cart Side

Panels (DB and DA) as shown.

ASSEMBLY INSTRUCTIONS

YOU WILL NEED:

X 8

Back View

Assemble the two Back Braces (DC) to the

Left and Right Cart Side Panels (DB and DA) as

shown.

DA DB

Close Up

Note: Turn Cart assembly upside down.

a. Place Wheel (DG) and Wheel Spacer (#5) onto

the Wheel Axle (DH). “Cone”side of wheel

should be against cart side panel. Figure B.

b. Insert Wheel Axle Assembly (DH) through

wheel axle hole in the front and rear of the Left

Cart Side Panel (DB), as shown.

c. To complete wheel assembly position the

Wheel Spacer (#5), Wheel (DG), Wheel Washer

(#6) and Hitch Pin (#7), onto Wheel Axle (DH)

as shown.

d. Insert End Caps (DF) into Right Cart Side Panel

(DA).

ASSEMBLY INSTRUCTIONS

876

YOU WILL NEED:

X 2

X 1

Assemble the three Tank Exclusion Wires (DJ) to

the Lower Back Brace (DC) and the Front Panel

(DD and DE) as shown.

Back View

Close up - front view

Close up - back view

YOU WILL NEED:

10 11

X 3 X 3

Close upClose up

Note: TWO PEOPLE required for this step.

Ensure that the regulator hose (CE) (Propane

models only) is hanging outside of cart.

a. Position the Lid and Burner Box Assembly

(A & B), onto the cart assembly (C).

b. Assemble the Burner Box Assembly (BA) to the

cart assembly (C) as shown in gure B.

YOU WILL NEED:

ASSEMBLY INSTRUCTIONS

X 4

A B

PROPANE MODEL ONLY.

Assemble the Gas Tank Support (DK) to Left Cart

Side Panel (DB).

Back View

Close up

ASSEMBLY INSTRUCTIONS

7RIGHT SIDE SHELF ASSEMBLY

a. Insert the Right Side Shelf Assembly (EA and

EB) into the support brackets located on the

right side of the Burner Box Assembly (BA).

b. Ax the Right Side Shelf Table (EA) to the

Burner Box Assembly (BA) as shown in

gures B and C.

c. Ax the Right Side Shelf Fascia (EB) to the

Control Panel (CA).

Securely tighten all hardware.

YOU WILL NEED:

X 3

Front, right side view

Back View

View, under right side shelf

X 4 X 4

X 4

ASSEMBLY INSTRUCTIONS

8LEFT SIDE SHELF ASSEMBLY

a. Insert the Left Side Shelf Assembly (EC and ED)

into the support brackets located on the right

side of the Burner Box Assembly (BA).

b. Ax the Left Side Shelf Table (EC) to the Burner

Box Assembly (BA) as shown in gures B and C.

c. Ax the Left Side Shelf Fascia (ED) to the

Control Panel (CA).

Securely tighten all hardware.

YOU WILL NEED:

X 3

YOU WILL NEED:

X 4

View, under left side shelf

Back view

Front, left side view

View, under left side shelf

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels MasterChef Gril

MasterChef

MasterChef G36401 Manuel utilisateur

MasterChef

MasterChef 85-3138-4 / G45329 Manuel utilisateur

MasterChef

MasterChef COMPETITOR RSH-014349 Manuel utilisateur

MasterChef

MasterChef T420 Manuel utilisateur

MasterChef

MasterChef TF2201804-MC Manuel utilisateur

MasterChef

MasterChef 085-3605-2 Manuel utilisateur

MasterChef

MasterChef 085-3602-8 Manuel utilisateur

MasterChef

MasterChef ELITE G45325 Manuel utilisateur

MasterChef

MasterChef 76 cm (30?) Guide rapide

MasterChef

MasterChef S480 Manuel utilisateur

MasterChef

MasterChef 085-3175 Manuel utilisateur

MasterChef

MasterChef C0NB903A Manuel utilisateur

MasterChef

MasterChef s380 Manuel utilisateur

MasterChef

MasterChef 85-1035-0 Guide rapide

MasterChef

MasterChef 085-2202-6 Manuel utilisateur

MasterChef

MasterChef 85-3039 Manuel utilisateur

MasterChef

MasterChef 280 Manuel utilisateur

MasterChef

MasterChef E500 Manuel utilisateur

MasterChef

MasterChef T360 Guide rapide

MasterChef

MasterChef BG1207G4 Manuel utilisateur

MasterChef

MasterChef RSH-015050 Manuel utilisateur

MasterChef

MasterChef E480 Manuel utilisateur

MasterChef

MasterChef S280 Manuel utilisateur

MasterChef

MasterChef 85-1261-0 Guide rapide

Manuels Gril populaires d'autres marques

Orbegozo

Orbegozo GR 2300 Manuel utilisateur

bora

bora PT11 Manuel utilisateur

Klarstein

Klarstein 10031664 Manuel utilisateur

Garland

Garland MWE3W Manuel utilisateur

Char-Broil

Char-Broil 463722714 Manuel utilisateur

Nexgrill

Nexgrill 720-0830HK Manuel utilisateur

Kenmore

Kenmore 415.16123800 Manuel utilisateur

Camp Chef

Camp Chef PG24CLAU Manuel utilisateur

Tucker Barbecues

Tucker Barbecues GTR Series Instructions de montage

Monogram

Monogram ZGG540NCP1SS Manuel utilisateur

Equipex

Equipex Sodir Savoy Manuel utilisateur

Gaggenau

Gaggenau VR 414 610 Manuel utilisateur

Miele

Miele KM 408-1 Manuel utilisateur

George Foreman

George Foreman GGR50B Manuel utilisateur

AOG

AOG T series Manuel utilisateur

Gorenje

Gorenje TG2000CB Mode d’emploi

Weber

Weber Genesis Silver-B Permamount NG 051701 Manuel utilisateur

Glen

Glen SA 3037 Manuel utilisateur