Storage Canopy C604015S Manuel utilisateur

SHELTER ASSEMBLY MANUAL

Model # C604015S

W18x L12x H4.5m

C604015S Parts list

Part Code

Description

Qty

Top Bent Tube

Side Bent Tube on the top

Side Bent Tube on the bottom

Lower Bent Tube

Purlin

Top Steel wire

Clips

8LA

Left Base Plate

Left Base Plate in the middle

8RB

Right Base Plate

Right Base Plate in the middle

Ratchet

Nylon band for ratchet

Tensioning Tube

2 Groups

Bolts M12x40

204

12A

Tool

Bolts M10x80

Roof Cover

Knitting Rope for Cover

Plastic Plug

Base plates for roof cover

Inner standing leg

19LA

Left base plates for left standing leg

19L

Middle base plates for left standing leg

19RA

Right base plates for right standing leg

19R

Middle base plates for right standing leg

Bolts M8x80

PVC tube

2 Groups

Angle iron for base plate

SPECIFICATION

Length: 18m Width: 12m Height: 4.5m

IMPORTANT -----READ MANUAL FIRST

Improper site preparation, Assembly and Maintenance may invalidate warranty and cause

unnecessary and costly mistake. If you have any questions contact your local dealer.

For User Friendly assembly we have identified each individual component with the part code as

indicated in the parts list. Please refer to the part code numbers and drawing to ensure problem free

assembly.

It’s necessary to tighten the roof fabric enough to avoid “hammocks” on the roof and also re-tighten

once or twice again after a few months of use. This is important when assembly in cold weather

(autumn and winter) because the fabric is stiff then and when we got the sun and warm weather

afterwards it will make the fabric “slack” again and need to be re-tighten before next winter.

It’s the owners responsibility to take of snow immediately if not slide off by itself.

READ ALL INSTRUCTIONS BEFOREASSEMBLY

1. Keep work area clean. Cluttered areas invite injuries. Do not set up near snow drifts, in slippery

places, in high winds, or wet location.

2. Keep children away. All children should be kept away from the work area.

3. Don’t over reach. Keep proper footing and balance at all times.

4. Do not assemble in under the influence of alcohol or drugs. Read warning labels on

prescriptions to determine if your judgment or reflexes are impaired while taking drugs. If there

is any doubt, do not assemble.

5. Be aware of possible windy conditions; fasten the bases in concrete if these conditions are likely

to occur. Remove the cover during hurricane.

6. Be careful with power and heat sources. Do not keep heat sources near the tarpaulin. Do not

expose to open flame.

7. Be aware of personal safety during assembly and use. Be careful not to pinch fingers with clips

and tubes when assembling: when using makes sure there is adequate ventilation for exhaust

and other dangerous fumes.

EQUIPEMNT AND TOOLS FOR INSTALIATION

1. Measuring tape

2. String for alignment

3. Step ladder

4. Welder

5. Sledge hammer

6. Wrench

7. Scissors

INSTALLATION PROCESS

A—BASE INSTALLATION

Please refer to the diagram (Figure 1) to place the base plates. UNIT: mm

Figure 1

1. The measure if from center to center of the tubes. Referring to the above diagram and confirm the

place of the base plates. ENSURE THAT THE FOUNDATIONS IS SQUARE.

2. All the base plates need to use welder to be welded on the Containers.

Figure 2: Size: L18 x W12 x H4.5m

B—FRAME INSTALLATION

Figure 3

Figure 4

Figure 5

D—INSTRUCTION THE ROOF COVER

Figure 6

Figure 7

NOT install the cover onto the frame of your building in high wind conditions. A slight breeze is the most

advantageous for cover installation. To take advantage of the breeze, pull the cover up over the arches with

the breeze blowing in the cover like a sail filled with air.

NOTE: DO NOT LEAVE THE ROOF COVER UNATTACHED UNDER ANY CIRCUMSTANCES until the

final assembly and tightening has been completed. The process is quite easy. But some tightening adjustments will

be necessary to produce a flat, tension ed roof cover. Please adjust the roof cover every month.

Table des matières

Autres manuels Storage Canopy Abri

Storage Canopy

Storage Canopy C4020 Manuel utilisateur

Storage Canopy

Storage Canopy C4040R Manuel utilisateur

Storage Canopy

Storage Canopy FB406021P Manuel utilisateur

Storage Canopy

Storage Canopy C4060DTR Manuel utilisateur

Storage Canopy

Storage Canopy 33x40x12 Manuel utilisateur

Storage Canopy

Storage Canopy FB335017P Manuel utilisateur

Storage Canopy

Storage Canopy FB408021P Manuel utilisateur

Storage Canopy

Storage Canopy W33 x L40 x H12 ft Manuel utilisateur

Storage Canopy

Storage Canopy C3340R Manuel utilisateur

Storage Canopy

Storage Canopy C4080S Manuel utilisateur

Storage Canopy

Storage Canopy C3340DTR Manuel utilisateur

Storage Canopy

Storage Canopy C3340S Manuel utilisateur

Storage Canopy

Storage Canopy FB408021DP Manuel utilisateur

Storage Canopy

Storage Canopy EWC6040DTR Manuel utilisateur

Storage Canopy

Storage Canopy DT Container shelter Manuel utilisateur

Storage Canopy

Storage Canopy C2620 Manuel utilisateur

Storage Canopy

Storage Canopy C3340 Manuel utilisateur

Storage Canopy

Storage Canopy C3340DTPR Manuel utilisateur

Storage Canopy

Storage Canopy 26x40x10 Container Shelter Single truss Manuel utilisateur

Storage Canopy

Storage Canopy 40x40x15 Manuel utilisateur

Storage Canopy

Storage Canopy SHELTER Manuel utilisateur

Storage Canopy

Storage Canopy C3340 Manuel utilisateur

Storage Canopy

Storage Canopy C4040S Manuel utilisateur

Storage Canopy

Storage Canopy Two Car Garage Shelter Manuel utilisateur

Manuels Abri populaires d'autres marques

Tempo Fitness

Tempo Fitness S11 Manuel utilisateur

Tuindeco

Tuindeco 42.7906 Manuel utilisateur

No Butts Bin

No Butts Bin SR1605 Manuel utilisateur

TMG

TMG TMG-DT5040CG Manuel utilisateur

TMG

TMG TMG-DT3063-PRO Manuel utilisateur

EAGLE CLAW

EAGLE CLAW Shappell DX4000 Manuel utilisateur

Kampa

Kampa Poled Shelter 300 Manuel utilisateur

Harnois

Harnois TA-R Manuel utilisateur

Shelters4Less

Shelters4Less SR1551 Manuel utilisateur

TMG

TMG TMG-DT50FW8 Manuel utilisateur

Vikre Handel AS

Vikre Handel AS JIT-1216 Manuel utilisateur

VARNA buildings

VARNA buildings C2020H Manuel utilisateur

Frabill

Frabill ICE HUNTER 195 Manuel utilisateur

Shelters4Less

Shelters4Less SR1588 Manuel utilisateur

Sealey

Sealey Power Products GSS150819SD Manuel utilisateur

Crivit

Crivit 104155 Manuel utilisateur

No Butts Bin

No Butts Bin SR1558-F Manuel utilisateur

TMG

TMG TMG-ST3040C Manuel utilisateur