Sony MAV-555A Manuel utilisateur

MULTI ACCESS VIDEO DISK RECORDER

MAV-555A

AD/DA CONVERTER BOARD

BKMA-513

ASYNCHRONOUS NETWORK BOARD

BKMA-550

MAINTENANCE MANUAL

1st Edition (Revised 1)

MAV-555A

!WARNING

This manual is intended for qualified service personnel only.

To reduce the risk of electric shock, fire or injury, do not perform any servicing other than that

contained in the operating instructions unless you are qualified to do so. Refer all servicing to

qualified service personnel.

!WARNUNG

Die Anleitung ist nur für qualifiziertes Fachpersonal bestimmt.

Alle Wartungsarbeiten dürfen nur von qualifiziertem Fachpersonal ausgeführt werden. Um die

Gefahr eines elektrischen Schlages, Feuergefahr und Verletzungen zu vermeiden, sind bei

Wartungsarbeiten strikt die Angaben in der Anleitung zu befolgen. Andere als die angegeben

Wartungsarbeiten dürfen nur von Personen ausgeführt werden, die eine spezielle Befähigung

dazu besitzen.

!AVERTISSEMENT

Ce manual est destiné uniquement aux personnes compétentes en charge de l’entretien.Afin

de réduire les risques de décharge électrique, d’incendie ou de blessure n’effectuer que les

réparations indiquées dans le mode d’emploi à moins d’être qualifié pour en effectuer d’autres.

Pour toute réparation faire appel à une personne compétente uniquement.

MAV-555A (SY) Serial No. 10001 and Higher

BKMA-513 (SY) Serial No. 10001 and Higher

BKMA-550 (SY) Serial No. 10001 and Higher

MAV-555A

Voor de klanten in Nederland

Dit apparaat bevat een MnO2-Li batterij voor memory

back-up.

Raadpleeg uw leverancier over de verwijdering van de

batterij op het moment dat u het apparaat bij einde

levensduur afdankt.

Gooi de batterij niet weg. maar lever hem in als KCA.

Bij dit produkt zijn batterijen geleverd.

Wanneer deze leeg zijn, moet u ze niet

weggooien maar inleveren als KCA.

Für Kunden in Deutschland

Entsorgungshinweis: Bitte werfen Sie nur entladene

Batterien in die Sammelboxen beim Handel oder den

Kommunen. Entladen sind Batterien in der Regel dann,

wenn das Gerät abschaltet und signalisiert “Batterie

leer”oder nach längerer Gebrauchsdauer der Batterien

“nicht mehr einwandfrei funktioniert”. Um

sicherzugehen, kleben Sie die Batteriepole z.B. mit

einem Klebestreifen ab oder geben Sie die Batterien

einzeln in einen Plastikbeutel.

CAUTION

Danger of explosion if battery is incorrectly replaced.

Replace only with the same or equivalent type

recommended by the manufacturer.

Dispose of used batteries according to the

manufacturer’s instructions.

Vorsicht!

Explosionsgefahr bei unsachgemäßem Austausch

der Batterie.

Ersatz nur durch denselben oder einen vom

Hersteller empfohlenen ähnlichen Typ. Entsorgung

gebrauchter Batterien nach Angaben des

Herstellers.

ATTENTION

Il y a danger d’explosion s’il y a remplacement

incorrect de la batterie.

Remplacer uniquement avec une batterie du même

type ou d’un type équivalent recommandépar le

constructeur.

Mettre au rebut les batteries usagées conformément

aux instructions du fabricant.

ADVARSEL!

Lithiumbatteri-Eksplosionsfare ved fejlagtig

håndtering.

Udskiftning måkun ske med batteri

af samme fabrikat og type.

Levér det brugte batteri tilbage til leverandøren.

ADVARSEL

Lithiumbatteri - Eksplosjonsfare.

Ved utskifting benyttes kun batteri som

anbefalt av apparatfabrikanten.

Brukt batteri returneres

apparatleverandøren.

VARNING

Explosionsfara vid felaktigt batteribyte.

Använd samma batterityp eller en likvärdig typ

som rekommenderas av apparattillverkaren.

Kassera använt batteri enligt gällande

föreskrifter.

VAROITUS

Paristo voi räjähtää jos se on virheellisesti

asennettu.

Vaihda paristo ainoastaan laitevalmistajan

suosittelemaan tyyppiin.

Hävitäkäytetty paristo valmistajan ohjeiden

mukaisesti.

1 (P)

1 (E)

MAV-555A

Table of Contents

Manual Structure

Purpose of this manual ........................................................................................ 5 (E)

Related manuals................................................................................................... 5 (E)

Contents ............................................................................................................... 6 (E)

Trademarks .......................................................................................................... 6 (E)

1. Error Message/Maintenance Functions

1-1. Error Message .......................................................................................1-1 (E)

1-1-1. Normal Indication ................................................................1-1 (E)

1-1-2. Error Indication ....................................................................1-2 (E)

1-2. Acquiring the Logs................................................................................1-3 (E)

1-2-1. How to Aquire the Logs of the MAV-555A ........................1-3 (E)

1-2-2. How to Acquire the Logs of the BKMA-550.......................1-6 (E)

1-3.

Backing Up and Restoring the Contents of Memory (FM-81 board)....

1-10 (E)

1-4. Upgrading the Software ......................................................................1-13 (E)

1-4-1. How to Upgrading the MAV-555A Software Version ......1-13 (E)

1-4-2. How to Upgrading the BKMA-550 Software Version ......1-16 (E)

1-5. Upgrading the PLD Version................................................................1-24 (E)

2. Service Overview

2-1. Setup when Replacing Board or Battery is Replaced ...........................2-1 (E)

3. Parts and Board Replacement

3-1. Cautions before Servicing .....................................................................3-1 (E)

3-2. Removing the Cabinet...........................................................................3-2 (E)

3-2-1. Removing the Ornamental Bar, Ornamental Plate,

Blank Panel and Ornamental Panel......................................3-2 (E)

3-2-2. Removing the Top Plate and Rear Panel..............................3-4 (E)

3-3. Main Parts and Board Layout Diagram ................................................3-6 (E)

3-4. Replacing the Main Parts ......................................................................3-7 (E)

3-4-1. Power Supply .......................................................................3-7 (E)

3-4-2. Fan ........................................................................................3-7 (E)

3-4-3. Filter .....................................................................................3-8 (E)

3-4-4. Backup Battery.....................................................................3-9 (E)

3-4-5. HDD Unit ...........................................................................3-10 (E)

3-4-6. FL Display Tube (Indicator Tube) .....................................3-11 (E)

2 (E) MAV-555A

3-5. Replacing the Boards ..........................................................................3-12 (E)

3-5-1. Replacing the Plug-in Boards.............................................3-12 (E)

3-5-2. CN-2180 Board ..................................................................3-12 (E)

3-5-3. SDI-68 Board .....................................................................3-12 (E)

3-5-4. CN-2178 Board ..................................................................3-13 (E)

3-5-5. CN-2179 Board ..................................................................3-14 (E)

3-5-6. CN-1830 Board ..................................................................3-14 (E)

3-5-7. MB-947 Board ...................................................................3-17 (E)

4. Electrical Adjustment

4-1. General Information for Electrical Adjustment ....................................4-1 (E)

4-1-1. Equipment Required.............................................................4-1 (E)

4-1-2. Notes for Adjustment ...........................................................4-1 (E)

4-2. EM-3 Board Adjustment .......................................................................4-2 (E)

4-2-1. Video Monitor Out Level Adjustment .................................4-2 (E)

4-3. SDI-68 Board Adjustment.....................................................................4-3 (E)

4-3-1. SDI Free-Run Adjustment....................................................4-3 (E)

4-4. FM-81 Board Adjustment .....................................................................4-4 (E)

4-4-1. SCH DET Adjustment (525/60 mode) .................................4-4 (E)

4-4-2. SCH DET Adjustment (625/50 mode) .................................4-6 (E)

4-5. ADA-61 Board (BKMA-513) Adjustment ...........................................4-8 (E)

4-5-1. Audio Level Adjustment ......................................................4-8 (E)

4-5-2. Analog Audio Input Adjustment ........................................4-10 (E)

4-5-3. Distortion Adjustment ........................................................4-11 (E)

4-5-4. Preparation before Video Adjustment................................4-12 (E)

4-5-5. D/A Video Level Adjustment ............................................4-15 (E)

4-5-6. Setting upon Completion of Adjustment............................4-16 (E)

4-5-7. A/D Pedestal Video Level Adjustment ..............................4-17 (E)

4-5-8. A/D AGC Video Level Adjustment ...................................4-18 (E)

4-5-9. A/D Manual Video Level Adjustment ...............................4-19 (E)

4-5-10. A/D Video Adjustment 2 ...................................................4-19 (E)

4-5-11. Setting upon Completion of Adjustment............................4-19 (E)

5. Circuit Description

5-1. MAV-555A ...........................................................................................5-1 (E)

5-2. BKMA-550 ...........................................................................................5-4 (E)

3 (E)

MAV-555A

6. Spare Parts

6-1. Notes on Repair Parts..................................................................................6-1

6-2. Exploded Views ..........................................................................................6-2

6-3. Electrical Parts List ...................................................................................6-13

6-3-1. MAV-555A ..............................................................................6-13

6-3-2. BKMA-513 ..............................................................................6-14

6-3-3. BKMA-550 ..............................................................................6-14

7. Block Diagrams and Frame Wiring

Overall ....................................................................................................................7-3

ADA-61A/61B (BKMA-513) ................................................................................7-4

DM-127 ..................................................................................................................7-6

DPR-189A/189B ....................................................................................................7-8

EM-3.....................................................................................................................7-12

FP-128 ..................................................................................................................7-13

FM-81 ...................................................................................................................7-14

IF-837 ...................................................................................................................7-16

IF-860/PG-40A (BKMA-550)..............................................................................7-17

PU-121..................................................................................................................7-19

Frame Wiring........................................................................................................7-20

5 (E)

MAV-555A

Manual Structure

Purpose of this manual

This manual is the maintenance manual of the MAV-555A Multi Access Video Disk

Recorder.

This manual is intended for use by trained system and service engineers, and

describes the information that premise the service based on components replacement

(error message/maintenance functions, service overview, parts and board replace-

ment, electrical alignment, circuit descriptions, spare parts, block diagrams, and

frame wiring).

Moreover, describes the information for the following optional board.

.AD/DA Converter Board : BKMA-513

.Asynchronous Network Board : BKMA-550

Related manuals Besides this maintenance manual, the following manuals are available for the

MAV-555A.

.MAV-555A Operation Manual (Supplied with MAV-555A)

This manual describes the operation and function of the MAV-555A.

.MAV-555A Installation Manual (Supplied with MAV-555A)

This manual describes the information regarding the installation of the MAV-555A.

.BKMA-505 Operation Manual (Supplied with BKMA-505)

This manual describes the operation and function of the BKMA-505.

.BKMA-505 Installation Manual (Supplied with BKMA-505)

This manual describes the information regarding the installation of the optional

control panel BKMA-505.

.BKMA-513 Installation Manual (Supplied with BKMA-513)

This manual describes the information regarding the installation of the optional

board BKMA-513.

.BKMA-550 Operation Manual (Supplied with BKMA-550)

This manual describes the operation and function of the BKMA-550.

.BKMA-550 Installation Manual (Supplied with BKMA-550)

This manual describes the information regarding the installation of the optional

board BKMA-550.

.BKMA-570 Installation Manual (Supplied with BKMA-570)

This manual describes the information regarding the installation of the optional

analog audio expansion unit BKMA-570.

6 (E) MAV-555A

Contents The following is a summary of all the section for understanding the contents of this

manual.

Section 1 Error Message/Maintenance Functions

This section describes the menu and error message, etc.

Section 2 Service Overview

This section describes the setting when the circuit board, memory, or battery is

replaced.

Section 3 Parts and Board Replacement

This section describes the removal of cabinet, replacement of main parts and boards.

Section 4 Electrical Adjustment

This section describes the electrical alignment when maintenance.

Section 5 Circuit Descriptions

This section describes the circuit description of main boards

Section 6 Spare Parts

This section describes spare parts.

Section 7 Block Diagrams and Frame Wiring

This section describes the overall block diagram, main board block diagram, and

frame wiring.

Trademarks Trademarks and registered trademarks used in this manual are follows.

.Ethernet is a registered trademark of Xerox Corporation.

.IBM is a registered trademark of International Business Machines Corporation.

.Windows is a registered trademark of Microsoft Corporation.

Autres manuels pour MAV-555A

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Sony Instrument de mesure

Sony

Sony PCM-D10 Guide de référence

Sony

Sony NEX-FS100C Manuel utilisateur

Sony

Sony TC-252 D Manuel utilisateur

Sony

Sony MZ-N920 Manuel utilisateur

Sony

Sony MDX-C800REC Manuel utilisateur

Sony

Sony TC-260 Manuel utilisateur

Sony

Sony LE-SP6800 Series Manuel d'installation et d'exploitation

Sony

Sony MZ-N10 Manuel utilisateur

Sony

Sony TC-730 Manuel utilisateur

Sony

Sony M-640V - Microcassette Recorder Manuel utilisateur

Sony

Sony XDBK-105 Manuel utilisateur

Sony

Sony DVW-250 Manuel utilisateur

Sony

Sony MG40 Series Manuel d'installation

Sony

Sony WatchCorder EVT-820 Manuel utilisateur

Sony

Sony DG805FLM Manuel utilisateur

Sony

Sony DG805FL Manuel utilisateur

Sony

Sony Betacam SX DNV-5 Manuel utilisateur

Sony

Sony WM-W800 Manuel utilisateur

Sony

Sony TC-788-4 Guide de configuration

Sony

Sony DG10B Series Manuel utilisateur

Sony

Sony DT12N Manuel utilisateur

Sony

Sony 3026 Manuel d'utilisation et d'entretien

Sony

Sony DG10B Series Manuel utilisateur

Sony

Sony MAVE-F555 Manuel utilisateur

Manuels Instrument de mesure populaires d'autres marques

Suaoki

Suaoki D40 Manuel utilisateur

Elster

Elster BK-G1.6 Manuel utilisateur

Endress+Hauser

Endress+Hauser Deltabar FMD71 Manuel

Duratool

Duratool D03128 Manuel utilisateur

Vega

Vega VEGAPULS 65 Manuel utilisateur

Tonghui

Tonghui TH2618B Manuel utilisateur

Tenmars

Tenmars TM-801 Manuel utilisateur

MSR

MSR 145 Manuel utilisateur

TPS

TPS WP-82 Manuel utilisateur

ELMETRON

ELMETRON CP-511 Manuel utilisateur

PCB Piezotronics

PCB Piezotronics 003C30 Manuel utilisateur

Tenma

Tenma 72-10465 Manuel utilisateur

Endress+Hauser

Endress+Hauser Proline Promag 50 Caractéristiques techniques

Siemens

Siemens SITRANS F Coriolis FCT030 Manuel de la liste des pièces

KLINGER

KLINGER CMF V Series Manuel utilisateur

EXFO

EXFO FTB-2 Manuel d'exploitation et d'entretien

Keysight

Keysight M8290A Manuel utilisateur

ADTEK

ADTEK MW-5 Manuel utilisateur