Philips FC9261 Manuel utilisateur

ServiceManual

Philips Consumer Lifestyle

Published by Philips Consumer Lifestyle Printed in the Netherlands © Copyright reserved Subject to modification

Vacuum cleaner

FC9261

11/03

PRODUCT INFORMATION

- This product meets the requirements regarding

interference suppression on radio and TV

- After the product has been repaired, it should function

properly and has to meet the safety requirements as

officially laid down at this moment

TECHNICAL INFORMATION

- Colour : Bordeaux red

- Power consumption : 2000 W (IEC) 230 V

- Maximum Air displacement : 37 l/s

- Vacuum : 27.5 kPa

- Duststorage capacity : 1.5 L

- Cord length : 9 m

- Motor : Infrared remote controlled

- Fiter system : HEPA cyclone-filtration

auto-clean system

: Permanent motor

protection filter

: Ultra Clean Air HEPA13

washable exhaust filter

- Dimensions of cleaner : 485 x 285 x 335 mm

- Net weight : 9.6 kg

ACCESSORIES

- Nozzle : All purpose nozzle

- Additional nozzle : Hard floor nozzle

- Tubes : Metal lacquered telescopic tube

- Handgrip : Ergonomic handgrip with remote

control

- Accessories : Brush, crevice nozzle and small nozzle

- Accessory storage : Active accessory storage bridge in

handgrip

- Coupling : Button coupling

OPTIONAL (accessories)

- FC 8031 : Super Clean Air HEPA filter

- FC 8038 : Super Clean Air HEPA washable filter

FC9261

DISASSEMBLY- AND RE-ASSEMBLY ADVISE

- To open the appliance, first remove the filter cover

(item 39).

- Remove the can with the filters.

- Then remove the hingecover (2 screws A)

- When the hinge cover is removed, the dustcover can be

removed.

- Now remove the drive coupling (item 13) by turning it

clockwise.

- To remove the housing (9 screws F), for some screws you

will require a screwdriver with 14.5 cm long shrank.

Screwdriver 4322 009 08490 for T15 can be used.

- When the repair is finished, check whether all functions of

the appliance work properly.

- To disassemble the cord winder, use TORX screwdriver no.

T10, which is one of a set consisting of T20; T15; T10; T9;

T8; T7 and T6 (code number 4822 395 50145)

ELECTRICAL DIAGRAM

REPAIR INSTRUCTION

- Due to precisely pre-adjusted belt-tension, rattle drive unit

(item 12) may only be replaced as a complete unit.

Do not disassemble this unit in any way!

- If the reel half spring unit is replaced, shaft (M) must be

lubricated with silicone grease. Do not apply any silicone

grease to or spill any grease on terminals (item 55) or

conductors (item 56).

- The cord winder spring must be tensioned to the maximum

level and the be rewound approx 1.5 turn.

- Item 15, air valve, opens to cool the motor if the air

displacement is too low or if the airflow is blocked.

RATTLE

DRIVE

MOTOR

Black

BlackBlack

Blue

Brown

Red

Blue

IR PCB

Switch

CORD

WINDER

TRANSMITTER

2-8

FC9261

- Appliances from before WK845 have a potential problem

in the cord winder system; the lever of spindle (Pos. 26) can

move out of position.

Symptom:

Cord will not rewind pressing the cord winder button.

Solution:

Remove the Cord winder button as shown in below picture:

Remove the cord winder button by simultaneously operating

the button and putting a screwdriver between the openings

that occur.

Then lift the button by levering the screwdriver.

This has to be done at 2 (two) positions as indicated in the

picture.

Insert a screwdriver (size 1) in the position as shown in below

picture and move it backwards until a “Click” is heard, the

lever of spindle is now back in position. This can be tested by

pressing lever A, the cord should rewind now.

“Click”

REPAIR INSTRUCTION

To prevent lever shifting out of position to re-occur,

CW support (Pos. 71) must be added as shown in below

pictures:

Rotate the part 90 degrees CCW, once it is inside the housing

half way.

90°

CCW

90°

CCW

Then drop the part till it is completely inside the appliance

and push down with a screwdriver untill “Click”.

“Click”

Finally re-assemble the button.

Press it ﬁrmly, until the “Click”.

3-8

FC9261

PARTS LIST

4-8

Pos Service code Description

4322 005 25400

4322 003 34210

4322 003 34200

4322 003 34180

4322 005 25480

4322 003 34160

4322 000 68230

4322 003 34230

4322 001 73910

4322 003 34220

4322 003 35180

4322 005 23140

4322 005 19600

4322 003 35210

4322 005 26540

4322 009 09860

4322 003 32920

4322 005 25420

4322 004 20130

4322 005 24220

4322 003 34140

4322 005 27210

4322 005 27470

4322 006 23530

4322 001 74100

4322 003 31310

4322 003 34070

4322 003 34060

4322 005 25470

4322 000 39120

4322 003 32890

4322 003 32900

4322 003 34150

4322 005 27220

4322 003 34110

Handle assy

Handle side rear

Handle side front

Handle support

Dustcover toppanel

Dustcover Bordeaux red

Spring

Dustc. lock button Bordeaux red

Dustcover sealing

Dustc. inside incl. seal. Bord. red

Choke valve cover Bordeaux red

Rattle drive unit assy

Coupling assy

Hinge cover Bordeaux red

Choke valve assy

Rattle ﬁlter cyl. assy Bord. red

Tower assy

Bucket assy Transp. Aqua

Filter Brush

Upperh. sidec. assy Transp. Aqua

Bumper right Bordeaux red

Cordwinder button Bordeaux red

RMC window assy

PCB assy incl. IR

Cooling tube

Lever of spindle

Front handle Bordeaux red

Lower housing Bordeaux red

Caster wheel assy Bordeaux red

Motor inlet ﬁlter

Inlet sealing 2

Switch lever

Bumper left Bordeaux red

On/Off button Bordeaux red

Backpanel Bordeaux red

Pos Service code Description

38*

4322 006 07750

4322 003 34100

4322 005 27781

4322 005 23940

4322 004 93350

4322 000 38960

4322 000 39020

4322 003 31220

4322 000 39000

4322 000 39010

4322 003 25390

4322 003 31240

4322 001 73440

4322 009 09430

4322 000 39110

4322 003 26030

4322 001 73520

4322 003 31250

4322 005 18670

4322 005 17430

4322 005 17910

4322 006 07410

4322 006 07390

4322 006 07400

4322 005 25770

4322 009 09930

4322 005 27430

4322 009 09940

4322 005 25790

4322 003 34660

4322 005 25800

4322 004 20580

4322 005 27340

4322 004 23820

4322 004 23770

4322 003 35650

Switch

Cord outlet Bordeaux red

Skate wheel assy Left & Right

Exhaust grille assy Autumn Grey

HEPA13 ﬁlter washable

Exhaust sealing

Silencer 4

S-class H sealing

Silencer 1 wall

Silencer 2 bottom

Inlet sealing 1

Motorhousing top

Motorbuffer front

Motor 1761 220 - 240 V

Silencer 3 VCM

Motor bracket

Bufferback green

Motorhousing bottom

Reelhalf spring unit

Reelhalf cordside assy

Contactplate assy

Cordset UK/HK 9.3 m

Cordset Euro 4.8 mm 9.3 m

Cordset Swiss 9.3 m

Battery lid assy

Bend type 1 assy

Hose/connection assy Bord. red

Hose/connection/bend

type 1 assy Bordeaux red

Accessoiry holder

Crevice nozzle

Small nozzle

Brush tool

2pc Telescopic tube assy

RD264 Nozzle stand.

Hard ﬂoor nozzle

CW Support

* Standardized colour

= changed

FC9261

EXPLODED VIEW

Blue

Red

5-8

FC9261

EXPLODED VIEW

Black Black

Red

Brown

Black

Blue

Black

Blue

6-8

FC9261

EXPLODED VIEW

Blue

Brown

57 59

Black

7-8

FC9261

EXPLODED VIEW

Europe Ø 4.8mm 58

Swiss

57U.K. / H.K. 59

61 62

8-8

Table des matières

Autres manuels Philips Aspirateur

Philips

Philips HR6016/03 Manuel utilisateur

Philips

Philips City Line FC8434 Manuel utilisateur

Philips

Philips Ledino 41621/48/16 Manuel utilisateur

Philips

Philips FC8760/01 Manuel utilisateur

Philips

Philips FC 9104 Manuel utilisateur

Philips

Philips FC8956 Manuel utilisateur

Philips

Philips FC9728/01 Manuel utilisateur

Philips

Philips Jack HR6072 Manuel utilisateur

Philips

Philips FC8796 Manuel utilisateur

Philips

Philips FC9202 Manuel utilisateur

Philips

Philips FC8740 Manuel utilisateur

Philips

Philips FC8188 Manuel utilisateur

Philips

Philips Performer Manuel utilisateur

Philips

Philips FC8660 Manuel utilisateur

Philips

Philips Impact Excel Manuel utilisateur

Philips

Philips SmartPro FC8794/01 Manuel utilisateur

Philips

Philips SmallStar FC8234/01 Manuel utilisateur

Philips

Philips FC8445 Manuel utilisateur

Philips

Philips Marathon FC9200 Manuel utilisateur

Philips

Philips StudioPower FC9080 SERIES Manuel utilisateur

Philips

Philips City Line FC8432 Manuel utilisateur

Philips

Philips FC9088 Manuel utilisateur

Philips

Philips FC9258 Manuel utilisateur

Philips

Philips FC6172 Manuel utilisateur

Manuels Aspirateur populaires d'autres marques

Bissell

Bissell LittleGreen Proheat 1425 Series Manuel utilisateur

Panasonic

Panasonic MC-YL637S147-AE Manuel utilisateur

NEFF

NEFF N17XH10 0 Series Manuel utilisateur

LG A9 Series Manuel utilisateur

Oreck

Oreck Cordless Captura BK51700 Series Manuel utilisateur

Kogan

Kogan KAVACROBVWA Manuel utilisateur

Kränzle

Kränzle VENTOS 50 ID Guide de l'utilisateur

EVVO

EVVO Ai35 Manuel utilisateur

DeWalt

DeWalt DWH200D Manuel utilisateur

Pontec

Pontec Pondomatic Vacuum Cleaner Manuel utilisateur

Cleanmaxx

Cleanmaxx PC-P007E Manuel utilisateur

Exido

Exido 240-114 Manuel utilisateur

RIDGID

RIDGID WD1685AU0 Manuel utilisateur

Ezviz

Ezviz RE4P Manuel utilisateur

STG global

STG global TANVAC HDV3000 Manuel utilisateur

Shark

Shark ROTATOR PRO COMPLETE NV550 Series Manuel utilisateur

Factory

Factory M3340 Manuel utilisateur

Shop-Vac

Shop-Vac VN92 SERIES Manuel utilisateur