Fujitsu Fi-6800 Guide de configuration

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

fi-6800 CONSUMABLE REPLACEMENT

AND CLEANING INSTRUCTIONS

CG00002-020901C

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

CONSUMABLES LIST

Description Qty Life Fujitsu P/N

Pick Rollers 1 Set 600,000 PA03575-K011

Separator Roller 1 600,000 PA03575-K012

Brake Roller 1 600,000 PA03575-K013

Note:

To insure the longest possible consumable life, it is strongly

recommended that all the consumables listed above be replaced at

the same time. Not replacing all the consumables at the same

time will decrease the life of the consumables.

NCR or Carbonless paper has chemical composition which damages

the consumables listed above. Cleaning of these items will be

needed more frequently to avoid feed problems. Also their life will be

reduced if this paper is scanned.

Pick Rollers

Brake Roller Separator Roller

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

REPLACING THE PICK ROLLERS

Worn, defective, or improperly installed Pick Rollers will cause misfeeds

and paper jams. The Pick Rollers have an approximate life of 600,000

pages. If NCR or carbonless paper is used the life span of the Pick

Rollers may be decreased by half.

Tab Roller Cover

Pick Roller

• Make sure there is no paper

in the stacker.

• Grab the ADF Release Tab

and lift it up to open the ADF.

Note:

When you stop pushing up on the ADF it stays at that location.

• Open the Roller Cover by

grabbing the tabs on the left

and right sides with your

fingers and pull down.

• Pull out on the tab that locks

the Pick Roller in place in

the direction of the arrow and

slide the Pick Roller off the

shaft.

• Repeat the procedure above

to remove the second Pick

Roller.

Note:

The roller shaft and the hole in the Pick Rollers are keyed and will only

slide on in one orientation.

• Install the new Pick Rollers

by aligning the hole in the

rollers with the roller shaft.

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

REPLACING THE PICK ROLLERS (CONT.)

• Install the new Pick Rollers

by aligning the hole in the

rollers with the roller shaft.

• Close the Roller Cover.

• Close the ADF Cover.

• Reset the Pick Roller

Counter in the Software

Operation Panel or on the

Scanner Operator Panel.

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

REPLACING THE SEPARATOR ROLLER

A worn or improperly installed Separator Roller will cause multiple feeds

and paper jams. Separator Roller has an approximate life of 600,000

pages. If NCR or carbonless paper is used the life span of the these

rollers may be decreased by half.

Tab Roller Cover

Lever

Separator Roller

Lever

Separator Roller

• Make sure there is no paper

in the stacker.

• Grab the ADF Release Tab

and lift it up to open the ADF.

Note:

When you stop pushing up on the ADF it stays at that location.

• Open the Roller Cover by

grabbing the tabs on the left

and right sides with your

fingers and pull down.

• Pull down the lever which is

located on the right side of

the Separator Roller.

• Pull down the lever which is

located on the left side of the

Separator Roller.

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

• Pull the lever on the left side

of the Separator Roller

towards you and remove it

along with the shaft.

• Install the new Separator

Roller by inserting the right

side of the shaft first, then

the left side so that the tab

fits in the groove.

• Push up the lever which is

located on the left side of the

Separator Roller.

• Push up the lever which is

located on the right side of

the Separator Roller.

Tab

Separator Roller

Lever

REPLACING THE SEPARATOR ROLLER (CONT.)

Separator Roller

Lever

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

REPLACING THE SEPARATOR ROLLER (CONT.)

• Close the Roller Cover.

Note:

Make sure that both ends of the cover are locked firmly.

• Close the ADF Cover.

• Reset the Separator Roller

Counter in the Software

Operation Panel or on the

Scanner Operator Panel.

Roller Cover

Separator

Roller

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

REPLACING THE BRAKE ROLLER

A worn or improperly installed Brake Roller will cause multiple feeds and

paper jams. The Brake Roller has an approximate life of 600,000 pages.

If NCR or carbonless paper is used the life span of the Brake Roller may

be decreased by half.

• Make sure there is no paper

in the stacker.

• Grab the ADF Release Tab

and lift it up to open the ADF.

Note:

When you stop pushing up on the ADF it stays at that location.

• Grab the Roller Cover by the

lower middle and lift to open.

• Lift the left side of the Brake

Roller and then pull the shaft

out from left to right.

• Install the new Brake Roller

by inserting the right end of

the shaft into the mounting

hole, then place the left end

into the mounting bracket.

• Close the Roller Cover.

Roller Cover

Brake

Roller

Brake

Roller

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

REPLACING THE BRAKE ROLLER (CONT.)

• Close the ADF Cover.

• Reset the Brake Roller Counter in the Software Operation Panel or on

the Scanner Operator Panel.

fi-6800 CONSUMABLE REPLACEMENT AND CLEANING INSTRUCTIONS

CHECKING AND RESETTING THE CONSUMABLE & CLEANING COUNTERS

The following instructions show you how to check the life count of each

consumable and also how to reset the counter after the consumables

have been replaced. To insure accurate consumable life tracking, it

is very important to reset the consumable counters every time

consumables are replaced.

CHECKING CONSUMABLE COUNTS

• Turn on the scanner and confirm it is communicating properly to your

PC.

• From the START MENU, select ALL PROGRAMS/SCANNER UTILITY FOR

MICROSOFT WINDOWS/SOFTWARE OPERATION PANEL.

• The SOFTWARE OPERATION PANEL opens.

• From the listing on the left, select Device Setting

Autres manuels pour fi-6800

Table des matières

Autres manuels Fujitsu Scanner

Fujitsu

Fujitsu SV600 Instructions de montage

Fujitsu

Fujitsu fi-6800 Manuel utilisateur

Fujitsu

Fujitsu fi-65F Manuel

Fujitsu

Fujitsu M4097D - Fb 50PPM SCSI A3 Dupl 100Sht Adf Manuel

Fujitsu

Fujitsu N7100 Manuel

Fujitsu

Fujitsu PA03360-B525 Manuel

Fujitsu

Fujitsu fi-4860C Manuel

Fujitsu

Fujitsu SV600 Manuel utilisateur

Fujitsu

Fujitsu FI-4860C2 Manuel utilisateur

Fujitsu

Fujitsu PA03541-B105 Manuel

Fujitsu

Fujitsu ScanSnap S1100i Manuel utilisateur

Fujitsu

Fujitsu SCANPARTNER 600C Manuel utilisateur

Fujitsu

Fujitsu fi 5750C - Document Scanner Manuel utilisateur

Fujitsu

Fujitsu fi-4220C2 Guide de configuration

Fujitsu

Fujitsu fi-5650C Guide de configuration

Fujitsu

Fujitsu ScanSnap S1300i Instructions de montage

Fujitsu

Fujitsu M3097E Plus Manuel

Fujitsu

Fujitsu ScanSnap iX500 Manuel utilisateur

Fujitsu

Fujitsu ScanSnap S1100 Manuel utilisateur

Fujitsu

Fujitsu ScanSnap S1100 Manuel utilisateur

Fujitsu

Fujitsu S1500 - ScanSnap Deluxe Bundle Manuel utilisateur

Fujitsu

Fujitsu fi-5530C - Document Scanner Manuel utilisateur

Fujitsu

Fujitsu S510M - ScanSnap - Document Scanner Manuel utilisateur

Fujitsu

Fujitsu FI 6140 - Document Scanner Manuel utilisateur

Manuels Scanner populaires d'autres marques

Plustek

Plustek Scanner Manuel utilisateur

Z/I Imaging

Z/I Imaging PhotoScan 2001 Manuel utilisateur

Renkforce

Renkforce DS100-5M Manuel utilisateur

Image Access

Image Access WideTEK A2 Manuel utilisateur

Canon

Canon imageFORMULA CR-120N Manuel utilisateur

GeoSlam

GeoSlam ZEB Horizon Instructions d'installation

Kodak

Kodak i5800 Scanner Manuel utilisateur

Kodak

Kodak i7300 Manuel utilisateur

Revopoint

Revopoint POP Manuel utilisateur

Eddyfi Technologies

Eddyfi Technologies Floormap X Manuel utilisateur

Faselase

Faselase F6 Manuel utilisateur

Uniden

Uniden BC340CRS Manuel utilisateur

Infinite Peripherals

Infinite Peripherals INFINEA TAB M Manuel utilisateur

Mustek

Mustek PageExpress 4800 Pro Manuel utilisateur

Optex

Optex 750830 Manuel utilisateur

Innova

Innova 5210 Manuel utilisateur

Visioneer

Visioneer CardReader 100 Guide de démarrage rapide

Rohde & Schwarz

Rohde & Schwarz TSME6 Manuel utilisateur

Fujitsu fi-6800 Guide de configuration

Manuels Scanner populaires d'autres marques