Front Runner SSLD001 Manuel utilisateur

land rover defender 2.4

drawer kit

SSLD001

INSTALL TIME: 45 mins

IMPORTANT WARNING!

IT IS CRITICAL THAT ALL FRONT RUNNER PRODUCTS BE PROPERLY AND SECURELY ASSEMBLED AND ATTACHED TO YOUR

VEHICLE. IMPROPER ATTACHMENT COULD RESULT IN AN AUTOMOBILE ACCIDENT, AND COULD CAUSE SERIOUS BODILY

INJURY OR DEATH TO YOU OR TO OTHERS. YOU ARE RESPONSIBLE FOR ASSEMBLING AND SECURING ALL FRONT RUNNER

PRODUCTS TO YOUR VEHICLE, CHECKING THE ATTACHMENTS PRIOR TO USE, AND PERIODICALLY INSPECTING THE

PRODUCTS FOR ADJUSTMENT, WEAR, AND DAMAGE. THEREFORE, YOU MUST READ AND UNDERSTAND ALL OF THE

INSTRUCTIONS AND CAUTIONS SUPPLIED WITH YOUR FRONT RUNNER PRODUCT PRIOR TO INSTALLATION OR USE. IF YOU DO

NOT UNDERSTAND ALL OF THE INSTRUCTIONS AND CAUTIONS, OR IF YOU HAVE NO MECHANICAL EXPERIENCE AND ARE NOT

THOROUGHLY FAMILIAR WITH THE INSTALLATION PROCEDURES, YOU SHOULD HAVE THE PRODUCT INSTALLED BY A

PROFESSIONAL INSTALLER OR OTHER QUALIFIED PERSONNEL.

SSLD001_REV_A00

GET ORGANIZED...

Here is what you are looking at:

You will need:

13 mm Flat or Socket Wrench

4 mm Hex Key

4mm & 9mm Drill Bits

Drilling Machine

20mm Hole Punch

Clinch Nut Tool

Familiarize yourself with the parts and then step away from the work area and read through these

instructions from beginning to end. Take a moment as a little prep now may save you a lot of time later.

( A )

Item # Quantity Description

110 M6 Countersunk Cap Screw

2 1 Deck

3 4 M10 Flat Washer

412 M8x19x3 Flat washer

5 4 M6 Clinch Nut

6 4 M6 x 25 Countersunk Cap Screw

7 1 Drawer

SSLD001_REV_A00

INSTALLING DRAWER SYSTEM

Now with the Jump Seats removed,

Remove the Deck from the Drawer

System. To do this unscrew the ten M6

Countersunk Cap Screw from the Deck

with a 4mm Hex Key. As shown in the

diagram to the right. Retain the Screws

for reuse later.

( A )

Carefully place the Drawer System into the

vehicle and place the Deck back on to the

Drawer making sure that the Deck fits

between the left and right hand wheel arches.

Position the Drawer underneath the Deck so

that the Holes in the Deck line up with the

Screw Holes in the Drawer. With the holes

lined up, loosely screw two of the Counter

Sunk Cap Screws previously removed in

Step2A into the front two holes. Position the

Drawer System so that the Deck lines up with

the inside edge of the door jam, as indicated

by the arrow in the picture.

( B )

( C )

Remove the Deck again. Take care not to move the

Drawer

To install your Drawer System you will need to remove the Jump Seats form your vehicle first.

SSLD001_REV_A00

INSTALLING DRAWER SYSTEM CONT...

Using the drawer as a template, mark out the bottom

four bolt holes with a white marker. For the front two

holes lift the carpet slightly. There is a hole in either

corner of the drawer base. (See picture to the right) For

the rear two, unlatch the Drawer and open it out

partially. It may be easier to mark these two holes by

leaning over the rear seats from the inside of the vehicle.

( D )

Remove the Drawer from the vehicle exposing the marks you have just made.

Drill 4mm pilot holes through the carpet and the floor of the vehicle. Now lift up the Carpet and open up

the Pilot Holes with a 9mm Drill Bit. Punch four holes in the carpet where you have just drilled the Pilot

holes, with a 20mm Hole Punch. Lay the carpet back down and insert the Clinch Nuts (Item 5) into the

holes in the body and crimp firmly.

( E )

( F )

Stack three 19x3mm Fat Washers (Item 4) on top of the Clinch Nuts to compensate for the carpet

thickness. Carefully place the Drawer System on top of the stacked Washers. Fasten the Drawer System in

place with the M6x25 Countersunk Cup Screws and M10 Flat Washers (Item3 &6). Use a 4mm Hex Key to

firmly fasten the four Cap Screws.

Finally fit the Deck with the Ten Countersunk Cap Screws you removed in Step2A.

( G )

Congratulations, you have

completed your installation.

Take a step back and admire

your work. Good Job!

SSLD001_REV_A00

Autres manuels Front Runner Accessoires automobiles

Front Runner

Front Runner TRCA009 Manuel utilisateur

Front Runner

Front Runner SSDR012 Manuel utilisateur

Front Runner

Front Runner SSDS201 Manuel utilisateur

Front Runner

Front Runner JADA010 Manuel utilisateur

Front Runner

Front Runner MKIII Small Manuel utilisateur

Front Runner

Front Runner RRAC178 Manuel utilisateur

Front Runner

Front Runner KRLDT03L Mode d’emploi

Front Runner

Front Runner SLIMLINE II KRSO004T Manuel

Front Runner

Front Runner RRAC054 Manuel utilisateur

Front Runner

Front Runner LATF002 Manuel utilisateur

Front Runner

Front Runner TBRA034 Manuel utilisateur

Front Runner

Front Runner KSTF003T Manuel utilisateur

Front Runner

Front Runner SAFE010 Manuel utilisateur

Front Runner

Front Runner RRAC018 Manuel utilisateur

Front Runner

Front Runner RRAC120 Manuel utilisateur

Front Runner

Front Runner FAFE001 Manuel utilisateur

Front Runner

Front Runner SSDS111 Manuel utilisateur

Front Runner

Front Runner LAMG002 Manuel utilisateur

Front Runner

Front Runner GWTL101-2 Manuel utilisateur

Front Runner

Front Runner RRAC901 Manuel utilisateur

Front Runner

Front Runner RRAC119 Manuel utilisateur

Front Runner

Front Runner SSAM009 Manuel utilisateur

Front Runner

Front Runner SSDS115 Manuel utilisateur

Front Runner

Front Runner Easy-Out Manuel utilisateur

Manuels Accessoires automobiles populaires d'autres marques

James Baroud

James Baroud Odyssey Manuel utilisateur

Motorola

Motorola i50sx Manuel utilisateur

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manuel utilisateur

Feniex

Feniex T3 Manuel utilisateur

Renault

Renault 77 11 423 180 Manuel utilisateur

Kia

Kia E8300-4D000 Manuel utilisateur

Brink

Brink 756843 Manuel utilisateur

Whispbar

Whispbar K085W Manuel utilisateur

v.link

v.link CI-VL2-PC-HSD Manuel utilisateur

Viking

Viking Stack-Rack Guide de configuration rapide

Aries

Aries 203015 Manuel utilisateur

Choetech

Choetech AT0005 Manuel utilisateur

ZZ2

ZZ2 ZZAIR-PRO Manuel utilisateur

Holman

Holman 4A80L Manuel utilisateur

Thule

Thule 2075 Manuel utilisateur

Motorola

Motorola T325 Manuel utilisateur

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guide d'installation

DV8

DV8 FBJL-02 Manuel utilisateur