Front Runner FATF006 Manuel utilisateur

ENG

220 min

toyota 4 Runner (2009 - CURRENT)

Foot Rail

IMPORTANT WARNING!

Don’t be a hero and muscle through this without ﬁrst reading these ﬁtting instructions! Improper installation of this gear may void certain aspects of

your warranty.

Before you begin, take a moment and open all your Front Runner rack kit boxes and gather the assembly instructions for the various components.

A complete kit will contain:

1. A Front Runner Mounting System speciﬁc to your vehicle

2. A Front Runner Rack Tray or Load Bar Slats

This document will guide you through the assembly of the mounting system and assist you in ﬁtting the roof rack tray or load bars to your speciﬁc

vehicle.

Please refer to the next page for a list of all the components, quantities and tools required.

FATF006

READ ME FIRST

START HERE!

IT IS CRITICAL THAT ALL FRONT RUNNER PRODUCTS BE PROPERLY AND SECURELY ASSEMBLED AND ATTACHED TO YOUR VEHICLE. IMPROPER ATTACHMENT COULD

RESULT IN AN AUTOMOBILE ACCIDENT, AND COULD CAUSE SERIOUS BODILY INJURY OR DEATH. YOU ARE RESPONSIBLE FOR ASSEMBLING AND SECURING ALL FRONT

RUNNER PRODUCTS TO YOUR VEHICLE. CHECKING THE ATTACHMENTS PRIOR TO USE, AND PERIODICALLY INSPECTING THE PRODUCTS FOR ADJUSTMENT, WEAR AND

DAMAGE. THEREFORE YOU MUST READ AND UNDERSTAND ALL OF THE INSTRUCTIONS AND PRECAUTIONS SUPPLIED WITH YOUR FRONT RUNNER PRODUCT PRIOR TO

INSTALLATION OR USE. IF YOU DO NOT UNDERSTAND ALL OF THE INSTRUCTIONS AND CAUTIONS, OR IF YOU HAVE NO MECHANICAL EXPERIENCE AND ARE NOT THOROUGHLY

FAMILIAR WITH THE INSTALLATION PROCEDURES, YOU SHOULD HAVE THE PRODUCT INSTALLED BY A PROFESSIONAL INSTALLER OR OTHER QUALIFIED PERSONNEL.

IN THE BOX

FIGURE 1.1

1 2 X Front Foot Rail; 1xLH, 1xRH

2 2 X Rear Foot Rail; 1xLH, 1xRH

3 24 X Nut Cap M8

4 12 X Hex Bolt M8x40

5 12 X Spring Washer M8

6 24 X Flat Washer M8x16x1.6ss

7 12 X Hex Bolt M8x20

8 12 X Nyloc Nut M8

9 4 X Rivnut M8

10 6 X Spacer

11 8 X Button Head M6x16

12 2 X Joiner Plate

13 8 X Flat Washer M6x12x1ss

14 8 X Nyloc Nut M6

15 8 X Nut Cap M6

IN THE BOX TOOLS NEEDED

10mm

13mm

IN THE BOX

1GET ORGANIZED

Here is what you are looking at for FATF006

4mm

7mm Rivnut Setter

FATF006_REV_A00

FIT AND SECURE

13mm

2.1

2.2

2.3

Drill the pilot holes to 11.5mm and

secure two rivnuts (item 9) in the holes

by using a rivnut setter.

With the factory rails removed, use the

center of the existing front hole of the

roof rail, mark out the dimension as

shown on the ditch molding. Do this on

the left and right side.

Place the assembled foot rail over the

existing holes and markings to check.

5mm

11.5mm

520

570

Place the spacer (item 10) over the

marks you have made. Mark the

outsides of the spacer.

Drill 5mm pilot holes though the ditch

molding and the vehicles roof to mark.

Make sure not to drill to deap otherwise

you will damage the inside lining of the

roof.

Now cut the ditch molding on the marks

you have made so that the spacer can ﬁt

in the ditch.

FATF006_REV_A00

FIT AND SECURE

13mm

Place a bead of sealant in and over each

hole in the roof, then place a spacer

(item 10) over each hole.

Place the foot rail that you assembled in

step 2.4 on the spacers and loosely ﬁt it

with the fasteners shown.

Assemble the front and rear foot rail

(items 1 and 2) with the joiner plate

(item 12) with the fasteners shown.

10mm

4mm

2.4

2.5

FIT AND SECURE

2.2

2.4

2.1

3.2

3.3

4MM

3.1

Refer to RRSTUNI when assembling your Slimline II Tray.

Make sure that the wind diﬂector is

installed before you proceed to the next

step.

3.4

Centre the rack and fully tighten all the fasteners. Use M8 nut caps (Items 3) to ﬁnish off the nuts.

FATF006_REV_A00

Slide item 7 into the t-slots shown in

step 3.3. Loosely ﬁt the roof rack to the

foot rails by using items 6,7 and 8.

13mm

FATF006_REV_A00

COMPLETION

INSTALL OTHER VEHICLE AND RACK ACCESSORIES

Now's the time to visit your favorite Front Runner Dealer in person or online.

4.1

Congratulations. You did it. Take a step back and admire your work!

Table des matières

Autres manuels Front Runner Accessoires automobiles

Front Runner

Front Runner BRONCO TBRA040 Manuel utilisateur

Front Runner

Front Runner SSDS115 Manuel utilisateur

Front Runner

Front Runner MKIII Small Manuel utilisateur

Front Runner

Front Runner LALD006 Manuel utilisateur

Front Runner

Front Runner TBRA034 Manuel utilisateur

Front Runner

Front Runner FAJL004 Manuel utilisateur

Front Runner

Front Runner Drawer 6 Box Large MKII SSWO008 Manuel utilisateur

Front Runner

Front Runner TRCA008 Manuel utilisateur

Front Runner

Front Runner KSTF003T Manuel utilisateur

Front Runner

Front Runner FAJK003 Manuel utilisateur

Front Runner

Front Runner FSLI022 Manuel utilisateur

Front Runner

Front Runner LALD009 Manuel utilisateur

Front Runner

Front Runner FSLI021 Manuel utilisateur

Front Runner

Front Runner KRRK001T Mode d’emploi

Front Runner

Front Runner SSDS113 Manuel utilisateur

Front Runner

Front Runner SSDR003 Manuel utilisateur

Front Runner

Front Runner SLIMLINE II KRFE009T Manuel

Front Runner

Front Runner KRTT950T Manuel utilisateur

Front Runner

Front Runner Wolfpack Pro RRAC257 Manuel utilisateur

Front Runner

Front Runner TRCA010 Manuel utilisateur

Front Runner

Front Runner TRCA009 Manuel utilisateur

Front Runner

Front Runner SLIMLINE II TRAY Manuel utilisateur

Front Runner

Front Runner LADD007 Manuel utilisateur

Front Runner

Front Runner SSDS110 Manuel utilisateur

Manuels Accessoires automobiles populaires d'autres marques

James Baroud

James Baroud Odyssey Manuel utilisateur

Motorola

Motorola i50sx Manuel utilisateur

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manuel utilisateur

Feniex

Feniex T3 Manuel utilisateur

Renault

Renault 77 11 423 180 Manuel utilisateur

Kia

Kia E8300-4D000 Manuel utilisateur

Brink

Brink 756843 Manuel utilisateur

Whispbar

Whispbar K085W Manuel utilisateur

v.link

v.link CI-VL2-PC-HSD Manuel utilisateur

Viking

Viking Stack-Rack Guide de configuration rapide

Aries

Aries 203015 Manuel utilisateur

Choetech

Choetech AT0005 Manuel utilisateur

ZZ2

ZZ2 ZZAIR-PRO Manuel utilisateur

Holman

Holman 4A80L Manuel utilisateur

Thule

Thule 2075 Manuel utilisateur

Motorola

Motorola T325 Manuel utilisateur

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guide d'installation

DV8

DV8 FBJL-02 Manuel utilisateur