Eaton Powerware PowerPass 9125 Manuel utilisateur

Powerware 9125 Two-in-One

PowerPass Distribution Module

User’s Guide

For use with Powerware 9125 Two-in-One

5000/6000 VA UPS Models

All manuals and user guides at all-guides.com

all-guides.com

Class A EMC Statements

FCC Part 15

NOTE This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to

part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference

when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate

radio frequency energy and, if not installed and used in accordance with the instruction manual, may cause harmful

interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful

interference in which case the user will be required to correct the interference at his own expense.

ICES-003

This Class A Interference Causing Equipment meets all requirements of the Canadian Interference Causing

Equipment Regulations ICES-003.

Cet appareil numérique de la classe A respecte toutes les exigences du Reglement sur le matériel brouilleur du

Canada.

EN 50091-2

Some configurations are classified under EN 50091-2 as “Class-A UPS for Unrestricted Sales Distribution.” For

these configurations, the following applies:

WARNING This is a Class A-UPS Product. In a domestic environment, this product may cause radio interference, in

which case, the user may be required to take additional measures.

Powerware and PowerPass are registered trademarks of Eaton Electrical Inc.

Greenlee is a registered trademark of Greenlee Textron.

reproduced in any way without the express written approval of Eaton Corporation.

All manuals and user guides at all-guides.com

Requesting a Declaration of Conformity

Units that are labeled with a CE mark comply with the following harmonized standards and EU directives:

SHarmonized Standards: EN 50091-1-1 and EN 50091-2; IEC 60950 Third Edition

SEU Directives: 73/23/EEC, Council Directive on equipment designed for use within certain voltage limits

93/68/EEC, Amending Directive 73/23/EEC

89/336/EEC, Council Directive relating to electromagnetic compatibility

92/31/EEC, Amending Directive 89/336/EEC relating to EMC

The EC Declaration of Conformity is available upon request for products with a CE mark. For copies of the EC

Declaration of Conformity, contact:

Eaton Power Quality Oy

Koskelontie 13

FIN-02920 Espoo

Finland

Phone: +358-9-452 661

Fax: +358-9-452 665 68

All manuals and user guides at all-guides.com

Special Symbols

The following are examples of symbols used on the UPS or accessories to alert you to important

information:

RISK OF ELECTRIC SHOCK - Indicates that a risk of electric shock is present and the

associated warning should be observed.

CAUTION: REFER TO OPERATOR’S MANUAL - Refer to your operator’s manual for

additional information, such as important operating and maintenance

instructions.

This symbol indicates that you should not discard the UPS or the UPS batteries

in the trash. This product contains sealed, lead-acid batteries and must be

disposed of properly. For more information, contact your local recycling/reuse or

hazardous waste center.

This symbol indicates that you should not discard waste electrical or electronic

equipment (WEEE) in the trash. For proper disposal, contact your local

recycling/reuse or hazardous waste center.

All manuals and user guides at all-guides.com

EATON Powerware®9125 Two-in-One PDM (5000/6000 VA) User’s Guide S164201519 Rev E

www.powerware.com

Table of Contents

1 Introduction 1.........................................................

Safety Warnings 1......................................................................

2 Installation 13..........................................................

Inspecting the Equipment 13................................................................

UPS Setup 13..........................................................................

UPS Shutdown 14.....................................................................

Installing the UPS Internal Batteries 14.....................................................

Tower Setup 16......................................................................

EBM Installation 18......................................................................

Hardwired PDM Installation 19..............................................................

Remote Emergency Power-off Installation 26....................................................

Plug-Receptacle PDM Installation 28..........................................................

Plug-Receptacle PDM Rear Panels 32.........................................................

3 Configuration 35........................................................

4 Operation 37...........................................................

Using Maintenance Bypass 37..............................................................

5 Specifications 39.......................................................

6 PDM Schematics 41.....................................................

7 Service and Support 49..................................................

All manuals and user guides at all-guides.com

TABLE OF CONTENTS

EATON Powerware®9125 Two-in-One PDM (5000/6000 VA) User’s Guide S164201519 Rev E

www.powerware.com

All manuals and user guides at all-guides.com

all-guides.com

EATON Powerware®9125 Two-in-One PDM (5000/6000 VA) User’s Guide S164201519 Rev E

www.powerware.com

Chapter 1 Introduction

The PowerPass®Distribution Module (PDM) is designed to operate with

a 5000/6000 VA Powerware®9125 uninterruptible power system (UPS).

The PDM allows you to:

SReplace or upgrade the UPS without losing power to the protected

equipment (see “Using Maintenance Bypass” on page 37).

SProvide surge protection if the UPS is not present.

SProvide extra surge protection when the UPS is present.

Safety Warnings

IMPORTANT SAFETY INSTRUCTIONS

SAVE THESE INSTRUCTIONS

This manual contains important instructions that you should follow during installation and

maintenance of the UPS and PDM. Please read all instructions before operating the

equipment and save this manual for future reference.

DANGER

This UPS contains LETHAL VOLTAGES. All repairs and service should be performed by

AUTHORIZED SERVICE PERSONNEL ONLY. There are NO USER SERVICEABLE PARTS

inside the UPS.

CAUTION

STo reduce the risk of fire or electric shock, install this UPS in a temperature and humidity

controlled, indoor environment, free of conductive contaminants. Ambient temperature

must not exceed 40°C (104°F). Do not operate near water or excessive humidity

(95% maximum).

SFor PDM models with hardwired outputs, overcurrent protection for the output AC

circuit(s) is to be provided by others.

SFor PDM models with hardwired outputs, suitably rated disconnect switches for the

output AC circuit(s) are to be provided by others.

All manuals and user guides at all-guides.com

INTRODUCTION

EATON Powerware®9125 Two-in-One PDM (5000/6000 VA) User’s Guide S164201519 Rev E

www.powerware.com

Sikkerhedsanvisninger

VIGTIGE SIKKERHEDSANVISNINGER

GEM DISSE ANVISNINGER

Denne manual indeholder vigtige instruktioner, som skal følges under installation og

vedligeholdelse af UPS’en og PDU. Læs venligst alle instruktioner inden betjening af

udstyret og gem denne manual mhp. fremtidige opslag.

FARE

Denne UPS indeholder LIVSFARLIG HØJSPÆNDING. Alle reparationer og vedligeholdelse bør

kun udføres af en AUTORISERET SERVICETEKNIKER. Ingen af UPS’ens indvendige dele kan

repareres af brugeren.

ADVARSEL

SInstallér denne UPS i et temperatur- og fugtighedskontrolleret indendørsmiljø, frit for

ledende forureningsstoffer for at formindske risikoen for brand og elektrisk stød.

Rumtemperaturen må ikke overstige 40°C. UPS’en bør ikke betjenes nær vand eller høj

fugtighed (maksimalt 95%).

SFor PDM systemer med hårdledningsudgange, skal overstrømsbeskyttelse for

vekslestrømmens udgangskredsløb forsynes af andre.

SFor PDM systemer med hårdledningsudgange, skal egnede, nominelle afbryderkontakter

for vekslestrømmens udgangskredsløb forsynes af andre.

All manuals and user guides at all-guides.com

INTRODUCTION

EATON Powerware®9125 Two-in-One PDM (5000/6000 VA) User’s Guide S164201519 Rev E

www.powerware.com

Belangrijke Veiligheidsinstructies

BELANGRIJKE VEILIGHEIDSINSTRUCTIES

BEWAAR DEZE INSTRUCTIES

Deze handleiding bevat belangrijke instructies die u dient te volgen tijdens de installatie en

het onderhoud van de UPS en de PDU. Lees alle instructies voordat u de apparatuur in bedrijf

neemt en bewaar deze handleiding als naslagwerk.

GEVAAR

Deze UPS bevat LEVENSGEVAARLIJKE ELEKTRISCHE SPANNING. Alle reparaties en

onderhoud dienen UITSLUITEND DOOR ERKEND SERVICEPERSONEEL te worden uitgevoerd.

Er bevinden zich GEEN ONDERDELEN in de UPS die DOOR DE GEBRUIKER kunnen worden

GEREPAREERD.

OPGELET

STeneinde de kans op brand of elektrische schok te verminderen dient deze UPS in een

gebouw met temperatuur- en vochtigheidregeling te worden geïnstalleerd, waar geen

geleidende verontreinigingen aanwezig zijn. De omgevingstemperatuur mag 40°C niet

overschrijden. Niet gebruiken in de buurt van water of bij zeer hoge vochtigheid

(max. 95%).

SVoor PDM systemen met vast-bedrade uitgangen, moet de overstroombeveiliging voor

wisselstroom uitvoercircuit(s) door anderen worden geleverd.

SVoor PDM systemen met vast-bedrade uitgangen, moeten de juiste hoofdschakelaars

voor wisselstroom uitvoercircuit(s) door anderen worden geleverd.

All manuals and user guides at all-guides.com

INTRODUCTION

EATON Powerware®9125 Two-in-One PDM (5000/6000 VA) User’s Guide S164201519 Rev E

www.powerware.com

Tarkeita Turvaohjeita

TÄRKEITÄ TURVAOHJEITA - SUOMI

SÄILYTÄ NÄMÄ OHJEET

Tämä käyttöohje sisältää tärkeitä ohjeita, joita on noudatettava UPS-virtalähteen ja PDM

asennuksen ja huollon yhteydessä. Lue kaikki ohjeet ennen laitteiston käyttöä ja säilytä ohje

myöhempää tarvetta varten.

VAARA

Tämä UPS sisältää HENGENVAARALLISIA JÄNNITTEITÄ. Kaikki korjaukset ja huollot on

jätettävä VAIN VALTUUTETUN HUOLTOHENKILÖN TOIMEKSI. UPS ei sisällä MITÄÄN

KÄYTTÄJÄN HUOLLETTAVIA OSIA.

VARO

SVähentääksesi tulipalon ja sähköiskun vaaraa asenna tämä UPS sisätiloihin,

joissa lämpötila ja kosteus on säädettävissä ja joissa ei ole virtaa johtavia

epäpuhtauksia. Ympäristön lämpötila ei saa ylittää 40 °C. Älä käytä lähellä vettä ja vältä

kosteita tiloja (95 % maksimi).

SPDM-järjestelmissä kiintealla asennuksella: kuormana olevien laitteiden ylivirtasuojaus

ja erotuskytkimet tulee toteuttaa kuormapiireissa.

All manuals and user guides at all-guides.com

Table des matières

Autres manuels Eaton Unité de contrôle

Eaton

Eaton PKE-COM-RTU Manuel

Eaton

Eaton DXE-EXT-SET Manuel

Eaton

Eaton OPTC4 LonWorks Manuel utilisateur

Eaton

Eaton SL7-AP Series Manuel

Eaton

Eaton XTPAXENCS65B Manuel

Eaton

Eaton MSFI-125A Manuel

Eaton

Eaton Crouse-hinds series Manuel utilisateur

Eaton

Eaton Crouse-hinds series Manuel utilisateur

Eaton

Eaton NZM-XSWD-704 Manuel

Eaton

Eaton HMi VU Series Manuel

Eaton

Eaton MFD-TP12 Series Manuel

Eaton

Eaton Cutler-Hammer IQMSSPM Manuel utilisateur

Eaton

Eaton Powerware Series Manuel utilisateur

Eaton

Eaton Transformer 5000 Manuel utilisateur

Eaton

Eaton Char-Lynn Manuel utilisateur

Eaton

Eaton xComfort Room-Manager Manuel utilisateur

Eaton

Eaton PKE-SWD-CP Manuel

Eaton

Eaton Crouse-hinds series Guide de configuration

Eaton

Eaton Form 4D Recloser Control Manuel utilisateur

Eaton

Eaton COOPER POWER SERIES Manuel utilisateur

Eaton

Eaton CI/E-PKZ01-X Series Manuel

Eaton

Eaton SC200 Manuel utilisateur

Eaton

Eaton NRX Digitrip 1150 Manuel

Eaton

Eaton SL7 Series Manuel

Manuels Unité de contrôle populaires d'autres marques

Festo

Festo Compact Performance CP-FB6-E Manuel de la liste des pièces

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manuel utilisateur

JS Automation

JS Automation MPC3034A Manuel utilisateur

JAUDT

JAUDT SW GII 6406 Series Guide rapide

Spektrum

Spektrum Air Module System Manuel utilisateur

BOC Edwards

BOC Edwards Q Series Manuel utilisateur

KHADAS

KHADAS BT Magic Manuel utilisateur

Etherma

Etherma eNEXHO-IL Manuel utilisateur

PMFoundations

PMFoundations Attenuverter Manuel utilisateur

GEA

GEA VARIVENT Manuel utilisateur

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manuel utilisateur

Altronix

Altronix LINQ8PD Instructions de montage

WAGO

WAGO 750-407/040-000 Manuel utilisateur

Sony

Sony CCU-590 Manuel utilisateur

Graco

Graco 25D614 Manuel utilisateur

Task Force Tips

Task Force Tips YE-RF-900 Manuel de programmation

Shini

Shini SPV-U Series Manuel utilisateur

Flyron

Flyron FN-BC04 Manuel utilisateur