Cornelius Liquid Base Beverage Dispenser Manuel utilisateur

P/N 630460068

July 8, 1998

IMI Cornelius Inc; 1998

IMI CORNELIUS INC.

One Cornelius Place

Anoka, MN. 55303–6234

Telephone (612) 421–6120

Facsimile (612) 422–3232

INSTALLATION MANUAL

Liquid Base Beverage Dispenser

DRIP

TRAY

CUP

REST

FRONT

ACCESS PANEL

SUPPLY INLET

Design data

Width 10 3/4”

Height 21”

Depth 9 1/8”

Electrical Requirements:(if applicable)

15 Amp Circuit, 115v 60hz

.52 Amp Unit Current Draw

24v 60hz, Dispensing valves

Installation Check List :

Counter Top with access to route

concentrate supply lines.

15 Amp,115v60hz Outlet, Within 5’

(if applicable)

Cold Water Supply, With Shutoff

Overall Dimensions:

Weight: 12 lbs

24 VOLT

TRANSFORMER

(24 Volts) cord to

dispensing valves

RECEIVING

Each Unit is completely tested under operating conditions and thoroughly inspected before shipment. At time of

shipment, the carrier accepts the Unit and any claim for damage in transit must be made with the carrier. Upon

receiving Unit from the delivering carrier, carefully inspect the carton for visible indication of damage. Any dam-

age or irregularities should be noted at time of delivery (or not later than 15 days from date of delivery) and im-

mediately reported to the delivering carrier. Request a written inspection report from the Claims Inspector to

substantiate claim. File claim with the delivering carrier, not with IMI Cornelius Inc.

INSTALLATION

Place Unit in selected location to install unit.

Use mounting template (See page No. 3), to drill mounting holes for installing unit to counter top.

Liberally apply a sealant, such as Dow Corning RTV 731 or equivalent, to the unit flange bottom surface,per

(NSF) requirements, the unit must be sealed to the counter top.

Make connections as follows:

Plain Water Source Connections:

TO THE INSTALLER

It is the responsibility of the installer to ensure that the water supply to the dispensing equipment is

provided with protection against backflow by an air gap as defined in ANSI/ASME A112. 1.2-1979; or an

approved vacuum breaker or other such method as proved effective by test.

P/N 630460068

Water pipe connections and fixtures directly connected to a potable water supply shall be sized,

installed, and maintained according to Federal, State, and Local laws.

1. Flush plain water source thoroughly before connecting to Unit.

2. Connect plain water source to water inlet tube labeled ‘‘WATER’’.

Concentrate Line Connection:

1. Connect concentrate source lines to inlet lines from dispenser, labeled ‘‘1 or 2 etc’’. DO NOT CONNECT

SOURCE LINES TO CONCENTRATE AT THIS TIME.

Transformer Connections:(for electric valve units)

1. Connect Unit cord two-pin connector to the mating connector on the transformer output (24V) cord.

Steps of final installation:

1. Plug transformer into electrical outlet with proper electrical requirements.

2. Open shutoff valve in plain water source line.

3. Inspect connections for leaks.

4. Place a waste container under each nozzle and operate valve(s) to remove air from the plain water line.

5. Connect concentrate supply to concentrate system.

6. Open cylinder shutoff valve to apply the calculated pressure (approx. 40 PSI) to the concentrate system.

7. Operate each dispensing valve to remove air from the lines.

8. Check all lines for leaks.

9. Adjust Dispensing Valves for Water-To-Concentrate “Ratio”of dispensed drinks as instructed on ”BRIXING

VALVES”instructions.

NOTE: Concentrate system must be sanitized before Unit is put into operation. Refer to

Owner/Operator Manual for procedure.

10. Apply flavor decals to valve covers.

P/N 630460068

ONE SINGLE-FLAVOR

DISPENSING VALVE

ADJUSTABLE CONCENTRATE

FLOW REGULATOR

CONCENTRATE NO. ”2” IN

CONCENTRATE NO. ”1” IN

”WATER” IN

TWO SINGLE-FLAVOR

DISPENSING VALVES

”WATER” IN

CONCENTRATE NO. ”1” IN

CONCENTRATE NO. ”3” IN

CONCENTRATE NO. ”4” IN

TWO TWO-FLAVOR

DISPENSING VALVES

ADJUSTABLE WATER

FLOW REGULATOR

CONCENTRATE NO. ”2” IN

FLOW DIAGRAMS

”WATER” IN

CONCENTRATE NO. ”1” IN ”WATER” IN

”WATER” IN

Autres manuels pour Liquid Base Beverage Dispenser

Table des matières

Autres manuels Cornelius Distributeur de boissons

Cornelius

Cornelius 2232MS Manuel

Cornelius

Cornelius TRIAD-150 Manuel utilisateur

Cornelius

Cornelius R-404A REFRIGERANT Manuel utilisateur

Cornelius

Cornelius VIPER (E) 2 FLAVOR Manuel utilisateur

Cornelius

Cornelius IDC PRO 255 Manuel utilisateur

Cornelius

Cornelius Profile 150 Manuel utilisateur

Cornelius

Cornelius Remcor TJ45-A Manuel utilisateur

Cornelius

Cornelius ED 300 BC Manuel utilisateur

Cornelius

Cornelius DF/ED250PRO Manuel utilisateur

Cornelius

Cornelius Enduro 200 Manuel utilisateur

Cornelius

Cornelius MillenniumII 4000 Manuel utilisateur

Cornelius

Cornelius A.B.S. Unit Manuel utilisateur

Cornelius

Cornelius VIPER 4 FLAVOR Manuel utilisateur

Cornelius

Cornelius Remcor TJ200 Manuel utilisateur

Cornelius

Cornelius CTP-20 Guide de configuration

Cornelius

Cornelius ENDURO 250 Manuel utilisateur

Cornelius

Cornelius Agitator Gear Motor Capacitor ED/DF Manuel utilisateur

Cornelius

Cornelius JETSPRAY LT1 Manuel utilisateur

Cornelius

Cornelius Ice Cooled Dispensers Manuel utilisateur

Cornelius

Cornelius JETSPRAY Guide de configuration

Cornelius

Cornelius 6 Flavor Mode d’emploi

Cornelius

Cornelius Quantum 45200001 Guide de configuration

Cornelius

Cornelius VANGUARD 245 Manuel utilisateur

Cornelius

Cornelius SPIRIT 414384-XXX Guide de configuration

Manuels Distributeur de boissons populaires d'autres marques

PEGAS

PEGAS Evolution Manuel utilisateur

Ugolini

Ugolini MT micro Manuel utilisateur

Bunn

Bunn SLCA-7 Instructions d'installation

Gekkeikan

Gekkeikan Sake Machine Manuel utilisateur

Olympia

Olympia DH709 Manuel utilisateur

Marco

Marco ECOSMART PB10 Manuel utilisateur

Marvel

Marvel ML24BN Series Manuel

Cecilware

Cecilware 2K-GB-LD Manuel

Sure Vend

Sure Vend 673 Manuel utilisateur

Nostalgia Electrics

Nostalgia Electrics KEG7000SS Manuel utilisateur

Bunn

Bunn LCR-3 HV Guide de dépannage

Servend

Servend SV-200 Manuel utilisateur

EdgeStar

EdgeStar VBR440 Manuel utilisateur

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C Manuel utilisateur

Siemens

Siemens GA 3000 Manuel d'instructions et de sécurité

Selbach

Selbach Fruit Juice dispenser Manuel utilisateur

Taylor

Taylor C302NP Manuel utilisateur

Vinotemp

Vinotemp VT-WINEDISP2 Manuel utilisateur