Audi R8 Spyder Manuel de référence

Technical Service Bulletin

Page 1 of 6

rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,

stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to

other sites, without the prior expressed written permission of the publisher.

72 Seat fore-and-after adjustment incorrect

72 22 45 2058268/2 July 12, 2022. Supersedes Technical Service Bulletin Group 72 number 20-22 dated January 17,

2020, for reasons listed below.

Model(s)

Year

VIN Range

Vehicle-Specific Equipment

R8 Spyder

2017 901529 – 905737

Not Applicable

2018 900030 – 900262

Condition

REVISION HISTORY

Revision

Date

Purpose

2 - Revised title

Revised

Condition

and

Technical Background

(Add customer complaint)

1 01/17/2020 Initial publication

Customer states:

•The seat backrest panels are damaging the rear panel trim panel and/or windscreen.

•The seat cannot be moved backward far enough.

Workshop findings:

•One or both sides seat backrest panels chafe on the rear panel trim panel and/or windscreen resulting in

damaged trim panels and/or windscreen.

Technical Service Bulletin

Page 2 of 6

rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,

stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to

other sites, without the prior expressed written permission of the publisher.

•The seat cannot be adjusted backward far enough.

Technical Background

On R8 Spyders with sport seats and fully

electric seats, the seats can be adjusted

to positions that allow for mechanical

interference between the seat backrest

panels and the rear panel trim panel

and/or windscreen during normal

operation. This interference can result in

damaged trim panels and/or windscreen

(Figure 1).

Figure 1.

Damaged rear panel trim panel.

Technical Service Bulletin

Page 3 of 6

rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,

stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to

other sites, without the prior expressed written permission of the publisher.

In some cases, the seats cannot be

adjusted backward far enough (Figure 2).

Figure 2.

Seat not moving backward far enough.

Production Solution

Improved software in the seat control modules J136, (address word 0036) and J521, (address word 0006).

Service

SVM Update Instructions

1. Follow all instructions in TSB 2011732:

00 Software Version Management (SVM), operating instructions.

Technical Service Bulletin

Page 4 of 6

rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,

stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to

other sites, without the prior expressed written permission of the publisher.

2. Update the seat control modules J136, (address word 0036) and J521, (address word 0006) using the SVM action

code as listed in the table below, if necessary:

Model

Old Target Data

Container Number

Old Target Data

Container Version

New Target Data

Container Number

New Target Data

Container Version

(or higher)

SVM Code

Input

Spyder 4S0909856B * 4S0909856C * 36A004

Spyder 4S0909866B * 4S0909866C * 36A004

3. Perform basic settings of the seats via Guided Functions in ODIS Service.

4. Replace any damaged seat backrest panels, rear panel trim panels, and/or the windscreen according to the

repair manuals in Elsa.

Warranty

Claim Type:

•110 up to 48 Months/50,000 Miles.

•G10 for CPO Covered Vehicles – Verify Owner.

•If the vehicle is outside any warranty, this Technical Service Bulletin is informational only.

Service Number:

7293

Damage Code:

0039

Technical Service Bulletin

Page 5 of 6

rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,

stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to

other sites, without the prior expressed written permission of the publisher.

Labor Operations:

Software Update 0151 0000 Time stated on the

diagnostic protocol

(Max 50 TU)

Front seat backrest cover replace 7423 1950 See SRT

Rollover bar trim replace 7081 1905 See SRT

Diagnostic Time:

GFF No allowance 0 TU

Road test prior to the service procedure No allowance 0 TU

Road test after the service procedure No allowance 0 TU

Claim Comment:

As per TSB 2058268/2

All warranty claims submitted for payment must be in accordance with the

Audi Warranty Policies and Procedures

Manual

. Claims are subject to review or audit by Audi Warranty.

Required Parts and Tools

Always check with your Parts Department and/or ETKA for the latest information and parts bulletins.

Part Number

Part Description

Quantity

See ETKA Fasteners, Bolts, Nuts, and Screws as needed per the

Repair Manual

See ETKA/ELSA

4S0881969* Backrest panel (left) 01 (If damaged)

4S0881970* Backrest panel (right) 01 (If damaged)

4S7867477* Rear panel trim 01 (If damaged)

Technical Service Bulletin

Page 6 of 6

rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced,

stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to