Volkswagen golf 5 Manuel utilisateur
3
General
Lifting the vehicle using vehicle hoist and workshop
trolle
y
j
ack
Safety precautions
Warning!
Before driving on to a hoist ensure there is
sufficient clearance between low lying vehicle
components and hoist.
Before driving a vehicle onto a lifting platform it
must be ensured that the vehicle weight does
not exceed the permissible lifting capacity of the
platform.
Vehicle may only be lifted at points indicated in
illustration in order to avoid damaging vehicle
floor pan and to prevent vehicle from tipping.
Never start engine and engage a gear with
vehicle lifted so long as even one wheel has
contact with the floor. There is a risk of an
accident if this is not observed!
If work is to be performed under vehicle it must
be supported by suitable stands.
Lifting points for lifting platform and trolley jack:
Front:
Page 1 / 10Volkswagen Golf 5 - Description of work
- Place support plate, in area of side member marking -
arrow A - , on vertical stiffener of floor plate -arrowB-.
Warning!
Make sure that side member stiffener contacts support
p
late of liftin
g
p
latform at center.
Rear:
- Place support plate, in area of side member marking -
arrow A - , on vertical stiffener of floor plate -arrowB-.
Warning!
Make sure that side member stiffener contacts support
p
late of liftin
g
p
latform at center.
Data stickers
Appl
y
sticker "First service"
(
at the deliver
y
inspection
)
Pa
g
e 2 / 10General
Appy sticker "Your next service events" 01-3, Data
stickers
"First service" sticker
- Apply sticker on drivers side door jamb (B-pillar); the
sticker is located on an instruction which is attached at
front in the vehicle wallet. Destroy the instruction after
attaching the sticker!
Appl
y
sticker "Next service"
- Service sticker "Next service" : Enter a cross at the
position for oil change service or inspection service (next
service due) and enter date / odometer reading
- Apply sticker on drivers side door beam (B-pillar).
A
pp
l
y
in
g
"Data sticker" in service schedule
- Apply the upper of the two data stickers -arrow-.
1 - Planning week
Pa
g
e 3 / 10General
2 - PR Number
Dia
g
nostic unit, connectin
g
S
p
ecial tools, testers and auxiliar
y
items re
q
uired
Vehicle Diagnosis, Testing and Information System
VAS 5051 A
Vehicle Diagnosis, Testing and Information System
VAS 5051B
Vehicle diagnosis service syst. VAS 5052 or later
testers
Pa
g
e 4 / 10General
Diagnostic system VAS 5053
Diagnostic cable VAS 5051/6A
Warning!
During a test drive you must always secure
testing and measuring equipment on the back
seat.
Drivers must NEVER operate these tools while
driving.
Pa
g
e 5 / 10General
- Perform the following work procedure:
- Connect diagnosis cable connector to data link
connector.
- Turn on the tester.
- Switch ignition on.
Now follow information given on screen to start the desired
functions.
V
ehicle Identification Number
(
VIN
)
Com
p
onent location en
g
ine com
p
artment
Vehicle Identification Number (VIN) is located on extension
of longitudinal member -arrow-.
Meaning of Vehicle Identification Number (VIN):
000 234
Pa
g
e 6 / 10General
WVW ZZZ 1K1
1) Z4 8
Manufacturer
code Filler
characters Model Filler
characters Model
year 2004 Production
location Serial
number
1) Rabbit/GTI 2006
V
ehicle data sticke
r
The vehicle data sticker - arrow - is located in rear of
vehicle on the left in the spare wheel well under foam
storage tray. The vehicle data sticker can also be found in
the service schedule for the customer.
Sticker contains the following vehicle data:
1 - Production control number
2 - Vehicle Identification Number (VIN)
3 - Model identification number
4 - Model explanation/engine output
5 - Engine and transmission code letters
6 - Paint number/interior equipment identification number
7 - Optional extras identification numbers
Pa
g
e 7 / 10General
Information on time or distance dependent service
Service Identification
- Check via the vehicle data plate in luggage compartment,
whether the vehicle is equipped with PR number "QG0" or
with PR Number "QG2" . The PR number determines the
service intervals 01-3, Service intervals .
Vehicle data plate is applied at left next to spare wheel
well, component location, see 01-3, Vehicle data
sticker .
Vehicles marked with the following PR-number:
"QG2" indicates time or distance de
p
endent service.
"QG0" means time or distance de
p
endent service.
En
g
ine oils
Approved engine oil norms for vehicles
For information regarding approved oil types please
refer to: Additional Information, Fluid Capacity
Charts for a
pp
ro
p
riate model and
y
ear
En
g
ine code and en
g
ine numbe
r
Engine code and engine identification are found in:
Gasoline engines:
Repair Manual, 2.0 Liter 4-Cyl. 4V Turbo Engine
Mechanical, Fuel Injection Ignition, Engine Code(s): BPY,
Repair Group 00, Technical data, engine number
Pa
g
e 8 / 10General
On vehicle data sticker 01-3, Vehicle data
sticker .
Service intervals
Service intervals
So that each service is performed at the correct point in
time and is not forgotten, a sticker on the door beam or
service reminder indicator in the instrument cluster display
serves to remind customer of the service event.
Information about the sticker can be obtained 01-3, Data
stickers .
V
ehicles with PR-number QG0, QG2
Oil change service Page
- Oil change service at 5,000 miles (8,000 km)
(whichever occurs first)
(according to service interval display)
01-2, Oil change service
Inspection service (oil change service inspection service) every 10,000
miles (15,000 km) or after 1 year Page
- Oil change service every 10,000 miles (15,000 km) or after 1
year
(whichever occurs first)
(according to service interval display)
01-2, Oil change
service
T
y
pe plate
Note:
Vehicles for certain countries have no type plate.
Pa
g
e 9 / 10General
4-door vehicles
Type plate - arrow 1 - can be seen after opening left front
door, in lower area of B-pillar.
Sticker contains the following vehicle data:
A - Vehicle Identification Number (VIN)
B - Axle loads
C - Model identification number
2-door vehicles
Type plate is visible after opening right door on door beam
at bottom.
Pa
g
e 10 / 10General
Ce manuel convient aux modèles suivants
1
Table des matières
Autres manuels Volkswagen Automobile
Volkswagen
Volkswagen TYPE 1 1973 SEDAN 111 Manuel utilisateur
Volkswagen
Volkswagen 2013 Beetle Manuel utilisateur
Volkswagen
Volkswagen FOX 2004 Manuel utilisateur
Volkswagen
Volkswagen 2014 Beetle Convertible Manuel utilisateur
Volkswagen
Volkswagen PASSAT ESTATE Manuel utilisateur
Volkswagen
Volkswagen TOUAREG - Manuel utilisateur
Volkswagen
Volkswagen 1960 1200 Manuel utilisateur
Volkswagen
Volkswagen Jetta 2000 Manuel utilisateur
Volkswagen
Volkswagen Beetle 1977 Manuel utilisateur
Volkswagen
Volkswagen Bug 1967 Instructions d'utilisation
Volkswagen
Volkswagen Golf TSI 2021 Manuel utilisateur
Volkswagen
Volkswagen PASSAT - YEAR 2001 Manuel utilisateur
Volkswagen
Volkswagen Transporter 1972 Manuel utilisateur
Volkswagen
Volkswagen 1958 Beetle Manuel utilisateur
Volkswagen
Volkswagen SCIROCCO - Manuel utilisateur
Volkswagen
Volkswagen Type II Transporter 1200 Series Guide d'installation
Volkswagen
Volkswagen Beetle Manuel utilisateur
Volkswagen
Volkswagen 2015 Golf GTI Manuel utilisateur
Volkswagen
Volkswagen Eurovan Camper Manuel utilisateur
Volkswagen
Volkswagen Beetle 1998-2010 Manuel utilisateur
