UTICA BOILERS TriFire Manuel utilisateur

Remove all components from crate. It may be to the1.

installer’s advantage to place the cast iron boiler block

close to where the nal installation location will be.

Boiler may be piped and pressurized before

installing jackets & components.

NOTICE

Attach top and bottom rear intermediate panels with2.

5/16”x1/2” bolts & washers. Be sure top anges point

toward the front of the boiler. Bottom panel anges

will point rearward. Hold bottom ange to top of holes

while tightening bolts. See Figure 1.

Figure 1

Bottom Intermediate

Top Intermediate

Rear of Boiler

P/N 240007211, Rev. B [06/08]

KNOCKDOWN ASSEMBLY

Instructions for

TriFire Oil Fired Boiler

SUPPLEMENTAL INSTRUCTIONS

This assembly must be completed by a qualied installer or service agency, in accordance with the

manufacturer’s instructions, and in accordance with all codes and requirements of the authority having

jurisdiction. Failure to follow these instructions could result in re or explosion resulting in property dam-

age, personal injury, or loss of life.

WARNING

Wrap insulation around boiler with the smooth side out.3.

Be sure to overlap underneath boiler. Wrap 2 banding

strips around insulation and tie as shown in Figure 2,

Cut off excess banding material. The rear insulation is

not installed until step 11.

Figure 2

Attach pipe nipples to supply and return outlets. Be4.

sure to use pipe dope before screwing into boiler. See

Figure 3.

Figure 3

Insert (4) 5/16” x 1/2” bolts into threaded holes on front5.

of boiler as shown in Figure 4. Do not tighten down.

These bolts will hold the side Jacket panels on the

boiler.

Figure 4

Place the left side jacket panel on the 5/16”x1/2” bolts6.

from step 6. Place the control panel on the top of the

boiler with the burner wire harness on the right. See

Figure 5.

Figure 5

Attach the control panel to the left side jacket. The7.

slot on the front of the control panel will slide over the

screw in the side jacket panel. See Figure 5A.

Figure 5A

Attach the right side jacket panel to the boiler and8.

control panel like the left side. At the rear of the boiler,

be sure the panel ts over the top and bottom interme-

diate anges from step 2. Be sure to route the burner

wire harness as shown in Figure 6. Do not tighten all

the hardware yet.

KNOCKDOWN BOILER ASSEMBLY

Figure 6

11”

Attach the burner harness zip tie to right side jacket9.

with the screw provided. See Figure 6.

Attach the side jackets to the lower intermediate10.

bracket at rear of boiler. See Figure 7.

Figure 7

Place the rear insulation on the rear of the boiler.11.

Attach the lower rear. Insert the tabs into the slots12.

provided. Do not attach the upper rear panel yet. (Pipe

nipples removed for clarity)

Figure 8

You may now tighten down the control panel and side13.

panel hardware. You may have to pull the front switch

out in order to completely fasten the screws. (See

Figure 9.

Figure 9

Slot & Screw

Attach the top panel to the side panels.14.

KNOCKDOWN BOILER ASSEMBLY

Attach the upper rear panel by sliding the tabs into15.

the slots in the side panels and lower rear panel. Use

the screws provided to attach the upper rear panel to

the top panel. See Figure 9.

Figure 9

Attach the front panel by setting onto the rivets in the16.

side jackets. See Figure 10.

Figure 10

Proceed to the section “Packaged Boiler Assembly” in17.

the Installation, Operation and Maintenance manual.

KNOCKDOWN BOILER ASSEMBLY

For technical assistance with this product call toll free 1-800-325-5479

ECR International

PO Box 4729

Utica, NY 13504-4729

www.ecrinternational.com

Table des matières

Autres manuels UTICA BOILERS Chaudière

UTICA BOILERS

UTICA BOILERS MGB 50 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS UB90125 Instructions générales

UTICA BOILERS

UTICA BOILERS OLSSV-050 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS MAHF-75 Manuel utilisateur

UTICA BOILERS

UTICA BOILERS SW3 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS UCS-240 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS SFM CONSTELLATION Series Manuel d'instructions

UTICA BOILERS

UTICA BOILERS SFE0365 Manuel utilisateur

UTICA BOILERS

UTICA BOILERS MAH-125 Manuel utilisateur

UTICA BOILERS

UTICA BOILERS TriFire Guide d'installation

UTICA BOILERS

UTICA BOILERS DVB-50 Manuel du propriétaire

UTICA BOILERS

UTICA BOILERS PEG075EID Manuel d'instructions

UTICA BOILERS

UTICA BOILERS UBSSC-299 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS UB95M-200 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS UBSSC-075 Manuel du propriétaire

UTICA BOILERS

UTICA BOILERS MGC-8D Manuel d'instructions

UTICA BOILERS

UTICA BOILERS MAHF-125 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS USC SERIES Manuel d'instructions

UTICA BOILERS

UTICA BOILERS USC SERIES Mode d’emploi

UTICA BOILERS

UTICA BOILERS MGB 50 Manuel du propriétaire

UTICA BOILERS

UTICA BOILERS DV Mode d’emploi

UTICA BOILERS

UTICA BOILERS SSV-150 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS MACF-150 Mode d’emploi

UTICA BOILERS

UTICA BOILERS MAC-150 Manuel d'instructions

Manuels Chaudière populaires d'autres marques

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manuel utilisateur

Radijator

Radijator BIO max 23.1 Manuel utilisateur

Brunner

Brunner BSV 20 Manuel utilisateur

Buderus

Buderus Logamax GB062-24 KDE H V2 Manuel utilisateur

Potterton

Potterton 50e Fiche technique

Joannes

Joannes LADY Series Manuel

ECR International

ECR International UB90-125 Manuel d'instructions

Froling

Froling FHG Turbo 3000 Manuel utilisateur

Froling

Froling P4 Pellet 8 - 105 Manuel utilisateur

U.S. Boiler Company

U.S. Boiler Company K2 Manuel utilisateur

Henrad

Henrad C95 FF Manuel utilisateur

NeOvo

NeOvo EcoNox EF 36 Manuel utilisateur

Potterton

Potterton PROMAX SL 12 Manuel utilisateur

Eco Hometec

Eco Hometec EC 25 COMPACT Manuel utilisateur

Viessmann

Viessmann VITODENS 200 Mode d’emploi

Baxi

Baxi Prime 1.24 Manuel utilisateur

REXNOVA

REXNOVA ISA 20 BITHERMAL Manuel utilisateur

Radiant

Radiant R2K 55 Manuel