UTICA BOILERS TriFire Guide d'installation

Knockdown Boiler Assembly Instructions -

TriFire Model

Remove all components from crate. It may be to the1. installer’s advantage to place the cast iron boiler block

close to where the nal installation location will be.

Install rubber grommets in rear top plate. Attach with

2. brass bolts and washers. See Figure 1.

Figure 1

Rear of boiler

P/N 240007211, Rev. A [04/08]

KNOCKDOWN ASSEMBLY

Instructions for

TriFire Oil Fired Boiler

SUPPLEMENTAL INSTRUCTIONS

This assembly must be completed by a qualied installer or service agency, in accordance with the

manufacturer’s instructions, and in accordance with all codes and requirements of the authority having

jurisdiction. Failure to follow these instructions could result in re or explosion resulting in property dam-

age, personal injury, or loss of life.

WARNING

Wrap insulation around boiler with the smooth side out.3.

If necessary, overlap underneath boiler. Wrap 2 band-

ing strips around insulation. As shown in Figure 2,

Cinch banding together with plastic buckles provided.

Cut off excess banding material.

Figure 2

Insulation straps with buckles

Attach pipe nipples to supply and return outlets. Be4. sure to use pipe dope before screwing into boiler. See

Figure 3.

Figure 3

Attach insulation to rear of boiler. Attach insulation5. straps with plastic buckles as shown in Figure 4. Cut

off excess strap material as shown.

Figure 4

Place the control panel on the top of the boiler with the6. burner wire harness on the right. See Figure 4A.

Figure 4A

Insert brass bolts into threaded holes on front of boiler7. as shown in Figure 5. Do not tighten down. These

bolts will hold the side Jacket panels on the boiler.

Figure 5

KNOCKDOWN BOILER ASSEMBLY

Place the side jackets on the bolts from the previ-8. ous step. Be sure to route the burner wire harness as

shown in Figure 6.

Figure 6

11”

Attach the burner harness zip tie to right side jacket. If9.

no hole is present, drill 1/8” dia. See Figure 6.

Attach the lower rear panel, then attach the upper

10.

rear panel with the screws provided. See Figure 7

(Nipples removed for clarity.)

Figure 7

Rear of boiler

Attach the front control panel with the screws provided.11.

Check the clearance between the two side panels and en-

sure there is the same clearance top and bottom. Tighten

down the bolts mentioned in step 6. See Figure 8.

Figure 8

Attach the front panel by setting onto the rivets in the12.

side jackets. See gure 9.

Figure 9

KNOCKDOWN BOILER ASSEMBLY

Attach the top panel with the screws provided.13.

Proceed to the section “Packaged Boiler Assembly” in14.

the Installation, Operation and Maintenance manual.

KNOCKDOWN BOILER ASSEMBLY

For technical assistance with this product call toll free 1-800-325-5479

ECR International

PO Box 4729

Utica, NY 13504-4729

www.ecrinternational.com

Table des matières

Autres manuels UTICA BOILERS Chaudière

UTICA BOILERS

UTICA BOILERS STARFIRE 3 STEAM Document technique

UTICA BOILERS

UTICA BOILERS USC SERIES Document technique

UTICA BOILERS

UTICA BOILERS PEG112C Manuel utilisateur

UTICA BOILERS

UTICA BOILERS MGB 50 Manuel du propriétaire

UTICA BOILERS

UTICA BOILERS UH15B-K Manuel d'instructions

UTICA BOILERS

UTICA BOILERS MAHF-125 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS SFH-3085 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS MAGB Document technique

UTICA BOILERS

UTICA BOILERS MGC-8D Manuel d'instructions

UTICA BOILERS

UTICA BOILERS SFM6225W Manuel utilisateur

UTICA BOILERS

UTICA BOILERS MAC-150 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS UB90-50 Manuel utilisateur

UTICA BOILERS

UTICA BOILERS STARFIRE 3 STEAM Document technique

UTICA BOILERS

UTICA BOILERS USC SERIES Manuel d'instructions

UTICA BOILERS

UTICA BOILERS OLSSV-050 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS UH16 Series Manuel d'instructions

UTICA BOILERS

UTICA BOILERS MGB 50 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS MGB Series Mode d’emploi

UTICA BOILERS

UTICA BOILERS UCS-240 Manuel d'instructions

UTICA BOILERS

UTICA BOILERS 95M-200 Manuel utilisateur

UTICA BOILERS

UTICA BOILERS UB90 125 Document technique

UTICA BOILERS

UTICA BOILERS MAHF-165 Manuel utilisateur

UTICA BOILERS

UTICA BOILERS MGB Series Manuel d'instructions

UTICA BOILERS

UTICA BOILERS SFH 5 Series Manuel d'instructions

Manuels Chaudière populaires d'autres marques

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manuel utilisateur

Radijator

Radijator BIO max 23.1 Manuel utilisateur

Brunner

Brunner BSV 20 Manuel utilisateur

Buderus

Buderus Logamax GB062-24 KDE H V2 Manuel utilisateur

Potterton

Potterton 50e Fiche technique

Joannes

Joannes LADY Series Manuel

ECR International

ECR International UB90-125 Manuel d'instructions

Froling

Froling FHG Turbo 3000 Manuel utilisateur

Froling

Froling P4 Pellet 8 - 105 Manuel utilisateur

U.S. Boiler Company

U.S. Boiler Company K2 Manuel utilisateur

Henrad

Henrad C95 FF Manuel utilisateur

NeOvo

NeOvo EcoNox EF 36 Manuel utilisateur

Potterton

Potterton PROMAX SL 12 Manuel utilisateur

Eco Hometec

Eco Hometec EC 25 COMPACT Manuel utilisateur

Viessmann

Viessmann VITODENS 200 Mode d’emploi

Baxi

Baxi Prime 1.24 Manuel utilisateur

REXNOVA

REXNOVA ISA 20 BITHERMAL Manuel utilisateur

Radiant

Radiant R2K 55 Manuel