Toyota Prius 2010 Mode d'emploi

ILLUSTRATION

ON-VEHICLE INSPECTION

1. INSPECT THROTTLE BODY ASSEMBLY

(a) Check for throttle control motor operating sound.

(1) Turn the power switch on (IG).

(2) When depressing the accelerator pedal, check the operating sound of the motor. Make sure that no friction

noises are emitted from the motor. If any friction noise exists, replace the throttle body assembly.

(b) Set the vehicle to the inspection mode .

speed is within the specified range when the A/C is switched off.

Standard:

Condition

Engine Idle Speed

A/C switched off

950 to 1050 rpm

NOTICE:

x Be sure to perform this step with all accessories off.

x Make sure that park (P) is selected.

REMOVAL

1. REMOVE NO. 1 ENGINE UNDER COVER

2. DRAIN ENGINE COOLANT (for Engine)

3. REMOVE NO. 2 CYLINDER HEAD COVER

4. REMOVE AIR CLEANER CAP SUB-ASSEMBLY

(a) Disconnect the mass air flow meter connector.

(b) Release the 2 clamps.

5. REMOVE INLET AIR CLEANER ASSEMBLY

(a) Separate the hose from the hose clamp.

(b) Separate the wire harness clamp from the inlet air cleaner assembly.

6. REMOVE AIR CLEANER CASE

(a) Remove the air cleaner filter element.

(b) Separate the hose from the 3 hose clamps.

7. REMOVE AIR CLEANER HOSE ASSEMBLY

(a) Loosen the hose clamp and separate the ventilation hose.

(b) Unlock the hose clamp and remove the air cleaner hose assembly.

8. REMOVE THROTTLE BODY ASSEMBLY

(a) Disconnect the throttle body connector and the 2 water by

pass hoses.

(b) Remove the 2 bolts, 2 nuts and throttle body assembly.

INSPECTION

1. INSPECT THROTTLE BODY ASSEMBLY

(a) Measure the resistance according to the value(s) in the table below.

Text in Illustration

Component without harness connected

(Throttle Body)

Standard Resistance:

Tester Connection

Condition

Specified Condition

1 (M-) - 2 (M+)

20°C (68°F)

0.3 to 100 Ω

If the result is not as specified, replace the throttle body assembly.

INSTALLATION

1. INSTALL THROTTLE BODY ASSEMBLY

(a) Install a new gasket onto the intake manifold.

(b) Install the throttle body assembly with the 2 bolts and 2 nuts.

Torque:

10 N·m (102 kgf·cm, 7ft·lbf)

2. INSTALL AIR CLEANER HOSE ASSEMBLY

(a) Install the air cleaner hose assembly and lock the hose clamp.

(b) Connect the ventilation hose.

3. INSTALL AIR CLEANER CASE

(a) Install the air cleaner case with the 3 bolts.

Torque: 7.0 N·m (71 kgf·cm, 62in·lbf)

(b) Install the hose to the 3 hose clamps.

4. INSTALL INLET AIR CLEANER ASSEMBLY

(a) Install the inlet air cleaner assembly with the 3 bolts.

Torque:

7.0 N·m (71 kgf·cm, 62in·lbf)

(b) Connect the wire harness clamp to the inlet air cleaner assembly.

5. INSTALL AIR CLEANER CAP SUB-ASSEMBLY

(a) Install the air cleaner cap sub

assembly with the 2 clamps.

(b) Tighten the hose clamp.

6. ADD ENGINE COOLANT (for Engine)

7. INSPECT FOR COOLANT LEAK (for Engine)

8. INSTALL NO. 2 CYLINDER HEAD COVER

9. INSTALL NO. 1 ENGINE UNDER COVER

10. PERFORM INITIALIZATION

NOTICE:

Be sure to perform this procedure after reassembling the throttle body assembly, removing and reinstalling any

throttle body component or replacing the ECM.

(a) Disconnect the cable from the negative (-) battery terminal. Wait at least 60 seconds and reconnect the cable.

(b) Connect the Techstream to the DLC3 and clear the DTCs .

(d) Start the engine without operating the accelerator pedal and check that the MIL is not illuminated and that

the idle speed is within the specified range when the air conditioning is switched off after the engine is warmed

up.

Standard:

Condition

Engine Idle Speed

A/C switched off

950 to 1050 rpm

NOTICE:

x If the accelerator pedal is operated, perform the above steps again.

x Be sure to perform this step with all accessories off.

x Make sure that park (P) is selected.

(e) Perform a road test and confirm that there are no abnormalities.

Autres manuels pour Prius 2010

Table des matières

Autres manuels Toyota Automobile

Toyota

Toyota Hiace Manuel utilisateur

Toyota

Toyota 4Runner 2003 Guide de démarrage rapide

Toyota

Toyota Prius 2011 Manuel utilisateur

Toyota

Toyota RAV4 EV 2013 Manuel utilisateur

Toyota

Toyota AVALON HYBRID 2017 Manuel utilisateur

Toyota

Toyota 2003 MR2 Spyder Manuel utilisateur

Toyota

Toyota 2009 Land Cruiser Manuel utilisateur

Toyota

Toyota Corolla 2004 Manuel utilisateur

Toyota

Toyota AVALON 2005 Manuel utilisateur

Toyota

Toyota Prius 2007 Manuel utilisateur

Toyota

Toyota Tundra 2014 Manuel utilisateur

Toyota

Toyota 2012 CAMRY LE Manuel utilisateur

Toyota

Toyota CAMRY SOLARA 00452-PRG07-SOL Manuel utilisateur

Toyota

Toyota PriusV Guide de configuration

Toyota

Toyota 2007 Highlander Manuel utilisateur

Toyota

Toyota 4Runner 2004 Manuel utilisateur

Toyota

Toyota PRIUS 2008 Manuel utilisateur

Toyota

Toyota 2005 Camry Solara Convertible Manuel utilisateur

Toyota

Toyota Prius 2018 Manuel utilisateur

Toyota

Toyota Corolla guide Manuel utilisateur

Toyota

Toyota Prius HSD 2004 Manuel utilisateur

Toyota

Toyota YARIS 2020 Manuel utilisateur

Toyota

Toyota Auris HB 2018 Manuel utilisateur

Toyota

Toyota HILUX Guide de l'utilisateur

Manuels Automobile populaires d'autres marques

CITROËN

CITROËN DS4 DSign Manuel utilisateur

Lexus

Lexus 2015 CT 200h Manuel utilisateur

Cadillac

Cadillac CTS 2008 Manuel utilisateur

Mercedes-Benz

Mercedes-Benz M-class ML 55 AMG Manuel utilisateur

Porsche

Porsche Boxster S Manuel utilisateur

GMC

GMC 2010 Savana 1500 Cargo Manuel utilisateur

KIAM

KIAM SPORTAGE 2014 Manuel de la liste des pièces

GMC

GMC 2013 Terrain Instructions de montage

GMC

GMC T-Series 1999 Manuel utilisateur

Mercury

Mercury 1998 Mystique Manuel utilisateur

Mercury

Mercury 2007 Mariner Manuel utilisateur

Mazda

Mazda 2007 Mazdaspeed 3 Mode d’emploi

Mazda

Mazda 2014 CX-5 Manuel utilisateur

GMC

GMC Chevrolet Express 2022 Manuel utilisateur

GMC

GMC 1997 Jimmy Manuel utilisateur

Chevrolet

Chevrolet 2012 Malibu Manuel utilisateur

Cadillac

Cadillac 2010 Escalade Manuel utilisateur

Skoda

Skoda FABIA RS - ANNEXE 118 Manuel utilisateur