Ski-Doo 1982 Elite Manuel utilisateur

1982

OPERATOR

MANUAL

..Trademarks of Bomb-ardl$r Inc

All

nghts

reserved

Bombardier

inc

414465200

model

.1.

purchase da

warranty expirydate

0be comeietec dealer at time of sale.

DEALER IMPRINT AREA

TECHNICAL PUBLICATIONS

AFTER

SALES

SERVICE

DEPARTMENT

BOMBARDiER

iNC,

VALCOURT,QUEBEC

CANADA,

JOE

2LO

The following are trademarks

Bem-

h!!"'or.l'4iall" Inc.

BOMBARDIER

EVEREST

SKI-DOO

CITATION

ALPINE ot

YMPIQUE

BUZZARD

rNT

CARRY-BOOSE NORDU(

ELAN SKANDIC

ELITE

GRANOPRIX

SPECIAL

FOREWORD

The Operator Manual and the Snow-

mobile Safety handbook have been

prepared to acquaint the owner Ioper-

ator of a new snowmobile with the var-

ious vehicle controls maintenance and

safe operating instructions. Each is in-

dispensable for the proper use of the

product

and should be kept

with

the

vehicle at all times.

Should you have any questions per-

taining to the warranty and its applica-

tion, please consult the

"Often

Asked

Ouestion" section of this manual, or

your selling dealer.

This manual uses the tollowinq sym-

bols.

•

WARNING:

Identifies an instruc-

tion which, if not followed, could

cause personal injury.

CAUTION: Denotes an instruc-

...

tion which, if not followed, could

severely damage vehicle components.

ONOTE: Indicates supplementary

information needed to fully com-

plete an instruction.

Although the mere reading of such in-

formation does not eliminate the haz-

ard, your understanding of the infor-

mation will promote its correct use.

SAFETY IN MAINTENANCE

Observe

the

following

precautions:

• Throttle mechanism should be check-

ed for free movement before starting

engine.

• The snowmobile engine can be

stopped by activating the emergen-

cy cut-out or tether switches or turn-

ing

off

the key.

• Clean and check operation of the

headlight, tail light and brake light.

• Engine should be running only when

pulley guard is secured in place.

• Never run the engine

without

drive

belt installed. Running an unloaded

engine can prove to be dangerous.

• Never run the engine when the track

is raised

off

the ground.

• It can be dangerous to run engine

with the hood removed.

• Gasoline is flammable and explosive

under certain conditions. Always

manipulate in a well ventilated area.

Do not smoke or allow open flames

or sparks in the vicinity. If gasoline

fumes are noticed while driving, the

cause should be determined and

corrected

without

delay.

• Maintain your vehicle in top mechan-

ical condition at all times.

• Your snowmobile is not designed to

be driven or operated on black top,

bare earth, or other abrasive sur-

faces. On such surfaces abnormal

and excessive wear of critical parts

is inevitable.

• Your snowmobile is not designed to

be operated on public streets, road

or highways. In most States and

Provinces, it is considered an illegal

operation.

• Installation of other than standard

equipment! including ski-spreaders,

bumpers, pack racks! etc., could

severely affect the stability and safe-

ty of your vehicle. Avoid adding on

accessories that alter the basic ve-

hicle configuration.

• Whenever the vehicle is parked out-

doors, overnight or for a long peri-

od! it issuggestedto protect it against

the inclemency of the weather with

asnowmobile cover.

• Do not lubricate throttle

and/or

brake cables and housings.

• Only perform procedures as detailed

in this manual. Unless otherwise

specified, engine should be turned

OFF for all lubrication and mainte-

nance procedures.

• Since engine cooling is fully in ef-

fect only when the vehicle is in mo-

tion, it is not recommended that you

allow the engine to idle for more than

brief periods.

• When removing coolant tank cap,

first place a cloth over cap then turn

cap to its first step to release pres-

sure. Never drain or refill the cooling

system when engine is hot.

• PLEASEREADAND UNDERSTAND

ALL WARNINGS AND CAUTIONS

IN THIS

MANUAL

AND ON THE

VEHICLE.

THIS

MANUAL

SHOULD REMAIN WITH THE VEHICLE AT

THE TIME OF

RESALE.

INDEX

. . .6

. 9

THE 1982

"LIMITED

WARRANTY

OFTEN ASKED

QUESTIONS.

. .

LISTING OF AREA DISTRIBUTORS .

HOW

TO IDENTIFY YOUR

SNOWMOBILE

...

CONTROLS/INSTRUMENTS

Throttle lever, brake lever, ignition switch, light switch, headlamp dimmer switch,

emergency

cut-out

switch, primer, speedometer, temperature gauge, lighter,

handle heat switch, fuel gauge, seat belt, gear shift lever, mirror, alternator

charging light, high beam indicator, injection oil level indicator, engine compart-

ment hood opening, tool box, fuse holders. . . . . . . 10

BREAK-IN PERIOD

Break-in, lO-hour inspection, check list.

FUEL

Recommended gasoline, recommended injection oil

PRE-START CHECK

Check

points.

STARTING PROCEDURE

Electric starting, emergency starting, before riding

.. .13

...............

. .15

....

.15

...

.16

LUBRICATION

Frequency, slide suspension, steering mechanism, rotary valve system, gearbox

oil level, drive axle, driven pulley . . . . . . . . . . .17

MAINTENANCE

Belt guard removal, drive belt removal, drive belt condition, new drive belt, brake

condition, brake adjustment, drive pulley, drive chain tension, suspension condi-

tion, suspension adjustment, track condition, track tension and alignment, steer-

ing mechanism, steering adjustment, spark plugs, battery, exhaust system, en-

gine head nuts, engine

mount

nuts, carburetor adjustment, oil injection pump ad-

justment, cooling system, fan belt, headlamp beam aiming, bulb replacement,

general inspection .......... . 20

STORAGE

Cooling system, tracks, suspension, ski assembly, controls, gearbox, driven pul-

ley, drive pulley, carburetor, fuel tank, cylinder lubrication, battery, chassis, gen-

eral inspection. .......... .................. . 29

PRE-SEASON PREPARATION

Pre-season preparation chart ........... ...34

TROUBLE

SHOOTING

.......... .

...

.35

TOOLS............................

. . .38

SPECIFICATIONS ............ ................. .39

WIRING

DIAGRAM...

.. . .. . .. . . .. . 41

METRIC

INFORMATION

GUIDE.

. . . . . . . . . . . . . . . . 42

CHANGE

OF ADDRESS OR

OWNERSHIP.

.43

LIMITED WARRANTY 1982 SKI-DOO® SNOWMOBILES

1-PERIOD

BOMBARDIER® INC. as manufacturer, warrants FROM THE DATE OF FIRST

CONSUMER SALES, every 1982SKI-DOO® snowmobile, sold as NEW AND UN-

USED, by an authorized SKI-DOO dealer,

for

periods of:

• 12 consecutive months for ELAN®, CITATION*, EVEREST®, EUTE®,

ALPINE® models.

• 90 consecutive days

for

NORDIK*, SKANDIC*, BLiZZARD® 5500MX and 9500

models subject to the following:

1. If delivery is made after the 31st day of March of a given year and before the 1st

day of December of the same year, the above 90 day warranty will start on De-

cember 1st.

2. If delivery is made

on/or

after the 2nd day of January of a given year

but

before

the 31st day of March of the same year, all the unused portion of the 90 day pe-

riod will be carried over to the next winter and start again on the 1st day of De-

cember of the same year.

WHAT

BOMBARDIER WILL DO

BOMBARDIER will repair

and/or

replace, at its option, components defective in

material

and/or

workmanship (under normal use and service,) with a genuine

BOMBARDIER component

without

charge for parts or labour, at any authorized

SKI-DOO dealer during said warranty period.

3-CONDITION TO HAVE WARRANTY WORK PERFORMED

Present to the servicing dealer, the hard copy of the BOMBARDIER Customer Re-

gistration card received by the customer from the selling dealer at time of pur-

chase.

4-WARRANTY TRANSFER

This warranty istransferable to subsequent owner(s)

for

remainder of warranty pe-

riod from original date of sale.

5-EXCLUSIONS - ARE

NOT

WARRANTED

• Normal wear on all items such as, but

not

limited to:

- drive belts

- slider shoes

- spark plugs

breaker points

runners on skis

• Replacement parts

and/or

accessories which are

not

genuine BOMBARDIER

parts

and/or

accessories.

• Damage resulting from installation of parts other than genuine BOMBARDIER

parts.

• Damage caused by failure to provide proper maintenance as detailed in the

Operator Manual. The labour, parts and lubricants costs of all maintenance ser-

vices, including tune-ups and adjustments will be charged to the owner.

• A sulphated battery.

• Vehicles used

for

racing purposes.

• All optional accessories installed on the vehicle.

(The normal warranty policy

for

parts and accessories, if any, applies).

• Damage resulting from accident, fire or other casualty, misuse, abuse or ne-

glect.

• Damage resulting from modification to the snowmobile

not

approved in writing

by BOMBARDIER.

• Lossesincurred by the snowmobile owner other than parts and labour, such as,

but

not

limited to, transportation, towing, telephone calls, taxis, or any other in-

cidental or consequential damages.

Some states or provinces do not allow the exclusion or limitation of inciden-

tal or consequential damages, so the above limitation or exclusion may not

apply.

6•EXPRESSED OR IMPLIED WARRANTIES

This warranty gives you specific rights, and you may also have other legal

rights which

may

vary from state to state, or province to province. Where ap-

plicable this warranty is expressly in lieu

all other expressed or implied

warranties

BOMBARDIER, its distributors and the selling dealer, including

any warranty of merchantability

fitness for any particular purpose; other-

wise the implied warranty is limited to the duration

this warranty.

How-

ever, some states or provinces do not allow limitations on

how

long an im-

plied warranty lasts, so the above limitation

may

not apply.

Neither the distributor, the selling dealer, nor any other person has been

authorized to

make

any affirmation, representation or warranty other than

those contained in this warranty, and if made, such affirmation, representa-

tion or warranty shall

not

be enforceable against BOMBARDIER or any other

person.

BOMBARDIER INC. reserves the right to modify its warranty policy at any

time, being understood that such modification will not alter the warranty

conditions applicable to vehicles sold while the above warranty is in effect.

7-CONSUMER ASSISTANCE

If a servicing problem or other difficulty occurs, we suggest the following:

1. Try to resolve the problem at the dealership

with

the Service Manager or

Owner.

2. If this fails, contact your area distributor listed in the Operator Manual.

3. Then if your grievance still remains unsolved, you may

write

to us:

Bombardier Inc.

Service Department

Recreational Products

Valcourt, Quebec, Canada, JOE 2LO

January 1981

Bombardier Inc.

Valcourt, Quebec, Canada, JOE 2LO

"Trademarks of Bombardier Inc.

OFTEN ASKED

QUESTIONS

Why

must my snowmobile be registered?

After

all I do have my original invoice

as proof of when I purchased my snowmobile.

Your warranty is valid

any authorized dealer

the product. Your regis-

tration is the key element in providing the servicing dealer

with

the necessary

data to complete warranty claim forms. This information is also used to

notify

owners in the event

asafety recall.

How

do I

know

my vehicle has been registered at the factory?

When you

bought

yoursnowmobile the dealer shouldhave completed,

and

forwarded us the manufacturer's

copy

the Customer Warranty Registra-

tion. YOUR DEALER SHOULD HA VEGIVEN YOU THE

HARD

COpy

OF THE

WARRANTY REGISTRA TION FORM.

Q: Ibought my snowmobile in O'King County but I snowmobile in Washington

County. Can the dealer in Washington County accept to perform warranty work

on my snowmobile?

Yes,

any authorizeddealer in North America can perform warranty repairs,

providing the customer warranty registration card is presented.

Q: Where can I find information on the lubrication and maintenance of my snow-

mobile?

In this Operator Manualprovided with the vehicle at the time

first sale.

Q: Will the entire warranty be void or cancelled, if I do not operate or maintain my

new snowmobile exactly as specified in the Operator's Manual?

The warranty

the

new

snowmobile cannot be

"voided"

or "Cancelled".

However,

aparticular failure is caused by operation

maintenance

other

than is shown in the OperatorManual, THA Tteilure may

not

be coveredunder

warranty. This includes service work performed by the customer, especially

the criticaladjustments to ignition, timing, carburation

and

oil

injection/or

oil

mixture.

Q: Would you give some examples of abnormal use or strain, neglect or abuse?

These terms are general

and

overlap each

other

in areas. Some specific ex-

amples may include: running the machine

out

oil, chain teilurecaused by a

lack

lubrication, operating the machine with abroken

damaged

part

which causesanother

part

to fail,

and

so on.

you have

any

specific questions

on operation or maintenance, please contact your dealer

for

advice.

Q: What costs are my responsibility during the warranty period?

Thecustomer's responsibility includes

all

costs

normalmaintenance ser-

vices, non-warranty repairs, accidents

and

collision damage, as well as oils,

and

spark plugs,

and

incidental

consequential damages costs as explained

in the warranty.

Q: Are

"Genuine"

Bombardier replacement parts used in warranty repairs covered

by warranty?

Yes.

When installed

an authorized dealer,

any

"qenuine" Bombardier

part

used in warranty repairs assumes the remaining warranty that exists on

the machine.

I sell my snowmobile within the warranty period, will the

new

owner

qualify

for

the balance

the warranty?

Yes,

provided the

unit

has already been registered with the manufacturer.

Note that the change

ownership card in this manual should be completed

and

sent to Bombardier Inc.

How

can I receive the best owner assistance?

Thesatisfaction

and

goodwill

the owners

Bombardierproducts are

primary concern to your dealer

and

Bombardier Inc. Normally, any problems

that arise in connection with the sales transaction

the operation

your

snowmobile wi/I be handled by your Dealers Sales or Service Departments. It

is recognized, however, that despite the best intentions

everyone concern-

ed, misunderstandings will sometimes occur.

you have a problem that has

not

been handled to your satisfaction through normal channels, we suggest

that you discuss your problem

with

amember

dealership management. Fre-

quently, complaints are the result

abreakdown in communications

and

can

quickly be resolved by a member

the dealership management.

the prob-

lem already has been reviewed with the Sales Manager or Service Manager,

contact the Dealer himself

the General Manager.

LISTING OF AREA DISTRIBUTORS

CANADIAN

DISTRIBUTORS

ALPINE

DISTRIBUTORS

LIMITED

Kalamalka Lake Road

P.O. Box 159

Vernon, British Columbia, V1T

6M2

(604) 545-1314

British Columbia

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

Atlantic

Branch

P.O. Box 670

Shediac,

New

Brunswick,

EOA

3GO

(506) 532-4454

Magdalen Island, Nova Scotia,

New

Brunswick, Prince Edward Island

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

(Quebec Branch)

1350 Nobel Boulevard

Boucherville, Quebec, J4B 1A1

(514) 527-2469 or 655-6121

Province of Quebec

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

Ontario Branch

230 Bayview Drive

Barrie, Ontario, L4N 4Y8

(705) 728-8600

Province of Ontario

BROOKS EQUIPMENT LIMITED

1616 King Edward Street

P.O. Box 985

Winnipeg,

Manitoba,

R3C 2V8

(204) 633-7247

Manitoba, Saskatchewan

HUDSON'S

BAY

CO. LTD.

165 Hymus Blvd

Pointe-Claire, Quebec,

M4W

1A8

(514) 697-8500

North-West Territories, Franklin

District &Keewatin

J.W.

RANDALL

LIMITED

West

Street

P.O.

Box 1050

Corner Brook! Newfoundland! A2H 6G7

(709) 634-3533

Newfoundland, Labrador

TRACT

EQUIPMENT

14325! 114th Avenue

Edmonton, Alberta, T5M 2Y8

(403) 452-9910

Alberta, Dist. Mackenzie, Yukon,

N.W.T.

AMERICAN

DISTRIBUTORS

BOMBARDIER CORPORATION

4505

West

Superior Street

P.O. Box 6106

Duluth,

Minnesota 55806

(218) 628-2881

North Dakota, Minnesota, Wisconsin,

Illinois, Missouri, Michigan, Indiana,

Ohio (less eastern half), Tennessee,

Kentucky, West Virginia, Virginia,

Northern Idaho, Northern Wyoming,

Montana, Iowa, Washington.

ELLIOTT &

HUTCHINS

INC.

East Main Street Road

Malone,

New

York 12953

(518) 483-4411

New York, Massachusetts, Connec-

ticut, Rhode Island, Pennsylvania,

New Jersey, Maryland, Delaware,

District of Columbia, Eastern half of

Ohio, Maine, New Hampshire, Vermont.

MILLER EQUIPMENT

AND

RECREATIONAL CENTER

1049

Whitney

Road

Anchorage, Alaska 99501

(907) 274-9513

Alaska

Table des matières

Autres manuels Ski-Doo Motoneige

Ski-Doo

Ski-Doo OLYMPIQUE 300 Manuel utilisateur

Ski-Doo

Ski-Doo REV Series Guide d'installation

Ski-Doo

Ski-Doo REV G4 Trail/Crossover E-TEC Series Manuel

Ski-Doo

Ski-Doo REV GEN4 Manuel utilisateur

Ski-Doo

Ski-Doo MXZ X 600 RS 2021 Manuel utilisateur

Ski-Doo

Ski-Doo Tundra II LT 1997 Guide d'installation

Ski-Doo

Ski-Doo CK3 Series Manuel

Ski-Doo

Ski-Doo Skandic WT 2013 Manuel

Ski-Doo

Ski-Doo Grand Touring 700/SE Guide d'installation

Ski-Doo

Ski-Doo REV XP 2008 Series Manuel

Ski-Doo

Ski-Doo 861 002 700 Manuel utilisateur

Ski-Doo

Ski-Doo NORDIK 50 1988 Manuel utilisateur

Ski-Doo

Ski-Doo ALPINE VALMOMT Manuel utilisateur

Ski-Doo

Ski-Doo Blizzard 7500 Manuel utilisateur

Ski-Doo

Ski-Doo Tundra R Skandic LT 2003 Manuel du propriétaire

Ski-Doo

Ski-Doo 1978 Blizzard Manuel utilisateur

Ski-Doo

Ski-Doo Safari 1990 Manuel utilisateur

Ski-Doo

Ski-Doo REV GEN4 Manuel

Ski-Doo

Ski-Doo Legend 800 2002 Manuel utilisateur

Ski-Doo

Ski-Doo MX Manuel utilisateur

Ski-Doo

Ski-Doo 1982 Blizzard 9500 Manuel utilisateur

Ski-Doo

Ski-Doo 2000 MX Zx 440 LC Manuel

Ski-Doo

Ski-Doo MX Z 800 2145 2002 Manuel

Ski-Doo

Ski-Doo 1980 citation 3500 Manuel utilisateur

Manuels Motoneige populaires d'autres marques

BRP

BRP Ski-Doo MXZ 120 2023 Manuel utilisateur

Arctic Cat

Arctic Cat ZR 900 Series 2006 Manuel utilisateur

Arctic Cat

Arctic Cat Wildcat EFI Mountain Cat 1994 Manuel utilisateur

BOMBARDIER

BOMBARDIER Ski-Doo Alpine 74 1959 Manuel utilisateur

Arctic Cat

Arctic Cat Cougar Manuel utilisateur

Yamaha

Yamaha SnoScoot SXR2NJ Manuel utilisateur

Yamaha

Yamaha VX500XTB Manuel utilisateur

Yamaha

Yamaha RS VENTURE 2014 Manuel utilisateur

Polaris

Polaris RMK Shift Manuel utilisateur

Yamaha

Yamaha VK540EF Manuel utilisateur

Yamaha

Yamaha VK540EF Manuel utilisateur

BOMBARDIER

BOMBARDIER ski-doo Nordic 640ER 1974 Manuel utilisateur

BOMBARDIER

BOMBARDIER ski-doo OLYMPIQUE 300 1974 Manuel utilisateur

Yamaha

Yamaha SXV4NP Manuel utilisateur

Ohlins

Ohlins PB 616 Manuel utilisateur

Polaris

Polaris 600 RUSH 2013 Mode d’emploi

BOMBARDIER

BOMBARDIER Ski-doo MX ZX 440 Manuel

Polaris

Polaris 600 INDY VOYAGEUR Manuel utilisateur