Rollplay W488 Manuel utilisateur

Mercedes Benz GL (W488)

Customer Service Guide

2

Customer Service Guide

Contents

I) Check Battery …………………………............................................. 3

II) Check Wiring Condition ……………………………..………………………. 5

III) Check Foot Pedal ………………………………………………………….….... 12

IV) Gearbox Replacement …………………………………………..…………… 14

V) Door Replacement .…………………………………..…….……..….………. 17

VI)Motor Control Board Replacement .….………..…….……..….………. 19

VII) Headlight Replacement .….……………………...…….……..….………. 21

VIII) Schematic diagram ……………..…………….…..….………..……………. 22

IX) Exploded View …………..………………..…....….……….……..…….…… 23

CAUTION :

Disconnect the battery before proceeding.

3

Customer Service Guide

I) Check Battery

Operation: Using a Flat head screwdriver, unlock and remove the seat. Locate the battery

harness, unplug the connector, and use a volt-meter to check battery condition

at battery side.

Step (1)

Turn and unlock this plastic knob according to the icon

Step (2)

Unplug the battery connector (red) by holding down

the small clip and pulling apart.

4

Customer Service Guide

I) Check Battery

Step

(3)

Voltage Reading: 6.0 V ~ 6.5 V –Good condition

5.6 V ~ 5.9 V –Proceed to Recharge

5.5 V –Battery to be recharged if after the stipulated

recharging time, voltage has not increased,

the Battery needs replacement

Below 5.5 V –Battery needs replacement

5

Customer Service Guide

II) Check Wiring Connection

Operation: Disconnect and reconnect all plugs and connections leading to the drive board

shown below.

A. Motor/Gearbox : Follow above (Point I) to remove the seat, locate the Gearbox

harness underneath.

Customer Service Guide

VI)Motor Control Board Replacement

Operation: Follow above (Point I) to remove the seat first and replace the Motor Control

Board (MCB) by below steps.

Customer Service Guide

Re-Coding Remote Control

Follow the below steps if;

1: Replacing the receiver/drive board module in the vehicle or

2: Remote control function is not operating as it should.

Note: The remote coding button should be held down for 5 seconds & then hold down

the receiver/module reset coding button for 5 seconds.

7

Customer Service Guide

II) Check Wiring Connection

C. Dashboard : Remove the Steering Wheel and Dashboard to check the connection.

Step (1)

Unscrew then pull up & out to remove steering wheel

Step (2)

Next, unscrew these two screws to remove the dashboard

8

Customer Service Guide

II) Check Wiring Connection

Step (3)

Pull up & out to remove the dashboard and windshield

together as one unit.

Step (4)

Check the 4-Pin plug

9

Customer Service Guide

II) Check Wiring Connection

D. Shifter : Follow steps above to remove the Dashboard, then check the connection

of Shifter and Main Power Switch as well.

Step (1)

Unplug this connector

Step (2)

Unscrew these four screws to remove the Windshield

Table des matières

Autres manuels Rollplay Voiture jouet motorisée

Rollplay

Rollplay W503 Instructions de montage

Rollplay

Rollplay W461P-01 Instructions de montage

Rollplay

Rollplay Nighthawk NexGen W502 Instructions de montage

Rollplay

Rollplay W461-RT Instructions de montage

Rollplay

Rollplay W462 Manuel utilisateur

Rollplay

Rollplay W441 Instructions de montage

Rollplay

Rollplay W461P-02 Instructions de montage

Rollplay

Rollplay Audi R8 Spyder Instructions de montage

Rollplay

Rollplay BMW X5 Manuel utilisateur

Rollplay

Rollplay FLEX Kart XL Instructions de montage

Rollplay

Rollplay 12V GMC Sierra Denali Instructions de montage

Rollplay

Rollplay W458AC-F Instructions de montage

Rollplay

Rollplay W442 Instructions de montage

Rollplay

Rollplay BMW i8 Concept Spyder Manuel utilisateur

Rollplay

Rollplay W488AD Manuel utilisateur

Rollplay

Rollplay W483RAC Instructions de montage

Rollplay

Rollplay W348AC Instructions de montage

Rollplay

Rollplay W495NB Instructions de montage

Rollplay

Rollplay 6V BMW X5 Manuel utilisateur

Rollplay

Rollplay BMW i8 Concept Spyder Manuel utilisateur

Rollplay

Rollplay 6V Mini Quad ACQUAD-P Manuel utilisateur

Rollplay

Rollplay STORM Instructions de montage

Rollplay

Rollplay 6V Porsche 918 Instructions de montage

Rollplay

Rollplay W488AC Instructions de montage

Manuels Voiture jouet motorisée populaires d'autres marques

Eduard

Eduard Humber Scout Car Mk.I exterior Manuel utilisateur

Traxxas

Traxxas 4995X Manuel utilisateur

Jamara

Jamara VW T1 Bus Manuel utilisateur

REVELL

REVELL 68 CHEVY CHEVELLE SS 396 Manuel utilisateur

Schumacher

Schumacher Pro Cat Manuel utilisateur

Tamiya

Tamiya TT-01 TYPE E Manuel utilisateur

Eduard

Eduard Krupp Protze 6x4 1/48 Manuel utilisateur

New Bright

New Bright 61072UEP Manuel utilisateur

Team Durango

Team Durango DEX410v5 Manuel utilisateur

Jamara

Jamara Mercedes Actros Muldenkipper 2,4 GHz Manuel utilisateur

PLAYMOBIL

PLAYMOBIL 9536 Manuel utilisateur

Atomic

Atomic BZ3 Manuel utilisateur

Aiyaplay

Aiyaplay 370-290V00 Manuel utilisateur

Power Wheels

Power Wheels GRJ53 Manuel utilisateur

ZEROTRIBE

ZEROTRIBE Zetricks ZT1144 Manuel utilisateur

INJUSA

INJUSA 412 Manuel utilisateur

Maverick

Maverick MSC-30BR-WP Manuel utilisateur

Land of B.

Land of B. Rollin' Riders Manuel utilisateur