Prorack K657 Manuel utilisateur

K657

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 4 x 4 x 8 x 2

x 2 x 4 x 4 x 2

x 2 x 2 x 2

Revision No: 1A 1

Fitting Kit K657

MAX kgs (lbs)

W/P WHD

Hyundai

Santa Fe , 5dr SUV 12-+ ZA 75 kgs (165 lbs) 75 kgs (165 lbs)

Santa Fe , 5dr SUV 12-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)

Santa Fe , 5dr SUV 12-+ NZ 75 kgs (165 lbs) 75 kgs (165 lbs)

Santa Fe Sport, 5dr SUV 13-+ US 75 kgs (165 lbs) 75 kgs (165 lbs)

Santa Fe , 5dr SUV Aug 12-+ AU 75 kgs (165 lbs) 75 kgs (165 lbs)

Fitting Kit EN

K657

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type A crossbar

fitted. They also apply to type B, C and D.

●Use keys to remove covers.

Fitting Kit EN

K657

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment.

●Ensure each end of the crossbar is

adjusted equally.

●Set bars to length (refer to the crossbar

instructions for crossbar adjustment).

●Clamps onto flush roof rail. Pins locate on

inside of rail.

Fitting Kit EN

K657

●Tighten adjusting screw to 5 Nm (3.7 ft lb).

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

●Remove both pins from each leg. Use

tapered end of spanner located inside left

hand cover to assist.

Fitting Kit EN

K657

●Detach foot from leg. Store loose parts in a

safe place.

●Repeat for all legs.

●Select four feet assemblies and match the

left and right assemblies to the left and

right roof rack legs.

●Assemble foot from kit into leg by pressing

it down.

●Ensure foot interlocks with leg.

●Using short capscrew and washer, secure

assembly onto leg (use Hex Screwdriver

supplied with crossbar to assist)

●Do not over tighten.

●Repeat for all legs.

Fitting Kit EN

K657

●Use two M5 x 12 mm self tapping screws to

secure the assembly onto the leg.

●Do not over tighten.

●Apply protective strip as shown.

Trim if required.

●It is important to put the clamps in the

correct position on the vehicle.

●Letters refer to the part numbers stamped

on clamps.

●Clamp Part Number:

A = 915A

B = 929A

Fitting Kit EN

K657

Fitment

●Locate three holes at each position along

the inside of the roof rails.

●Place crossbars approximately above

these holes on roof rails.

●Ensure back edge of foot sits flush with the

back edge of vehicle roof rail.

●Place one hand on the leg and apply

downward pressure.

●Slide clamp through opening in leg.

Fitting Kit EN

K657

●Ensure the pins of the clamps engage

correctly with the holes in the roof rail.

●Thread the coach bolt through the clamp

and the leg.

●Tighten the red plastic knob.

●Ensure the red plastic knob is in the

position shown when fully tightened.

●Do not over tighten.

●Repeat for all four positions.

●Ensure the clamp engages correctly on

inside of roof rail.

●Use keys to fit and lock covers

●Check crossbar is securely attached to the

vehicle.

Fitting Kit EN

K657

CAUTION: Recheck all fasteners immediately after

a load is applied to the crossbars.

Regularly check screws are tight.

Table des matières

Autres manuels Prorack Accessoires automobiles

Prorack

Prorack K710 Manuel utilisateur

Prorack

Prorack K050 Manuel utilisateur

Prorack

Prorack WHISPBAR S41 Manuel d'utilisation et d'installation

Prorack

Prorack K072 Manuel utilisateur

Prorack

Prorack K1222 Manuel utilisateur

Prorack

Prorack K435 Manuel d'utilisation et d'installation

Prorack

Prorack VOYAGER PR3207 Manuel utilisateur

Prorack

Prorack K346 Manuel utilisateur

Prorack

Prorack K434 Manuel utilisateur

Prorack

Prorack K926 Manuel d'utilisation et d'installation

Prorack

Prorack Whispbar S42 Manuel utilisateur

Prorack

Prorack K519 Manuel d'utilisation et d'installation

Prorack

Prorack K592 Manuel utilisateur

Prorack

Prorack K843 Manuel utilisateur

Prorack

Prorack K408 Manuel utilisateur

Prorack

Prorack K486 Manuel utilisateur

Prorack

Prorack K431 Manuel utilisateur

Prorack

Prorack K512 Manuel utilisateur

Prorack

Prorack K447 Manuel utilisateur

Prorack

Prorack K105 Manuel d'utilisation et d'installation

Prorack

Prorack K919 Manuel utilisateur

Prorack

Prorack K1062 Manuel utilisateur

Prorack

Prorack K866 Manuel utilisateur

Prorack

Prorack K402 Manuel utilisateur

Manuels Accessoires automobiles populaires d'autres marques

James Baroud

James Baroud Odyssey Manuel utilisateur

Motorola

Motorola i50sx Manuel utilisateur

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manuel utilisateur

Feniex

Feniex T3 Manuel utilisateur

Renault

Renault 77 11 423 180 Manuel utilisateur

Kia

Kia E8300-4D000 Manuel utilisateur

Brink

Brink 756843 Manuel utilisateur

Whispbar

Whispbar K085W Manuel utilisateur

v.link

v.link CI-VL2-PC-HSD Manuel utilisateur

Viking

Viking Stack-Rack Guide de configuration rapide

Aries

Aries 203015 Manuel utilisateur

Choetech

Choetech AT0005 Manuel utilisateur

ZZ2

ZZ2 ZZAIR-PRO Manuel utilisateur

Holman

Holman 4A80L Manuel utilisateur

Thule

Thule 2075 Manuel utilisateur

Motorola

Motorola T325 Manuel utilisateur

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guide d'installation

DV8

DV8 FBJL-02 Manuel utilisateur