Prorack K447 Manuel utilisateur

K447

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 1 x 1 x 6 x 6

x 6 x 4 x 2 x 6

Revision No: 7G 1

Fitting Kit K447

x 2 x 1 x 1 x 1

x 2

Fitting Kit K447

MAX kgs (lbs)

W/P WHD

Volkswagen

Caddy Maxi (3 Bar), 5dr Van 08-14 ZA 35 kgs (77 lbs) 50 kgs (110 lbs)

Caddy Maxi (3 Bar), 5dr Van 08-Nov 15 AU 35 kgs (77 lbs) 50 kgs (110 lbs)

Caddy Maxi (3 Bar), 5dr Van 08-Nov 15 NZ 35 kgs (77 lbs) 50 kgs (110 lbs)

Fitting Kit K447

A B C 1 2 3

Caddy Maxi (3 Bar), 5dr Van 08-14 (ZA) 100mm 860mm - 818mm 790mm 782mm

3 15/16ths" 33 7/8ths" - 32 3/16ths" 31 1/8ths" 30 13/16ths"

Caddy Maxi (3 Bar), 5dr Van 08-Nov 15 (AU) 100mm 860mm - 818mm 790mm 782mm

3 15/16ths" 33 7/8ths" - 32 3/16ths" 31 1/8ths" 30 13/16ths"

Caddy Maxi (3 Bar), 5dr Van 08-Nov 15 (NZ) 100mm 860mm - 818mm 790mm 782mm

3 15/16ths" 33 7/8ths" - 32 3/16ths" 31 1/8ths" 30 13/16ths"

Fitting Kit EN

K447

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type A crossbar

fitted. They also apply to type B, C and D.

●Use keys to remove covers.

Fitting Kit EN

K447

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment method.

●Ensure each end of the crossbar is

adjusted equally.

●Adjust crossbar in or out to suit vehicle.

Refer to the crossbar instructions for

crossbar adjustment.

●Please check the front of this manual for

information relating specifically to your

vehicle.

Fitting Kit EN

K447

●Tighten adjusting screw to 5 Nm (3.7 ft lb)

hand tight.

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

●Select plastic internal block (from fitting kit)

and insert into foot.

●Repeat for all legs.

Fitting Kit EN

K447

●Refer to the underside of the pad for the

part number.

●It is important to put the pads in the correct

position on the vehicle.

●Letters refer to the pad part numbers and

position.

●Pad Part Number:

A = 11-04-216 Pads with bars

B = 11-04-219

C = 11-04-226

D = 11-04-227

●Fit rubber pads (supplied with fitting kit) to

foot. Pad may vary in shape to that shown.

●Make sure the pad fits into the holes

underneath the foot.

Fitting Kit EN

K447

Fitment

●Remove fixed-point cover screws with 5mm

Hex Key.

●Use the following grubscrew lengths for

each position:

A = M8 x 55mm (2 1/8")

B = M8 x 70mm (2 3/4")

●Select grubscrews and screw into the

vehicle's fixed points.

●For additional weather protection, apply

silicon sealant in and around fixed point

hole and grubscrew (sealant not supplied).

●Place M8 washer over grubscrew.

●Fit nut to grubscrew.

●Height

Front: 60mm

Middle: 35mm

Rear: 40mm

Fitting Kit EN

K447

●Place crossbar foot over clamp.

●Tighten the plastic knob.

●In the fully tightened position, the knobs

should be parallel with the vehicle.

●Repeat for all four positions.

●Check crossbar is securely attached to the

vehicle.

●Use keys to fit and lock covers

Table des matières

Autres manuels Prorack Accessoires automobiles

Prorack

Prorack K372 Manuel d'utilisation et d'installation

Prorack

Prorack K1012 Manuel utilisateur

Prorack

Prorack K527 Manuel utilisateur

Prorack

Prorack PR3077 Manuel utilisateur

Prorack

Prorack K877 Manuel d'utilisation et d'installation

Prorack

Prorack K1018 Manuel utilisateur

Prorack

Prorack K1045 Manuel utilisateur

Prorack

Prorack K618 Manuel utilisateur

Prorack

Prorack K100 Manuel utilisateur

Prorack

Prorack WHISPBAR S53 Manuel d'utilisation et d'installation

Prorack

Prorack K381W Manuel utilisateur

Prorack

Prorack PR3090 Manuel utilisateur

Prorack

Prorack K568 Manuel utilisateur

Prorack

Prorack K652 Manuel utilisateur

Prorack

Prorack K827 Manuel utilisateur

Prorack

Prorack K934 Manuel d'utilisation et d'installation

Prorack

Prorack K446W Manuel d'utilisation et d'installation

Prorack

Prorack K1188 Manuel utilisateur

Prorack

Prorack K719 Manuel utilisateur

Prorack

Prorack K031 Manuel d'utilisation et d'installation

Prorack

Prorack K363 Manuel utilisateur

Prorack

Prorack K554 Manuel d'utilisation et d'installation

Prorack

Prorack K708 Manuel utilisateur

Prorack

Prorack K954 Manuel utilisateur

Manuels Accessoires automobiles populaires d'autres marques

James Baroud

James Baroud Odyssey Manuel utilisateur

Motorola

Motorola i50sx Manuel utilisateur

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manuel utilisateur

Feniex

Feniex T3 Manuel utilisateur

Renault

Renault 77 11 423 180 Manuel utilisateur

Kia

Kia E8300-4D000 Manuel utilisateur

Brink

Brink 756843 Manuel utilisateur

Whispbar

Whispbar K085W Manuel utilisateur

v.link

v.link CI-VL2-PC-HSD Manuel utilisateur

Viking

Viking Stack-Rack Guide de configuration rapide

Aries

Aries 203015 Manuel utilisateur

Choetech

Choetech AT0005 Manuel utilisateur

ZZ2

ZZ2 ZZAIR-PRO Manuel utilisateur

Holman

Holman 4A80L Manuel utilisateur

Thule

Thule 2075 Manuel utilisateur

Motorola

Motorola T325 Manuel utilisateur

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guide d'installation

DV8

DV8 FBJL-02 Manuel utilisateur