Powerware 9125 PowerPass Manuel utilisateur
9125
USER’S GUIDE
PowerPass®Distribution
Module (PDM)
For use with Two-in-One
5000/6000 VA Models
R
www.powerware.com
9125
USER’S GUIDE
PowerPass®Distribution
Module (PDM)
For use with Two-in-One
5000/6000 VA Models
R
www.powerware.com
Class A EMC Statements
FCC Part 15
NOTE This equipment has been tested and found to comply with the limits for a Class A digital device,
pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against
harmful interference when the equipment is operated in a commercial environment. This equipment
generates, uses, and can radiate radio frequency energy and, if not installed and used in accordance with
the instruction manual, may cause harmful interference to radio communications. Operation of this
equipment in a residential area is likely to cause harmful interference in which case the user will be
required to correct the interference at his own expense.
ICES-003
This Class A Interference Causing Equipment meets all requirements of the Canadian Interference
Causing Equipment Regulations ICES-003.
Cet appareil numérique de la classe A respecte toutes les exigences du Reglement sur le matériel
brouilleur du Canada.
EN50091-2
Some configurations are classified under EN50091-2 as “Class-A UPS for Unrestricted Sales Distribution.”
For these configurations, the following applies:
WARNING This is a Class A-UPS Product. In a domestic environment, this product may cause radio
interference, in which case, the user may be required to take additional measures.
Requesting a Declaration of Conformity
Units that are labeled with a CE mark comply with the following harmonized standards and EU
directives:
쑺Harmonized Standards: EN 50091-1-1 and EN 50091-2; IEC 60950 Third Edition
쑺EU Directives: 73/23/EEC, Council Directive on equipment designed for use within certain voltage
limits
93/68/EEC, Amending Directive 73/23/EEC
89/336/EEC, Council Directive relating to electromagnetic compatibility
92/31/EEC, Amending Directive 89/336/EEC relating to EMC
The EC Declaration of Conformity is available upon request for products with a CE mark. For copies of
the EC Declaration of Conformity, contact:
Powerware Corporation
Koskelontie 13
FIN-02920 Espoo
Finland
Phone: +358-9-452 661
Fax: +358-9-452 665 68
Powerware and PowerPass are registered trademarks of Powerware Corporation.
Greenlee is a registered trademark of Greenlee Textron.
ECopyright 2003–2004 Powerware Corporation, Raleigh, NC, USA. All rights reserved. No part of this
document may be reproduced in any way without the express written approval of Powerware
Corporation.
i
Powerware®9125 Two-in-One (5000/6000 VA) PDM User’s Guide SRev B www.powerware.com
Table of Contents
1Introduction 1...............................................
Safety Warnings 1.........................................................
2 Installation 11.................................................
Inspecting the Equipment 11.................................................
PDM Setup 11.............................................................
UPS Setup 12..............................................................
Installing the Internal Batteries 12..........................................
Tower Setup 14.........................................................
EBM Installation 16.........................................................
Plug-Receptacle PDM Installation 17..........................................
Remote Emergency Power-Off 21.............................................
Hardwired PDM Installation 23...............................................
PDM Rear Panels 29........................................................
3 Configuration 31..............................................
Configuration Mode 31.....................................................
4Operation 35..................................................
Using Maintenance Bypass 35................................................
5 Specifications 37..............................................
6PDMSchematics 39............................................
7 Service and Support 47........................................
Table of Contents
ii Powerware®9125 Two-in-One (5000/6000 VA) PDM User’s Guide SRev B www.powerware.com
1
Powerware®9125 Two-in-One (5000/6000 VA) PDM User’s Guide SRev B www.powerware.com
Chapter 1 Introduction
The PowerPass®Distribution Module (PDM) is designed to operate with a
5000/6000 VA Powerware®9125 uninterruptible power system (UPS). The
PDM allows you to:
쑺Replace or upgrade the UPS without losing power to the protected
equipment (see “Using Maintenance Bypass” on page 35).
쑺Provide surge protection if the UPS is not present.
쑺Provide extra surge protection when the UPS is present.
Safety Warnings
IMPORTANT SAFETY INSTRUCTIONS
SAVE THESE INSTRUCTIONS
This manual contains important instructions that you should follow during
installation and maintenance of the UPS. Please read all instructions before
operating the equipment and save this manual for future reference.
CAUTION
쑺There are NO USER SERVICEABLE PARTS inside the UPS. All repairs and
service should be performed by AUTHORIZED SERVICE PERSONNEL ONLY.
쑺To reduce the risk of fire or electric shock, install this UPS in a temperature
and humidity controlled, indoor environment, free of conductive
contaminants. Ambient temperature must not exceed 40°C (104°F). Do not
operate near water or excessive humidity (95% max).
쑺For PDM models with hardwired outputs, overcurrent protection for the
output AC circuit(s) is to be provided by others.
쑺For PDM models with hardwired outputs, suitably rated disconnect switches
for the output AC circuit(s) are to be provided by others.
Introduction
2Powerware®9125 Two-in-One (5000/6000 VA) PDM User’s Guide SRev B www.powerware.com
Sikkerhedsanvisninger
VIGTIGE SIKKERHEDSANVISNINGER
GEM DISSE ANVISNINGER
DENNE BRUGERVEJLEDNING INDEHOLDER VIGTIGE
SIKKERHEDSANVISNINGER
ADVARSEL
쑺Denne UPS indeholder LIVSFARLIG HØJSPÆNDING. Alle reparationer og
vedligeholdelse bør kun udføres af en AUTORISERET SERVICETEKNIKER.
Ingen af UPS’ens indvendige dele kan repareres af brugeren.
쑺Installér denne UPS i et temperatur- og fugtighedskontrolleret
indendørsmiljø, frit for ledende forureningsstoffer for at formindske risikoen
for brand og elektrisk stød. Rumtemperaturen må ikke overstige 40°C.
UPS’en bør ikke betjenes nær vand eller høj fugtighed (maksimalt 95%).
쑺For PDM systemer med hårdledningsudgange, skal overstrømsbeskyttelse for
vekslestrømmens udgangskredsløb forsynes af andre.
쑺For PDM systemer med hårdledningsudgange, skal egnede, nominelle
afbryderkontakter for vekslestrømmens udgangskredsløb forsynes af andre.
Belangrijke Veiligheidsinstructies
BELANGRIJKE VEILIGHEIDSINSTRUCTIES
BEWAAR DEZE INSTRUCTIES
DEZE HANDLEIDING BEVAT BELANGRIJKE
VEILIGHEIDSINSTRUCTIES
OPGELET
쑺Deze UPS bevat LEVENSGEVAARLIJKE ELEKTRISCHE SPANNING. Alle
reparaties en onderhoud dienen UITSLUITEND DOOR ERKEND
SERVICEPERSONEEL te worden uitgevoerd. Er bevinden zich GEEN
ONDERDELEN in de UPS die DOOR DE GEBRUIKER kunnen worden
GEREPAREERD.
쑺Teneinde de kans op brand of elektrische schok te verminderen dient deze
UPS in een gebouw met temperatuur- en vochtigheidregeling te worden
geïnstalleerd, waar geen geleidende verontreinigingen aanwezig zijn. De
omgevingstemperatuur mag 40°C niet overschrijden. Niet gebruiken in de
buurt van water of bij zeer hoge vochtigheid (max. 95%).
Introduction
3
Powerware®9125 Two-in-One (5000/6000 VA) PDM User’s Guide SRev B www.powerware.com
쑺Voor PDM systemen met vast-bedrade uitgangen, moet de
overstroombeveiliging voor wisselstroom uitvoercircuit(s) door anderen
worden geleverd.
쑺Voor PDM systemen met vast-bedrade uitgangen, moeten de juiste
hoofdschakelaars voor wisselstroom uitvoercircuit(s) door anderen worden
geleverd.
Tarkeita Turvaohjeita
TÄRKEITÄ TURVAOHJEITA - SUOMI
SÄILYTÄ NÄMÄ OHJEET
TÄMÄ OPAS SISÄLTÄÄ TÄRKEITÄ TURVAOHJEITA
VARO
쑺Tämä UPS sisältää HENGENVAARALLISIA JÄNNITTEITÄ. Kaikki korjaukset ja
huollot on jätettävä VAIN VALTUUTETUN HUOLTOHENKILÖN TOIMEKSI.
UPS ei sisällä MITÄÄN KÄYTTÄJÄN HUOLLETTAVIA OSIA.
쑺Vähentääksesi tulipalon ja sähköiskun vaaraa asenna tämä UPS sisätiloihin,
joissa lämpötila ja kosteus on säädettävissä ja joissa ei ole virtaa johtavia
epäpuhtauksia. Ympäristön lämpötila ei saa ylittää 40 °C. Älä käytä lähellä
vettä ja vältä kosteita tiloja (95 % maksimi).
쑺PDM-järjestelmissä kiintealla asennuksella: kuormana olevien laitteiden
ylivirtasuojaus ja erotuskytkimet tulee toteuttaa kuormapiireissa.
Introduction
4Powerware®9125 Two-in-One (5000/6000 VA) PDM User’s Guide SRev B www.powerware.com
Consignes de sécurité
CONSIGNES DE SÉCURITÉ IMPORTANTES
CONSERVER CES INSTRUCTIONS
CE MANUEL CONTIENT DES CONSIGNES DE SÉCURITÉ
IMPORTANTES
ATTENTION!
쑺Cet onduleur contient des TENSIONS MORTELLES. Toute opération
d’entretien et de réparation doit être EXCLUSIVEMENT CONFIÉE A UN
PERSONNEL QUALIFIÉ AGRÉÉ. AUCUNE PIÈCE RÉPARABLE PAR
L’UTILISATEURnesetrouvedansl’onduleur.
쑺Pour réduire les risques d’incendie et de décharge électrique, installer
l’onduleur uniquement à l’intérieur, dans un lieu dépourvu de matériaux
conducteurs, où la température et l’humidité ambiantes sont contrôlées. La
température ambiante ne doit pas dépasser 40 °C. Ne pas utiliser à
proximité d’eau ou dans une atmosphère excessivement humide (95 %
maximum).
쑺Pour les models PDM ayant des sorties câblées, la protection contre une
surintensité pour le(s) circuit(s) de sortie de courant alternatif doit être
fournie par un autre fournisseur.
쑺Pour les models PDM ayant des sorties câblées, les interrupteurs de
déconnexion convenables pour le(s) circuit(s) de sortie de courant alternatif
doivent être fournie par un autre fournisseur.
Autres manuels pour 9125 PowerPass
1
Table des matières
Manuels Unité de contrôle populaires d'autres marques
Festo
Festo Compact Performance CP-FB6-E Manuel de la liste des pièces
Elo TouchSystems
Elo TouchSystems DMS-SA19P-EXTME Manuel utilisateur
JS Automation
JS Automation MPC3034A Manuel utilisateur
JAUDT
JAUDT SW GII 6406 Series Guide rapide
Spektrum
Spektrum Air Module System Manuel utilisateur
BOC Edwards
BOC Edwards Q Series Manuel utilisateur
