Polar Electro CD229-A Manuel utilisateur

Model:

CD229-A / CD230-A

Refrigerated

Merchandiser

Instruction manual

CD229-A_CD230-A_A5_v2_20200903.indb 1CD229-A_CD230-A_A5_v2_20200903.indb 1 2020/9/3 09:402020/9/3 09:40

AU Telephone Helpline: 1300225960

Safety Tips

• Position on a flat, stable surface.

• A service agent/qualified technician should carry out

installation and any repairs if required. Do not remove any

components or service panels on this product.

• Consult Local and National Standards to comply with the

following:

- Health and Safety at Work Legislation

- Fire Precautions

- Wiring Regulations

- Building Regulations

• DO NOT use jet/pressure washers to clean the appliance.

• DO NOT use the appliance outside.

• DO NOT use this appliance to store medical supplies.

• DO NOT allow oil or fat to come into contact with the plastic

components or door seal. Clean immediately if contact occurs.

• DO NOT store products on top of the appliance.

• Bottles that contain a high percentage of alcohol must be

sealed and placed vertically in the refrigerator.

• Always carry, store and handle the appliance in a vertical

position and move by holding the base of the appliance.

• Always switch off and disconnect the power supply to the unit

before cleaning.

• Keep all packaging away from children. Dispose of the

packaging in accordance with the regulations of local

authorities.

• If the power cord is damaged, it must be replaced by a POLAR

agent or a recommended qualified technician in order to avoid

a hazard.

• Children should be supervised to ensure that they do not play

with the appliance.

CD229-A_CD230-A_A5_v2_20200903.indb 2CD229-A_CD230-A_A5_v2_20200903.indb 2 2020/9/3 09:402020/9/3 09:40

Telephone Helpline: 1300225960

• This appliance is not intended for use by persons (including

children) with reduced physical, sensory or mental capabilities,

or lack of experience or knowledge, unless they have been

given supervision or instruction concerning the use of the

appliance by a person responsible for their safety.

• Polar recommends that this appliance should be periodically

tested (at least annually) by a Competent Person. Testing

should include, but not be limited to: Visual Inspection,

Polarity Test, Earth Continuity, Insulation Continuity and

Functional Testing.

Caution Risk of Fire

• Do not store explosive substances such as aerosol cans

with a flammable propellant in this appliance.

Warning: Keep all ventilation openings clear of

obstruction. Unit should not be boxed in without

adequate ventilation.

• Warning: Do not use mechanical devices or other means

to accelerate the defrosting process, other than those

recommended by the manufacturer.

• Warning: Do not damage the refrigerant circuit.

• Warning: Do not use electrical appliances inside the food

storage compartments of the appliance, unless they are the

type recommended by the manufacturer.

Product Description

CD229-A - POLAR Refrigerated Display Merchandiser 120 litre

CD230-A - POLAR Refrigerated Display Merchandiser 160 litre

Pack Contents

• POLAR Counter-Top Refrigerated Merchandiser

• Shelves x 2

• Instruction manual

POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are

supplied fully functional and free of damage.

Should you find any damage as a result of transit, please contact your POLAR dealer immediately.

CD229-A_CD230-A_A5_v2_20200903.indb 3CD229-A_CD230-A_A5_v2_20200903.indb 3 2020/9/3 09:402020/9/3 09:40

AU Telephone Helpline: 1300225960

Installation

Note: If the unit has not been

stored or moved in an upright

position, let it stand upright for

approximately 12 hours before

operation. If in doubt allow to

stand.

1. Remove the appliance from the packaging.

Make sure that all protective plastic film and

coatings are thoroughly removed from all

surfaces.

2. Maintain a distance of 20cm (7 inches)

between the unit and walls or other objects for

ventilation. NEVER LOCATE NEXT TO OR

NEAR A HEAT SOURCE.

Note: Before using the appliance

for the first time, clean the

shelves and interior with soapy

water.

Operation

Control Panel

The control panel is located below the doors on the

rear of the appliance.

Turn On

1. Close the doors of the appliance

2. Connect the appliance to a mains power supply

3. Press the button to turn the light On or Off

as required.

Setting the Operating Temperature

1. Press the SET button. The display will flash

2. Press the or buttons to display the

required temperature.

3. Press the SET button to store the temperature

Table of Controller Parameters

The operating parameters of this appliance have been preset for optimum performance and to maximise

the life of the appliance.

Note: The range refers to controller not machine capability, e.g. these units will function

between 0°C and 12°C only so parameters E1 and E2 should be set between 0°C and 12°C .

Display Parameter Preset Value Range

E1 Lower set temperature 0°C -20°C to 2°C

E2 Upper set temperature 12°C 2°C to 45°C

E3 Temperature buffer 4°C 1°C to 10°C

E4 Temperature buffer time delay 3 minutes 0 to 10 minutes

E5 Fixed parameter 0 DO NOT CHANGE

E6 Fixed parameter 00 DO NOT CHANGE

F1 Defrost period 25 minutes 1 to 60 minutes

F2 Defrost interval 6 hours 1 to 24 hours

F3 Defrost temperature 20°C 0°C to 22°C

F4 Centigrade/Fahrenheit 0°C °C/°F

CD229-A_CD230-A_A5_v2_20200903.indb 4CD229-A_CD230-A_A5_v2_20200903.indb 4 2020/9/3 09:402020/9/3 09:40

Telephone Helpline: 1300225960

Should the parameter need adjusting:

1. Press and hold the SET button for six seconds. The “E1” parameter is displayed

2. Press the or buttons until the required value is displayed

3. Press the SET button to store the new value and cycle to the next parameter

NOTE: The controller times out after 10 seconds if no buttons are pressed

Manual Defrost:

Press and hold the button for 6 seconds to begin automatic defrost. The defrost light illuminates

Cleaning, Care & Maintenance

1. Switch off and disconnect from the power supply before cleaning.

2. The doors can be removed for ease of cleaning

3. Clean the interior of the appliance as often as possible

4. Do not use abrasive cleaning agents. These can leave harmful residues

5. Clean the door seal with warm soapy water

6. Always wipe dry after cleaning

Replacing the Interior Lamp

Call your POLAR dealer or a qualified electrician, the Lamp Assembly is available to purchase as a spare

part.

Cleaning the Condenser

Periodically cleaning the condenser can extend the life of the appliance. POLAR recommend that a POLAR

agent or qualified technician clean the condenser.

Troubleshooting

If your POLAR appliance develops a fault, please check the following table before making a call to the

Helpline or your POLAR dealer.

Fault Probable Cause Solution

The appliance is not

working

The unit is not switched on Check the unit is plugged in correctly and

switched on

Plug and lead are damaged Call POLAR agent or qualified Technician

Fuse in the plug has blown Replace the fuse

Power supply Check power supply

Internal wiring fault Call POLAR agent or qualified Technician

CD229-A_CD230-A_A5_v2_20200903.indb 5CD229-A_CD230-A_A5_v2_20200903.indb 5 2020/9/3 09:402020/9/3 09:40

AU Telephone Helpline: 1300225960

Fault Probable Cause Solution

The appliance

turns on, but the

temperature is too

high/ low

Too much ice on the condenser Defrost the appliance

Condenser blocked with dust Call POLAR or qualified technician

Doors are not shut properly Check doors are shut and seals are not

damaged

Appliance is located near a heat

source, in the direct sunlight or

air flow to the condenser is being

interrupted

Move the refrigerator to a more suitable

location

Ambient temperature is too high Increase ventilation or move appliance to a

cooler position

Unsuitable foodstuffs are being

stored in the appliance

Remove any excessive hot foodstuffs or

blockages to fan

Appliance is overloaded Reduce the amount of food stored in the

appliance

Factory default parameters adjusted Call POLAR or qualified technician

The appliance is

leaking water

The appliance is not properly

levelled

Adjust the screw feet to level the appliance

(if applicable)

The appliance is

unusually loud

Loose screw/nut Check and tighten all nuts and screws

The appliance has not been installed

in a level or stable position

Check installation position and change if

necessary

The display lamp

does not illuminate

Lamp needs replacing Call POLAR or qualified technician

Light not turned on Ensure Light button has been pressed

properly

Door does not shut Dirt/obstacle in runners Clean runners

Technical Specifications

Model Voltage Power

(W)

Current

(A)

Temperature

Range

Capacity

(Litres) Refrigerant Dimensions

H x W x D mm

Weight

(kg)

CD229-A 220-240V~

50Hz

160 1.4A 0°C to 12°C 120 R600a (50g) 686 x 696 x

568

CD230-A 220-240V~

50Hz

200 1.4A 0°C to 12°C 160 R600a (65g) 686 x 874 x

568

CD229-A_CD230-A_A5_v2_20200903.indb 6CD229-A_CD230-A_A5_v2_20200903.indb 6 2020/9/3 09:402020/9/3 09:40

Telephone Helpline: 1300225960

Electrical Wiring

The plug is to be connected to a suitable mains socket.

POLAR appliances are wired as follows:

• Live wire (coloured brown) to terminal marked L

• Neutral wire (coloured blue) to terminal marked N

• Earth wire (coloured green/yellow) to terminal marked E

This appliance must be earthed.

If in doubt consult a qualified electrician.

Electrical isolation points must be kept clear of any obstructions. In the event of any emergency

disconnection being required they must be readily accessible.

Compliance

The product must not be disposed of as household waste. To help prevent possible harm to human

health and/or the environment, the product must be disposed of in an approved and environmentally safe

recycling process. For further information on how to dispose of this product correctly, contact the product

supplier, or the local authority responsible for waste disposal in your area.

POLAR parts have undergone strict product testing in order to comply with regulatory

standards and specifications set by international, independent, and federal authorities.

POLAR products have been approved to carry the following symbol:

mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.

Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to

change specifications without notice.

CD229-A_CD230-A_A5_v2_20200903.indb 7CD229-A_CD230-A_A5_v2_20200903.indb 7 2020/9/3 09:402020/9/3 09:40

DECLARATION OF CONFORMITY

•Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •

• Declaración de conformidad • Declaração de conformidade

Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp

• Tipo di apparecchiatura • Tipo de equipo • Tipo de equipamento

Model • Modèle • Modell • Modello

• Modelo • Malli

Refrigerated Display Merchandiser - 120Ltr

Refrigerated Display Merchandiser - 160Ltr

CD229 (& -E -A)

CD230 (& -E -A)

Application of Territory Legislation &

Council Directives(s)

Toepassing van Europese Richtlijn(en)

• Application de la/des directive(s) du

Conseil • Anwendbare EU-Richtlinie(n)

• Applicazione delle Direttive

• Aplicación de la(s) directiva(s) del

consejo • Aplicação de directiva(s) do

Conselho

Low Voltage Directive (LVD) - 2014/35/EU

EN 60335-1:2012 +A11:2014 +A13:2017

EN 60335-2-89:2010 +A1:2016 +A2:2017

EN 62233:2008

Electro-Magnetic Compatibility (EMC)

Directive 2014/30/EU - recast of

2004/108/EC

EN 61000-6-1: 2007

EN 61000-6-1: 2007+A1:2011

Restriction of Hazardous Substances

Directive (RoHS) 2015/863 amending Annex

II to Directive 2011/65/EU

Electrical Safety

EN 60335-1:2012 +A11:2014 +A13:2017

EN 60335-2-89:2010 +A1:2016 +A2:2017

EN 62233:2008

Electromagnetic Compatibility

EN 61000-6-1: 2007

EN 61000-6-1: 2007+A1:2011

Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers

• Nome del produttore • Nombre del fabricante • Nome do fabricante

Polar

Producer Address • Adres fabrikant •

Adresse du producteur • Anschrift des

Herstellers • Indirizzo del produttore •

Dirección del fabricante • Morada do

fabricante

Fourth Way,

Avonmouth,

Bristol,

BS11 8TB

United Kingdom

42 North Point

Business Park

New Mallow Road

Cork

Ireland

15 Bagdally Road,

Campbelltown

NSW 2560

I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation,

Directive(s) and Standard(s).

Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande

Richtlijn(en) en Standaard(en).

Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus

Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und Norm(en)

entspricht.

Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.

El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y estándar(es)

arriba mencionadas.

Eu, o abaixo-assinado, declaro que o equipamento anteriormente especificado está em conformidade com a(s) anterior(es)

Directiva(s) e Norma(s)

Date • Data • Date • Datum • Data • Fecha • Data

24th August 2020

Signature • Handtekening • Signature • Unterschrift

Firma • Firma • Assinatura

Full Name • Volledige naam • Nom et prénom •

Vollständiger Name • Nome completo

•Nombre completo • Nome por extenso

Ashley Hooper

Josie Holt

Position • Functie • Fonction • Position • Qualifica

•Posición • Função

Technical & Quality Manager

Commercial Manager/

Responsible Supplier

CD229-A_CD230-A_A5_v2_20200903.indb 8CD229-A_CD230-A_A5_v2_20200903.indb 8 2020/9/3 09:402020/9/3 09:40

CD229-A_CD230-A_A5_v2_20200903.indb 9CD229-A_CD230-A_A5_v2_20200903.indb 9 2020/9/3 09:402020/9/3 09:40

CD229-A_CD230-A_A5_v2_20200903.indb 10CD229-A_CD230-A_A5_v2_20200903.indb 10 2020/9/3 09:402020/9/3 09:40

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Polar Electro marchandiseur

Polar Electro

Polar Electro DM075-A Manuel utilisateur

Manuels marchandiseur populaires d'autres marques

FRIGOGLASS

FRIGOGLASS Flex 20 HC Manuel utilisateur

Hussmann

Hussmann ENTYCE TY3 Manuel utilisateur

EPTA

EPTA COSTAN RHINO MULTI Manuel utilisateur

Hussmann

Hussmann CRFD Mode d'emploi

CASCO

CASCO Nano Cube Manuel utilisateur

Hussmann

Hussmann WDCHI Manuel utilisateur

True

True GDIM-26 Manuel utilisateur

Structural Concepts

Structural Concepts Oasis Mobile Series Instructions d'installation

Hussmann

Hussmann Q2-SS Instructions d'utilisation d'origine

Haussmann

Haussmann RL Manuel utilisateur

Howard McCray

Howard McCray R-CDS32E-4 Manuel utilisateur

Hussmann

Hussmann microSC SHM-A Series Manuel utilisateur

Hussmann

Hussmann APT0500 Manuel utilisateur

EPTA

EPTA iarp Cool Emotions Delight Lite Manuel utilisateur

VALERA

VALERA BC 85 Manuel utilisateur

HL Display

HL Display 3eBin Manuel utilisateur

Hussmann

Hussmann Q1-SS Mode d’emploi

Hussmann

Hussmann impact Excel C2X-XLEP Mode d’emploi