Kia EV9 Manuel utilisateur

Kia EV9

Emergency

Response Guide

Introduction

IMPORTANT INFORMATION

WARNING

A WARNING indicates a situation in which harm, serious bodily injury or death could result if

the warning is ignored.

The ERG (Emergency Response Guide) provided by Kia describes emergency response

operations, warnings, and precautions related to the vehicle. This publication is intended to

provide necessary information for vehicle accident rescue operations and for the training

and further education of first and second responders.

Please note that the guide may be updated by Kia on an ongoing basis. It is not intended for

retailers, end consumers, or any other readers not mentioned in the preceding sentence.

The provided guide applies only to the Kia EV9 vehicle and includes information about the

location and description of high-voltage components and the vehicle's structure. However, it

does not cover every scenario in emergency situations.

Failure to follow the recommended procedures during emergency response may result in

death or other serious injuries. It is important to read the guide in advance as it contains

necessary information about the vehicle's features and other provided content in the event

of an accident.

Kia EV9

Emergency Response Guide

Contents

1. Identification / recognition

10. Explanation of pictograms used

2. Immobilization / stabilization / lifting

3. Disable direct hazards / safety regulations

4. Access to the occupants

5. Stored energy / liquids / gases / solids

6. In case of fire

7. In case of Submersion

8. Towing / transportation / storage

9. Important additional information

Kia EV9

Emergency Response Guide

1. IDENTIFICATION / RECOGNITION

Initial Response: Identify,

Immobilize and Disable

The following procedures should be used

whenever you are dealing with a EV9 at an

emergency scene. However, all operations

should be consistent with your

department’s standard operating

procedures, guidelines, and any applicable

laws. When an EV9 is damaged in a crash,

the high-voltage safety systems may have

been compromised and present a potential

high-voltage electrical shock hazard.

Exercise caution and wear appropriate

personal protective equipment (PPE)

safety gear, including high-voltage safety

gloves and boots. Remove all metallic

jewelry, including watches and rings.

WARNING

Identify

The EV9 is an electric vehicle. Emergency

responders should respond to emergency

scenarios involving the EV9 accordingly,

exercising extreme care and caution to

avoid contact with the high-voltage system

within the vehicle.

Identifying a Kia EV9

“EV9” Car name emblem on tailgate

• The EV9 can be easily identified by the

car name emblem attached on the tailgate

on the left side.

•The car name emblem may be missing or

hidden after a crash due to damage to the

vehicle. Always be sure to use other

identification methods in this section before

determining that the vehicle is not an

electric car.

Charging Port

The charging port is located on the rear

left side.

Note that the doors must be unlocked

to open the charge port door.

How to open the charging port

1. Press the unlock door button,

depress the brake pedal and apply the

Electric Parking Brake (EPB).

2. Turn OFF all switches, move the shift

lever to P (Park) and turn off the vehicle.

3. Open the charging door by pressing

it, or press the “charging door open

button” in the crash pad.

Kia EV9

Emergency Response Guide

1. IDENTIFICATION / RECOGNITION

The VIN can be also found under the

driver’s seat (or passenger’s seat)

Identifying a EV9

VIN Label

The vehicle certification label attached on

the top of the dashboard through the front

windshield gives the VIN (Vehicle

Identification Number) as shown in the

below picture.

Charge Status Indicator

The battery charge status indicator (4

separate lights), located inside the

charging door, is illuminated when the

vehicle is charged. The number of

lights illuminated indicates the charge

level of the battery.

Kia EV9

Emergency Response Guide

1. IDENTIFICATION / RECOGNITION

EV9 Cluster Instrument Panel

The EV9 Cluster Instrument Panel displays EV specific features such as high-voltage

battery SOC (State of Charge) as below.

1. Speedometer

2. Distance to empty

3. Power/Charge gauge

4. Battery SOC (State of Charge) gauge

5. LCD display

6. Warning and indicator lights

7. Reduction gear shift indicator

8. Odometer

9. Regenerative braking level indicator

Kia EV9

Emergency Response Guide

2. IMMOBILIZATION / STABILIZATION / LIFTING

WARNING

• When installing a block or jack, avoid

high-voltage cable, high-voltage battery.

• If high-voltage components or cables

are exposed, do not place any support

on them.

2.1 Immobilization

The next step is to immobilize the vehicle

to prevent any accidental movement that

can endanger response personnel or

civilians. When the EV9 is damaged in a

crash, the vehicle may appear to be shut

off, even when it actually is not, due to a

lack of virtual engine sounds. When the

"READY" mode light is illuminated on the

Instrument Panel, the vehicle can move

silently using the electric motor.

Responders should approach the vehicle

from the sides and stay away from the

front or rear as they are potential paths for

vehicle movement. Be sure to immobilize

the vehicle in the following manner.

2. Put the vehicle in P (Park) position by

pressing the ‘P’ button.

3. Set the Electronic Parking Brake (EPB)

2.2 Vehicle Stabilization

Use standard stabilization (lift) points,

as shown beside. Always be sure to

connect to a structural component of

the vehicle and avoid placing cribbing

under high-voltage cables, and other

areas not normally considered

acceptable.

Kia EV9

Emergency Response Guide

3. DISABLE DIRECT HAZARDS / SAFETY REGULATIONS

Disabling vehicle

The final step in the initial response

process, conducted after immobilizing the

vehicle, is to disable the vehicle, its SRS

components and the high-voltage electrical

system. To prevent current flow through

the system, use one of the following

procedures to disable the vehicle.

Case 1:

1. EV off

2. 12 V battery disconnection

3. high-voltage shut off

Case 2*:

1. Fuse removal (Fuse box)

2. 12 V battery disconnection

3. high-voltage shut off

*In case of emergency

SRS : Supplemental Restraint System

3.1 Disabling the System –Smart

Key System and “EV”

START/STOP Button

1. Confirm the status of the READY light

on the instrument panel. If the READY

light is illuminated, the vehicle is ON.

a) If the READY light is NOT illuminated,

the vehicle is off. Do not push the “EV”

START/STOP button because the vehicle

may start (go into READY mode).

b) To turn OFF the system, press the 'P'

(Park) button on the rotary shifter dial, and

press the EV button.

2. If necessary, lower the windows,

unlock the doors and open the trunk as

required, before disconnecting the 12 V

battery. Once the 12 V battery is

disconnected, power controls will not

operate.

3. Before disconnecting the 12 V

battery, remove the smart key at least 2

meters (7 feet) away from the vehicle to

prevent accidental restart.

4. Open the hood after pressing the

release button twice.

Kia EV9

Emergency Response Guide

3. DISABLE DIRECT HAZARDS / SAFETY REGULATIONS

WARNING

Wait more than 5 minutes for capacitor

of the high-voltage battery system to be

discharged completely.

* If the release button does not work, pull

the emergency lever twice after removing

the emergency open cover located on the

left hand side of the footrest.

4. Separate the 12 V auxiliary battery

negative terminal (A) after loosening the

nut.

5. Remove the PE room junction box cover.

6. Disconnect the high voltage service

interlock connector (A).

Before

After

Kia EV9

Emergency Response Guide

3. DISABLE DIRECT HAZARDS / SAFETY REGULATIONS

5. Remove the service interlock

connector and disable the high-voltage

battery.

• If previously mentioned methods of

disabling the vehicle’s system are

unsuccessful, any emergency

procedures involving the electric vehicle

may cause the accidental deployment

of undeployed airbags and electric

shock from high-voltage components.

3.2 Disabling the system –IG

(Ignition) Fuse Removal

1. Open the hood.

2. Remove the PE (Motor) room fuse box

cover.

3. If necessary, lower the windows, unlock

the doors and open the tailgate as required,

before disconnecting the 12 V battery

(located in the left side of PE(Motor) room).

Once the 12 V battery is disconnected,

power controls will not operate.

4. In the event the vehicle is unable to be

disabled using the “EV” START/STOP

Button, using the fuse puller located in the

PE(Motor) room fuse box, pull both the IG1,

IG2 fuse from the PE room fuse box. If the

IG fuses cannot be located, pull out all of

the fuses and relays in the fuse box.

Kia EV9

Emergency Response Guide

Table des matières

Autres manuels Kia Automobile

Kia

Kia Sportage 2022 Manuel utilisateur

Kia

Kia SOUL EV 2016 Manuel de la liste des pièces

Kia

Kia Forte 2010 Manuel utilisateur

Kia

Kia Sorento 2023 Manuel utilisateur

Kia

Kia SEDONA 2020 Instructions de montage

Kia

Kia K900 2017 Manuel de la liste des pièces

Kia

Kia Cerato 2009 Manuel utilisateur

Kia

Kia Sportage 2021 Instructions de montage

Kia

Kia 2019 niro Manuel utilisateur

Kia

Kia Telluride Manuel de la liste des pièces

Kia

Kia 2016 Optima Manuel de la liste des pièces

Kia

Kia 2015 Soul Manuel utilisateur

Kia

Kia Soul EV 2018 Manuel de la liste des pièces

Kia

Kia Sorento 2003 Manuel utilisateur

Kia

Kia Sorento 2021 Manuel utilisateur

Kia

Kia Picanto 2016 Manuel utilisateur

Kia

Kia PICANTO 2017 Manuel technique

Kia

Kia 2015 Cadenza Manuel de la liste des pièces

Kia

Kia 2016 Sportage Manuel utilisateur

Kia

Kia Stinger 2017 Manuel utilisateur

Kia

Kia Soul 2024 Manuel utilisateur

Kia

Kia EV6 2024 Instructions de montage

Kia

Kia Sorento Manuel de la liste des pièces

Kia

Kia Magentis Manuel utilisateur

Manuels Automobile populaires d'autres marques

Toyota

Toyota 2000 Tundra Manuel utilisateur

CITROËN

CITROËN DS4 DSign Manuel utilisateur

Lexus

Lexus 2015 CT 200h Manuel utilisateur

Cadillac

Cadillac CTS 2008 Manuel utilisateur

Mercedes-Benz

Mercedes-Benz M-class ML 55 AMG Manuel utilisateur

Porsche

Porsche Boxster S Manuel utilisateur

GMC

GMC 2010 Savana 1500 Cargo Manuel utilisateur

KIAM

KIAM SPORTAGE 2014 Manuel de la liste des pièces

GMC

GMC 2013 Terrain Instructions de montage

GMC

GMC T-Series 1999 Manuel utilisateur

Mercury

Mercury 1998 Mystique Manuel utilisateur

Mercury

Mercury 2007 Mariner Manuel utilisateur

Mazda

Mazda 2007 Mazdaspeed 3 Mode d’emploi

Mazda

Mazda 2014 CX-5 Manuel utilisateur

GMC

GMC Chevrolet Express 2022 Manuel utilisateur

GMC

GMC 1997 Jimmy Manuel utilisateur

Chevrolet

Chevrolet 2012 Malibu Manuel utilisateur

Cadillac

Cadillac 2010 Escalade Manuel utilisateur