ITRON 60W Endpoint Manuel utilisateur

60W Endpoint

Installation Guide

ii 60W Endpoint Installation Guide

PUB-0771-001 Rev. A 01/06

Identification

60W Endpoint Installation Guide

PUB-0771-001 Rev. A 01/06

Trademark Notice

Itron is a registered trademark of Itron, Inc. All other product names and logos in this document are used for identification

purposes only and may be trademarks or registered trademarks of their respective companies.

Patent Notice

US and foreign patents pending.

Your company has the right to reproduce this contract document provided that such reproduction shall be subject to the same use

and disclosure restrictions contained in the Confidentiality and Non-Disclosure paragraphs in the Sales Contract.

Compliance Statement

This equipment has been tested and found to comply with the limits, pursuant to Part 15 of the FCC Rules. These limits are

designed to provide reasonable protection against harmful interference in a residential installation. Operation is subject to the

following conditions:

• This device may not cause interference.

• This device must accept any interference that may cause undesired operation of the device.

Complies with IC: R.S.S.-210

Transportation Classification

The Federal Aviation Administration prohibits operating transmitters and receivers on all commercial aircraft. When powered,

endpoints are considered operating transmitters and receivers and cannot be shipped by air.

Product Returns

To comply with FCC, UN, and Department of Transportation regulations, all units must be returned in their original

packaging following Itron’s RMA process. Bubble-up transmission must be disabled prior to shipping. If you are unable to

disable the transmitter or provide original packaging, contact Itron Customer Care.

Repairs and Modifications

Lithium Batteries

Suggestions

If you have comments or suggestions on how we may improve this document, send them to:

• Mail: Itron, Inc.; Attention: Customer Care; 2818 N. Sullivan Road; Spokane, WA 99216

• E-mail: [email protected]

• Phone: 1-800-635-8725

WARNING! Attempts to repair this device by unauthorized personnel may subject the person to shock hazard if removal

of protective covers is attempted. Unauthorized repair may void the warranty and/or maintenance contract with your

company.

WARNING! This unit cannot be modified and is not repairable. Modification of this device could cause non-compliance

with FCC rules. Attempts to modify this device will void the warranty.

WARNING! Follow these procedures to avoid injury to yourself or others.

• The lithium battery may cause a fire or chemical burn if it is not disposed of properly.

• Do not recharge, disassemble, heat, or incinerate the lithium battery.

• Keep the lithium battery away from children.

• Replace the lithium battery only with batteries meeting Itron specifications. Any other battery may cause a fire or

explosion

Contents iii

PUB-0771-001 Rev. A 01/06

Contents

List of Procedures. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . v

Before You Begin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vii

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vii

How This Document is Organized . . . . . . . . . . . . . . . . . . . . . . . . . . . vii

Related Documents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vii

Documentation Conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vii

Chapter 1 Getting Started. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

About the 60W Endpoint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Battery Life. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Installation Options. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Included Materials. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Materials Not Included. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Installation Process Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Compatible Registers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Chapter 2 Installing the 60W Endpoint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Step 1: Mounting the 60W (Using one of the following mounting techniques,

mount the 60W in the water-pit vault) . . . . . . . . . . . . . . . . . . . . . . . 7

Rod Mount

Wall (pit vault) Mount

Pipe Mount

Through-lid Mount

Step 2: Connecting the 60W to the water register. . . . . . . . . . . . . . . . . . . 17

Step 3: Verify that the 60W is operating properly . . . . . . . . . . . . . . . . . . . 21

Appendix A: Wiring for registers that do not

have a factory attached cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

iv 60W Endpoint Installation Guide

PUB-0771-001 Rev. A 01/06

List of Procedures v

PUB-0771-001 Rev. A 01/06

List of Procedures

Attaching a Cable Tie to the Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Installing with the Rod Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Installing a Wall Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Installing on a Pipe. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Installing Through-Lid. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Connecting an Inline Connector. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

Appendix A: Wiring for Registers that Do Not Have a Factory

Installed Inline Connector. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

Attaching the Inline Connector to the Neptune ProRead and ARB V Registers. . 22

vi 60W Endpoint Installation Guide

PUB-0771-001 Rev. A 01/06

Before You Begin

vii

PUB-0771-001 Rev. A 01/06

Before You Begin

Overview The 60W is available with either a 5’ length of cable (not terminated) or with an

inline connector (attached to approx. 7’’ of cable) and will interface with several

encoded (absolute) registers. This document describes the installation of the

60W endpoint, including rod mount, wall mount, pipe mount and through-lid

installations.

How This Document

is Organized This document is organized as follows.

Documentation

Conventions This document uses the following conventions.

CAUTION This type of note warns the user that failure to heed the information in

the note could result in loss of data. Be sure to carefully read a CAUTION note

and heed the advice/instructions.

Chapter Description

Chapter 1.

Getting Started Provides an overview of the 60W endpoint instal-

lation, including installation options, siting, and

required tools.

Chapter 2.

Installing the 60WP

Endpoint

Provides step-by-step instructions for wiring the

endpoint to a register and installing the endpoint

using the rod mount, on a wall or similar surface,

or on a pipe.

Convention Example

Itron product part numbers

are noted in parentheses. To install the endpoint (ERW-0771-2XX), do

the following steps.

Hypertext links are blue. See Contents on page iii for the complete table

of contents.

The last line in a table is

defined by a thick gray

line.

Note the thick gray line below this row. If the

table continues on another page, the column

headings are repeated on each page.

WARNING! This type of note is used to warn of potential physical harm

to the user or hardware. It is critical that you pay strict attention to

WARNING notes, read the information carefully, and heed the

advice/instructions.

viii 60W Endpoint Installation Guide

PUB-0771-001 Rev. A 01/06

Chapter 1 - Getting Started 1

PUB-0771-001 Rev. A 01/06

Chapter 1

Getting Started

About the 60W Endpoint

Overview The 60W water endpoint is an AMR module that collects consumption and

tamper information and reports in a bubbleup fashion. Approximately every 8

seconds, the 60W transmits a standard consumption message (SCM) at approx-

imately +10dBm between 910-920 MHz. The 60W supports protocols for a

variety of meter manufacturer's registers, including but not limited to: AMCO,

Badger, Hersey, Neptune, and Sensus.

The 60W features the following capabilities:

•Leak Detection The 60W will continually compare hourly register

readings. The 60W will report in the SCM if a zero consumption (equal to

previous read) doesn’t occur over a period of seven years

•Tamper Indicators To minimize the possibility of theft, the 60W features

cut cable tamper reporting, as well as a security seal to indicate physical

tampering. Cut cable is reported when the cable has been cut or discon-

nected from the register or the endpoint.

•Reverse Flow Detection The 60W will compare the hourly read with the

previousread.Ifthecurrentread is less than the previous read the60Wwill

report in the SCM that this occurred.

Battery Life Powered by a non-replaceable long life dual lithium battery pack, the 60W end-

point has an expected battery life of 20 years.

Installation Options The 60W endpoint may be installed in the following ways:

•Rod Mount Rod mount installation allows the endpoint to be mounted to

a 3/8” outside diameter length of pipe, rebar, or conduit that has been

driven at least 12 inches into the ground at the bottom of the meter pit..

•Wall Mount Wall mount installation attaches the endpoint to a wall or

other surface within a meter pit..

•Pipe Mount The pipe mount (vertical pipe only) option allows the end-

point to be installed on a pipe near the meter rather than on a wall surface.

•Through Lid Used in conjunction with the through-lid mounting kit, this

option allows the endpoint to be mounted up into a hole (1 7/8”) in a pit lid.

2 60W Endpoint Installation Guide

PUB-0771-001 Rev. A 01/06

Included Materials

The following materials are supplied by Itron:

• 60W endpoint with inline connector (connector includes a protective

cover) and security seal.

• 60W endpoint with a 5’ cable (This configuration allows for connection

directly to the register terminals.).

• Connector cables in 5-foot and 25-foot lengths. Itron typically supplies

these cables to the meter manufacturer for potting to the register.

Figure 1: 60W Endpoint

Materials Not Included

• Screws, Rebar Cable Ties, Hammer, Tape Measure and Screwdriver.

• Through Lid Mounting pieces, these can be ordered in quantities of ?? and

include a Through Lid mount, Lid mount clamp and cable ties

Autres manuels pour 60W Endpoint

Table des matières

Autres manuels ITRON Unité de contrôle

ITRON

ITRON 8600 Series Manuel utilisateur

ITRON

ITRON OpenWay Riva 500W ERT Manuel utilisateur

ITRON

ITRON 100W-R Manuel utilisateur

ITRON

ITRON OpenWay Riva 500G Manuel utilisateur

ITRON

ITRON Gen 5 500W ERT Manuel utilisateur

ITRON

ITRON OpenWay Riva Manuel utilisateur

ITRON

ITRON Centron C3A2H Manuel d'utilisation et d'entretien

ITRON

ITRON 800 Series Manuel utilisateur

ITRON

ITRON OpenWay Riva Manuel utilisateur

ITRON

ITRON OpenWay Riva 500W ERT Manuel utilisateur

ITRON

ITRON 100G Manuel utilisateur

ITRON

ITRON OpenWay Riva Manuel utilisateur

ITRON

ITRON OpenWay Riva 500G ERT Manuel utilisateur

ITRON

ITRON EquaScan hMIURFV2 Manuel utilisateur

ITRON

ITRON OpenWay Riva Manuel utilisateur

ITRON

ITRON ERT 40W Manuel utilisateur

ITRON

ITRON Gen 5 500W ERT Manuel utilisateur

ITRON

ITRON ITR9002 Manuel d'utilisation et d'entretien

ITRON

ITRON EquaScan wMIURF V2 Manuel utilisateur

ITRON

ITRON OpenWay Riva Manuel utilisateur

ITRON

ITRON Cellular 500G Manuel utilisateur

ITRON

ITRON 022 Manuel utilisateur

ITRON

ITRON OpenWay Riva Manuel utilisateur

ITRON

ITRON 100T-CP Manuel utilisateur

Manuels Unité de contrôle populaires d'autres marques

Festo

Festo Compact Performance CP-FB6-E Manuel de la liste des pièces

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manuel utilisateur

JS Automation

JS Automation MPC3034A Manuel utilisateur

JAUDT

JAUDT SW GII 6406 Series Guide rapide

Spektrum

Spektrum Air Module System Manuel utilisateur

BOC Edwards

BOC Edwards Q Series Manuel utilisateur

KHADAS

KHADAS BT Magic Manuel utilisateur

Etherma

Etherma eNEXHO-IL Manuel utilisateur

PMFoundations

PMFoundations Attenuverter Manuel utilisateur

GEA

GEA VARIVENT Manuel utilisateur

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manuel utilisateur

Altronix

Altronix LINQ8PD Instructions de montage

Eaton

Eaton Powerware Series Manuel utilisateur

WAGO

WAGO 750-407/040-000 Manuel utilisateur

Sony

Sony CCU-590 Manuel utilisateur

Graco

Graco 25D614 Manuel utilisateur

Task Force Tips

Task Force Tips YE-RF-900 Manuel de programmation

Shini

Shini SPV-U Series Manuel utilisateur