Hyundai Kona Manuel utilisateur

KONA Electric

Emergency Response Guide

Contents

1. Identification / recognition 2

2. Immobilization / stabilization / lifting 6

3. Disable direct hazards / satety regulations 7

4. Access to the occupants 12

5. Stored energy / liquid / gases / solids 15

6. In case of fire 18

7. In case of submersion 22

8. Towing / Transportation / storage 23

9. Important additional information 26

1. Identification / recognition

Initial Response: Identify, Immobilize and Disable

Identify

The KONA EV is an electric vehicle. Emergency responders should respond to emergency

scenarios involving the KONA EV accordingly, exercising extreme care and caution to avoid

contact with the high voltage system within the vehicle.

The following procedures should be used whenever you are dealing with a KONA EV at an

emergency scene. However, all operations should be consistent with your department's

standard operating procedures, guidelines, and any applicable laws. When an EV is

damaged in a crash, the high voltage safety systems may have been compromised and

present a potential high voltage electrical shock hazard. Exercise caution and wear

appropriate personal protective equipment (PPE) safety gear, including high voltage safety

gloves and boots. Remove all metallic jewelry, including watches and rings.

1. Identification / recognition

1.1 Identifying a HYUNDAI KONA EV

“

electric” logo on tail gate

•

The HYUNDAI KONA EV can be easily

identified by the “Eco electric” logo attached

on the tail gate and front charge port door on

driver’s side.

•

The eco electric logo may be missing or

hidden after a crash due to damage to the

vehicle. Always be sure to utilize additional

methods of identification before determining

that the vehicle is not an electric car.

Charging Port

•

The charging port is located on the front left bumper.

#Note : The doors must be un

-locked to open the charge port door.

How to open the charging port

Unlock

charging door in emergency

XXXXXXXG or HXXXXXX

1. Identification / recognition

VIN Label

The VIN (Vehicle Identification Number) identifies

an electric car

with a “G” or “H” displayed

in the 8th position, as shown in the below picture.

The VIN can be found:

1) Underneath the front passenger seat (or driver seat).

2) On the vehicle certification label attached to the driver’s side (or passenger) center pillar.

8th position (G or H)

1.1 Identifying a HYUNDAI KONA EV

1. Identification / recognition

Motor Compartment and underside

The KONA Electric has a plastic power electric cover with “EV” clearly shown on it.

Additionally, there are orange colored high

-voltage electrical cables in the motor

compartment and underside

1.1 Identifying a HYUNDAI KONA EV

2. Immobilization / stabilization / lifting

The next step is to immobilize the vehicle to prevent any accidental movement that can

endanger responding emergency personnel or civilians. When the KONA EV is damaged in a

crash, the vehicle may appear to be shut off when it is not because the engine emits little to no

sound.

When the "READY" mode light is illuminated on the Instrument Panel, the vehicle can move

silently using the electric motor. Responders should approach the vehicle from the sides and

stay away from the front or rear as they are potential paths for vehicle movement. Be sure to

immobilize the vehicle in the following manner.

2.2 Vehicle Stabilization

Use standard stabilization(lift) points, as

shown right. Always be sure to connect to a

structural member of the vehicle and avoid

placing cribbing under high voltage cables,

and other areas not normally considered

acceptable.

Chock the Wheels

Engage Parking Brake

Step on brake pedal to park

the vehicle, then press the

park (P) Button

2.1 Immobilization

3. Disable direct hazards / safety regulations

The final step in the initial response process, conducted after immobilizing the vehicle, is to

disable the vehicle, its SRS components and the high voltage electrical system. To prevent

current flow through the system, use one of the following procedures to disable the vehicle.

3.1 Disabling the System –Smart Key System and “POWER”

START/STOP Button

Confirm the status of the READY light on the instrument panel. If the READY

light is illuminated, the vehicle is ON.

“POWER” START/STOP Button

a) If the READY light is NOT illuminated, the vehicle is off. Do not push the

“POWER” START/STOP button because the vehicle may start (go

into READY

mode)

b) To turn OFF the system, press the 'P' (Park) button, and press the POWER button.

Case I

Case II*

Fuse removal

(Fuse box)

12 Volt battery

disconnection

High voltage

shut off

*In case of the vehicle cannot be disabled using the “power” button.

Power Off 12 Volt battery

disconnection

High voltage

shut off

“P” parking position button

3. Disable direct hazards / safety regulations

2. If necessary, lower the windows, unlock the doors and open the tail gate as required,

before disconnecting the 12 Volt battery. Once the 12 Volt battery is

disconnected,

power

controls will not operate. (Refer to below “5. –a” for 12 Volt battery disconnection

3. Before disconnecting the 12 Volt battery, remove the Smart Key at least 2 meters

away from the vehicle to prevent accidental restart.

4. In case of emergency, disconnect or cut the service interlock connector cable to

isolate the high voltage of the battery.

Without depressing

the brake pedal

Pressing

POWER button

Button

Position/LED Vehicle condition

One time ACC/ON Electrical accessories are operational.

Two times ON/ON The warning lights can be checked before the

vehicle is started.

Three times OFF Off

Pressing

POWER button

Button

Position/LED Vehicle condition

One time START/OFF Ready to drive

While depressing the brake pedal

Service Interlock Connector

3. Disable direct hazards / safety regulations

5. Follow the procedure below to remove the safety plug and disable the high voltage battery:

c) Remove the service plug

cover (A)

after removing rear seat cushion assembly.

a) Disconnect the 12 Volt auxiliary battery

negative (-) terminal.

d) Remove the service plug

(A).

b) Remove the rear seat shown

in the figure(illustration) below

to locate the service plug.

Autres manuels pour Kona

Table des matières

Autres manuels Hyundai Automobile

Hyundai

Hyundai Elantra 2011 Manuel utilisateur

Hyundai

Hyundai 2004 Santa Fe Manuel utilisateur

Hyundai

Hyundai SONATA hybrid Manuel utilisateur

Hyundai

Hyundai NEXO 2019 Manuel utilisateur

Hyundai

Hyundai Santa Cruz Manuel utilisateur

Hyundai

Hyundai 2005 Santa Fe Manuel utilisateur

Hyundai

Hyundai Sonata HEV Hybrid Manuel utilisateur

Hyundai

Hyundai Getz 2004 Manuel utilisateur

Hyundai

Hyundai 2005 Tiburon Manuel utilisateur

Hyundai

Hyundai 2010 ELANTRA TOURING Manuel utilisateur

Hyundai

Hyundai XG300 2001 Manuel utilisateur

Hyundai

Hyundai IX35 Manuel utilisateur

Hyundai

Hyundai Starex H-1 2004 Manuel utilisateur

Hyundai

Hyundai Genesis Coupe 2011 Manuel utilisateur

Hyundai

Hyundai KONA Electric 2023 Manuel utilisateur

Hyundai

Hyundai Tucson 2005 Manuel utilisateur

Hyundai

Hyundai GENESIS 2013 Manuel utilisateur

Hyundai

Hyundai BC3 Manuel utilisateur

Hyundai

Hyundai 2008 Veracruz Manuel utilisateur

Hyundai

Hyundai TUCSON 2020 Manuel utilisateur

Hyundai

Hyundai trajet Guide d'installation

Hyundai

Hyundai 2013 Azera Manuel utilisateur

Hyundai

Hyundai Kona Electric 2018 Manuel utilisateur

Hyundai

Hyundai Palisade 2020 Manuel utilisateur

Manuels Automobile populaires d'autres marques

Toyota

Toyota 2000 Tundra Manuel utilisateur

CITROËN

CITROËN DS4 DSign Manuel utilisateur

Lexus

Lexus 2015 CT 200h Manuel utilisateur

Cadillac

Cadillac CTS 2008 Manuel utilisateur

Mercedes-Benz

Mercedes-Benz M-class ML 55 AMG Manuel utilisateur

Porsche

Porsche Boxster S Manuel utilisateur

GMC

GMC 2010 Savana 1500 Cargo Manuel utilisateur

KIAM

KIAM SPORTAGE 2014 Manuel de la liste des pièces

GMC

GMC 2013 Terrain Instructions de montage

GMC

GMC T-Series 1999 Manuel utilisateur

Mercury

Mercury 1998 Mystique Manuel utilisateur

Mercury

Mercury 2007 Mariner Manuel utilisateur

Mazda

Mazda 2007 Mazdaspeed 3 Mode d’emploi

Mazda

Mazda 2014 CX-5 Manuel utilisateur

GMC

GMC Chevrolet Express 2022 Manuel utilisateur

GMC

GMC 1997 Jimmy Manuel utilisateur

Chevrolet

Chevrolet 2012 Malibu Manuel utilisateur

Cadillac

Cadillac 2010 Escalade Manuel utilisateur