Hussmann MicroSC VRL1B Manuel utilisateur

VRL

Low Temperature Self Contained

Glass Door Merchandisers

with R-290 Refrigerant

Installation &

Operation Manual

Spanish 3034045

MANUAL - SELF CONTAINED R290 VRL I/O

WARNINGS:

If the information in these instructions are not followed

exactly, a ﬁre or explosion may result, causing property

damage, personal injury or death.

Installation and service must be performed by a qualiﬁed

installer or service agency.

READ THE ENTIRE MANUAL BEFORE

INSTALLING OR USING THIS EQUIPMENT.

The unit uses R-290 gas as the refrigerant. R-290 is

ﬂammable and heavier than air. It collects ﬁrst in low

areas but can be circulated by the fans. If propane gas

is present or even suspected, do not allow untrained

personnel to attempt to ﬁnd the cause. The propane

gas used in the unit has no odor. The lack of smell does

not indicate a lack of escaped gas. If a leak is detected,

immediately evacuate all persons from the store, and

contact the local ﬁre department to advise them that

a propane leak has occurred. Do not let any persons

back into the store until the qualiﬁed service technician

has arrived and that technician advises that it is safe to

return to the store. No open ﬂames, cigarettes or other

possible sources of ignition should be used inside or in

the vicinity of the units.

FAILURETOABIDE BYTHIS WARNING COULD

RESULT IN AN EXPLOSION, DEATH, INJURYAND

PROPERTY DAMAGE.

IMPORTANT

Keep in store for future reference!

P/N 3034040_H

June 2021

2InstallatIon

P/N 3034040_H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com

BEFORE YOU BEGIN

Read these instructions completely and carefully.

PERSONAL PROTECTION EQUIPMENT (PPE)

Personal Protection Equipment (PPE) is required whenever installing or servicing this

equipment. Always wear safety glasses, gloves, protective boots or shoes, long pants, and a

long-sleeve shirt.

1. If the information in these instructions are not followed exactly, a ﬁre or explosion may result, causing property damage, person-

al injury or death.

2. Installation and service must be performed by a qualiﬁed installer or service agency.

3. This unit is designed only for use with R-290 gas as the designated refrigerant.

THE REFRIGERANT LOOP IS SEALED. ONLY A QUALIFIED TECHNICIAN SHOULD ATTEMPT TO SERVICE!

• Propane is ﬂammable and heavier than air.

• It collects ﬁrst in the low areas but can be circulated by the fans.

• If R-290 (propane) is present or even suspected, do not allow untrained personnel to attempt to ﬁnd the cause.

• The propane gas used in the unit has no odor.

• The lack of smell does not indicate a lack of escaped gas.

• If a leak is detected, immediately evacuate all persons from the store, and contact the local ﬁre department to advise them that a

pro pane leak has occurred.

• Do not let any persons back into the store until the qualiﬁed service technician has arrived and that technician advises that it is

safe to return to the store.

• A hand-held propane leak detector (“sniffer”) shall be used before any repair and/or maintenance.

• No open ﬂames, cigarettes or other possible sources of ignition should be used inside the building where the units are located

until the qualiﬁed service technician and/or local ﬁre department determines that all propane has been cleared from the area and

from the refrigeration systems.

• Component parts are designed for propane and non-incendive and non-sparking. Component parts shall only be replaced with

identical repair parts.

FAILURE TO ABIDE BY THIS WARNING COULD RESULT INAN EXPLOSION, DEATH, INJURY AND PROPERTY DAMAGE.

U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com

P/N 3034040_H 3

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. VRL Merchandisers

IMPORTANT

KEEP IN STORE FOR FUTURE REFERENCE

Quality that sets industry standards!

12999 St. Charles Rock Road • Bridgeton, MO 63044-2483

U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900

www.hussmann.com

Merchandiser must operate for 24 hours

before loading product!

Regularly check merchandiser temperatures.

Do not break the cold chain. Keep products

in freezer before loading into merchandiser.

These merchandisers are designed

for only pre-frozen products.

AT TENTION

Merchandiser must operate for 24 hours

before loading product!

Regularly check merchandiser temperatures.

Do not break the cold chain. Keep products in

freezer before loading into merchandiser.

These merchandisers are designed

for only pre-frozen products.

4InstallatIon

P/N 3034040_H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com

REVISION HISTORY

REVISION H

Updated the wiring diagrams.

REVISION G

Updated type & clearance, Page 5; Casters, Page 9; Checklist, Page 12; Physical & Electrical Data,

Page 42; Updated condensing unit drawings and wiring diagrams

REVISION F

Added new product warnings, Page 7

REVISION E

Added recovering refrigerant steps

REVISION D

Removed Fan Key Page; Updated parts list and diagrams; added California Warning.

REVISION C

Changed Added VRL 1-door cases

Changed info about door torque.

REVISION B

Changed NEMA Plug - Page 13

ORIGINAL ISSUE — JULY 2017

* * * * * * * * * * * * * * * * * * * * * * * * * *

ANSI Z535.5 DEFINITIONS

• DANGER – Indicate[s] a hazardous

situation which, if not avoided, will

result in death or serious injury.

• WARNING –Indicate[s] a hazardous

situation which, if not avoided, could

result in death or serious injury.

• CAUTION –Indicate[s] a hazardous

situation which, if not avoided, could

result in minor or moderate injury.

• NOTICE – Not related to personal injury –

Indicates[s] situations, which if not avoided,

could result in damage to equipment.

Do NOT remove shipping crate until the

merchandiser is positioned

for installation.

Excessive ambient conditions may

cause condensation and therefore

sweating of doors. Facility operators

should monitor doors and oor

conditions to ensure safety of persons.

Adjust closing torque by turning the bottom

hinge pin in the direction the door closes.

Use a 1/2 inch (13 mm) wrench, and turn

the hinge pin until the door closes on its own.

Usually it takes two clicks or a half turn.

AT TENTION

This warning does not mean that Hussmann products

will cause cancer or reproductive harm, or is in

violation of any product-safety standards or

requirements. As clarified by the California State

government, Proposition 65 can be considered more of

a‘right to know’ law than a pure product safetylaw.

When used as designed, Hussmann believes that our

products are notharmful. We provide the Proposition

65 warning to stay in compliance with California State

law. It is your responsibility to provide accurate

Proposition 65 warning labels to your customers when

necessary. For more information on Proposition 65,

please visit the California State government website.

August 31, 2018

Case ventilation openings must be clear

of any obstructions. Do not damage the

refrigerant circuit.

P/N 3034040_H 5

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. VRL Merchandisers

NSF LISTING

These merchandisers are manufactured to meet

ANSI / UL 471 standard requirements for

safety. Proper installation is required to maintain

this listing. Near the serial plate, each case

carries a label identifying the type of conditions

for which the merchandiser was tested.

ANSI/NSF-7 Type II – Display

Refrigerator / Freezer Intended for

80°F / 55% RH Ambient Application

ANSI/NSF-7 – Display Refrigerator

Intended for Bulk Produce

FEDERAL / STATE REGULATION

These merchandisers, at the time they are

manufactured, meet all federal and state /

provincial regulations.

HUSSMANN PRODUCT CONTROL

The serial number and shipping date of all

equipment is recorded in Hussmann’s files

for warranty and replacement part purposes.

All correspondence pertaining to warranty or

parts ordering must include the serial number

of each piece of equipment involved. This is

to ensure the customer is provided with the

correct parts.

SHIPPING DAMAGE

All equipment should be thoroughly examined

for shipping damage before and during

unloading. This equipment has been carefully

inspected at our factory. Any claim for loss

or damage must be made to the carrier. The

carrier will provide any necessary inspection

reports and/or claim forms.

Apparent Loss or Damage

If there is an obvious loss or damage, it must

be noted on the freight bill or express receipt

and signed by the carrier’s agent; otherwise,

carrier may refuse claim.

Concealed Loss or Damage

When loss or damage is not apparent until

after equipment is uncrated, retain all packing

materials and submit a written response to the

carrier for inspection within 15 days.

LOCATION

These merchandisers are designed for

displaying products in air conditioned stores

where temperature is maintained at or below

the ANSI / NSF-7 specified level and relative

humidity is maintained at or below 55%.

Placing refrigerated merchandisers in direct

sunlight, near hot tables or near other heat

sources could impair their efficiency. Like

other merchandisers, these merchandisers

are sensitive to air disturbances. Air currents

passing around merchandisers will seriously

impair their operation. Do NOT allow air

conditioning, electric fans, open doors or

windows, etc. to create air currents around

the merchandiser. VRL units take in air and

exhaust air through the front of the case. A

1-inch clearance space on top, at back or either

side of the case.

Recommended operating ambient

temperature is between

60°F (15.6°C) to 80°F (26.7°C).

Maximum relative humidity is 55%.

INSTALLATION

6InstallatIon

P/N 3034040_H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com

SELF CONTAINED (LOCATION)

Product should always be maintained at

proper temperature. This means that from the

time the product is received, through storage,

preparation and display, the temperature of

the product must be controlled to maximize

the life of the product.

Besure to position self contained

merchandisers properly.

VRL models have vented base panels to allow

air circulation through the condensing unit.

Allow for a minimum 36 in. clearance in the

front. Blocking or restricting air flow will

adversely affect performance and may damage

the refrigeration system.

36 in.

Air

Exhaust

Air

Exhaust

Front Rear

Zero Clearance

at Sides and Rear

36 in. Clearance

at Front

(Plan View)

Front Rear

Zero Clearance

at Sides and Rear

36 in. Clearance

at Front

(Plan View)

Front Rear

Zero Clearance

at Sides and Rear

36 in. Clearance

at Front

(Plan View)

Air Exhaust

Air Intake

FUk YUOUI

VRL2BVRL2B

36 in.

Air Intake

Front Rear

(Plan View)

Air Exhaust

1-in. Clearance at

Sides and Rear

36 in. Clearance at

Front

36 in. 36 in.

36 in.

Air

Exhaust

Air

Exhaust

Front Rear

Zero Clearance

at Sides and Rear

36 in. Clearance

at Front

(Plan View)

Front Rear

Zero Clearance

at Sides and Rear

36 in. Clearance

at Front

(Plan View)

Front Rear

Zero Clearance

at Sides and Rear

36 in. Clearance

at Front

(Plan View)

Air Exhaust

Air Intake

FUk YUOUI

VRL3BVRL3B

Air Exhaust

36 in.

Air Intake

Front Rear

(Plan View)

Air Exhaust

1-in. Clearance at

Sides and Rear

36 in. Clearance at

Front

36 in.

Air

Exhaust

Air

Exhaust

Front Rear

Zero Clearance

at Sides and Rear

36 in. Clearance

at Front

(Plan View)

Front Rear

Zero Clearance

at Sides and Rear

36 in. Clearance

at Front

(Plan View)

Front Rear

Zero Clearance

at Sides and Rear

36 in. Clearance

at Front

(Plan View)

Air Exhaust

Air Intake

FUk YUOUI

VRL1BVRL1B

36 in.

Air Intake

Front Rear

(Plan View)

Air Exhaust

1 in. Clearance at

Sides and Rear

36 in. Clearance at

Front

P/N 3034040_H 7

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. VRL Merchandisers

UNLOADING

Unloading from Trailer:

Lever Bar (also known as a Mule, Johnson

Bar, J-Bar, Lever Dolly, or Pry Lever)

Move the merchandiser as close as possible

to its permanent location and remove

all packaging. Check for damage before

discarding packaging. Remove all separately

packed accessories such as kits and shelves.

Improper handling may cause damage to

the merchandiser when unloading. To avoid

damage:

1. Do not drag the merchandiser out of the

trailer. Use a Johnson bar (Mule).

2. Use a forklift or dolly to remove the

merchandiser from the trailer.

EXTERIOR LOADING

Do NOT walk on top of the merchandiser or

damage to the merchandisers and serious

personal injury could occur.

merchandisers are not structurally

designed to support excessive external

loading such as the weight of a person.

Do not place heavy objects on the

merchandiser.

SHIPPING SKID

Each merchandiser is shipped on a skid to

protect the merchandiser’s base and to make

positioning the case easier.

Remove the top of the crate and detach walls

from each other (if applicable). Lift crate from

the skid. Unscrew the case from the skid. The

merchandiser can now be lifted off the crate

skid. Lift only at base of skid! Remove any

braces and/or skids attached (blanket wrapped

merchandiser may have skids).

DO NOT TILT MERCHANDISER ON ITS

SIDE OR END WHEN REMOVING SKID.

Once the skid is removed, the merchandiser

must be lifted —NOT PUSHED— to

reposition. To remove the skid, remove screws

attaching skid to the merchandiser.

Check floor where merchandisers are to be set

to if it is a level area. Determine the highest

part of the floor.

Do NOT stand or walk on top of

merchandiser. Do not store items or

ammable materials atop the unit.

Case ventilation openings must be clear of any

obstructions. Do not damage the refrigerant

circuit.

Do not use mechanical devices or other means

to accelerate the defrosting process.

Do not use electrical appliances inside the food

storage compartments of the case.

8InstallatIon

P/N 3034040_H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com

MODEL DESCRIPTION

VRL merchandisers are low temperature self-

contained cabinets, designed for pre-packaged

frozen food or products that require frozen

temperatures for conservation.

Design Features:

- Contemporary styling places maximum

attention on merchandising

- All VRL merchandisers have the same access

panel design for commonality between

merchandisers

- Self-closing Innovator doors. Positive seal,

torsion type closure system

- Triple-pane thermal insulated glass door

assemblies

- Magnetic door gaskets of one-piece

construction, removable without tools for

ease of cleaning

- Merchandiser can be placed against wall -

no air gap is required behind the case

- Digital display in center of case air grille

CABINET LEVELING

This merchandiser must be installed level

(from back to front, and side to side) to allow

maximum draining of the condensate water as

well as proper door alignment and operation.

Choose a level area to install case.

VRL2B and VRL3B also have an adjustable

leg leveler at center front and back. Turn the

leg levelers clockwise to add length to each leg

for leveling.

Adjustable

Leg Levelers

Adjustable

Leg Levelers

P/N 3034040_H 9

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. VRL Merchandisers

CASTERS

When optional casters are used, screw them

tight to the merchandiser base. Once in final

position, lock each caster. This option is a

ship loose kit. As a standard offering, this

merchandiser is fabricated with hockey puck

style leveler.

FIELD REQUIRED TOOLS

Pry (J) bar to lift up case to remove leg levelers.

Make sure the adjustable wrench used has a

minimum opening of 2 5/16".

83.19"

10 InstallatIon

P/N 3034040_H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com

SHELF INSTALLATION

After the cabinet is leveled, the shelves may

be installed. Wire shelves are adjustable.

Shelf spacing can be adjusted by positioning

the shelf clips according to individual loading

requirements.

VRL merchandisers have four movable wire

shelves and one bottom wire shelf, per door

as a standard option. Extra shelves can be

ordered as optional kits.

LAMPS

This merchandiser has a light switch inside of

the left door frame. The switch controls the

display lighting and interior lighting.

Shelves

Bottom Shelf

Light Switch

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Hussmann marchandiseur

Hussmann

Hussmann DM Manuel utilisateur

Hussmann

Hussmann IMPACT M1CIMP-4B Guide de l'utilisateur

Hussmann

Hussmann Specialty Products CR3-H Mode d’emploi

Hussmann

Hussmann VSG Mode d'emploi

Hussmann

Hussmann IMPACT LNGH Mode d’emploi

Hussmann

Hussmann IMPACT D6 Manuel utilisateur

Hussmann

Hussmann Impact Excel P1X-E Mode d’emploi

Hussmann

Hussmann IMPACT Excel C2NX-LE Mode d’emploi

Hussmann

Hussmann EXCEL PW Supplément

Hussmann

Hussmann Elite Series Manuel utilisateur

Hussmann

Hussmann RGSSFP Mode d'emploi

Hussmann

Hussmann D6LEP Manuel utilisateur

Hussmann

Hussmann ISLA IM-H Series Manuel utilisateur

Hussmann

Hussmann RDM Manuel utilisateur

Hussmann

Hussmann M4G-EP Manuel utilisateur

Hussmann

Hussmann XR75CX Manuel utilisateur

Hussmann

Hussmann Specialty Products CR3M-F Mode d’emploi

Hussmann

Hussmann FWG Mode d’emploi

Hussmann

Hussmann MAXI- Manuel utilisateur

Hussmann

Hussmann IMPACT D5RRIS Mode d’emploi

Hussmann

Hussmann C6-EP Manuel utilisateur

Hussmann

Hussmann DM Manuel utilisateur

Hussmann

Hussmann MBC Guide rapide

Hussmann

Hussmann SMB Manuel utilisateur

Manuels marchandiseur populaires d'autres marques

FRIGOGLASS

FRIGOGLASS Flex 20 HC Manuel utilisateur

EPTA

EPTA COSTAN RHINO MULTI Manuel utilisateur

CASCO

CASCO Nano Cube Manuel utilisateur

True

True GDIM-26 Manuel utilisateur

Structural Concepts

Structural Concepts Oasis Mobile Series Instructions d'installation

Haussmann

Haussmann RL Manuel utilisateur

Howard McCray

Howard McCray R-CDS32E-4 Manuel utilisateur

EPTA

EPTA iarp Cool Emotions Delight Lite Manuel utilisateur

VALERA

VALERA BC 85 Manuel utilisateur

HL Display

HL Display 3eBin Manuel utilisateur

Dixie Narco

Dixie Narco DNCB 501E Manuel utilisateur

APW Wyott

APW Wyott Racer DMXD-30H Manuel utilisateur

Hoshizaki

Hoshizaki KD-90C Manuel utilisateur

Summit

Summit SCR1006 Manuel utilisateur

Delfield

Delfield Shelleyspeed SPM-28E Manuel utilisateur

EPTA

EPTA iarp Cool Emotions GLEE 40 Manuel utilisateur

Kysor/Warren

Kysor/Warren GranBering KW Mode d’emploi

Crane

Crane BevMAX Refresh 6 Media Manuel utilisateur

Hussmann microSC VRL1B Manuel utilisateur

Manuels marchandiseur populaires d'autres marques