Generac Power Systems Mobile Power MMG25FHI Manuel utilisateur
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems
Phone: 800-926-9768 . Fax: 920-361-2214
www.m-p-llc.com Page 1 of 5
3/12
Mobile Generator – MMG25FHI Specifications
ENGINE
Isuzu®4LE1NYGV-03 - naturally aspirated, diesel engine
oPrime - 32 hp @ 1800 rpm
oStandby - 35 hp @ 1800 rpm
o4 cylinder
o2.2 L displacement
oTier IV Interim approved
Steel, single wall fuel tank
o106 gal. capacity
o45.4 hr. run time – full load
oFuel tank built into skid of generator set
Fuel consumption at prime:
o100% - 1.8 gph (6.8 Lph)
o75% - 1.4 gph (5.3 Lph)
o50% - 0.9 gph (3.4 Lph)
Cooling system capable of operating at 120°F ambient
Low coolant shutdown
Radiator and oil drains plumbed to exterior
Rubber vibration dampers isolate engine/generator from frame
Disposable air filter - paper element
Air filter restriction indicator mounted on control panel
60 Hz engine/generator
Droop governed
GENERATOR
Marathon Electric®
oBrushless
o4 pole
oClass H insulation
Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator
SYSTEM OUTPUT
3 position selector switch
oSingle phase – 120 / 240V Zig Zag
oThree phase – 120 / 208V Low Wye
oThree phase – 277 / 480V High Wye
16 kW / 16 kVA – standby, single phase
15 kW / 15 kVA – prime, single phase
20 kW / 25 kVA – standby, three phase
18 kW / 23 kVA – prime, three phase
35
www m-p-llc com
MMG25FHI Generac Specifications Continued:
Manufactured by Magnum Power Products LLC, a wholly owned subsidiary of Generac Power Systems Inc
Phone: 800-926-9768. Fax: 920-361-2214
www.m-p-llc.com Page 2 of 5
3/12
SYSTEM CONTROLS
Microprocessor-based controller
oBacklit, 128x64 pixel resolution display
o-40°F to 185°F operating temperature range
oThermostatically controlled LCD heater
oSix LED indicators w/ lamp test
Alarm / Fault (Red)
Ready / Manual (Red)
Running (Green)
Warning (Yellow)
Ready / Auto (Green)
Supplying Load (Green)
Push buttons for easy operation
oManual or Auto Start
oEngine Start or Stop
oAlarm Cancel & Fault Reset
oScrolling Arrows for Diagnostic Information
System kW output display
Line output & frequency display
Engine diagnostic display
Oil pressure
Engine temperature
Fuel level
Battery
System hours
Running hours
kW hours
Time to service
oAlarm list – warnings / shutdowns are date & time stamped
Fuel level: warning – 15%; shutdown – 5%
Overspeed protection: shutdown – 115%
Oil pressure: warning – 25 psi; shutdown – 20 psi
Coolant temperature: warning – 220°F; shutdown – 230°F
Battery voltage: over – 15VDC; under – 11VDC
Generator over voltage: warning – 110%; shutdown – 111%
Generator under voltage: warning – 87%; shutdown – 86%
Generator over frequency: warning – 105%; shutdown – 110%
Generator under frequency: warning – 95%; shutdown – 90%
Over current shutdown
ELECTRICAL CONTROLS
Remote start / stop contacts located next to lug box
Lockable control box door with diagnostics window
Lockable lug box with safety switch
oTrips main breaker when lug door is opened
oDisables voltage regulator
MMG25FHI Generac Specifications Continued:
Manufactured by Magnum Power Products LLC, a wholly owned subsidiary of Generac Power Systems Inc
Phone: 800-926-9768. Fax: 920-361-2214
www.m-p-llc.com Page 3 of 5
3/12
Cable entry guides to the lug box
oRestricts access of foreign objects
Output ground connection lug inside lug box
90A main breaker with shunt trip
Convenience receptacles with individual breakers (restricted use in high wye mode)
o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)
o(2) 125 / 250V 50 Amp, 3 pole, 4 wire twistlock (Non-Nema 6369)
Panel mounted rheostat for voltage adjustment - +/- 10%
720 CCA wet cell battery
ENCLOSURE
Generac Mobile Power decals
“Flip-Hood” Patented design - aluminum, sound attenuated enclosure
oEasy access for daily maintenance
oCentralized location for all electrical connections/wiring
oUV & fade resistant, high temperature cured, white polyester powder paint
oInsulated and baffled
o68 dB(A) at 23 feet – prime power
Fully lockable enclosure including doors and fuel fill
Stainless steel hinges on doors
Emergency stop switch located on outside of enclosure
Central lifting point
Multi-lingual operating/safety decals
Document holder with operating manual including AC/DC wiring diagrams
TRAILER
“Flip-Tongue” design
DOT approved tail, side, brake, and directional lights
oRecessed rear lights
Transportation tie downs
Safety chains with spring loaded safety hooks
2” ball hitch
3500 lb. axle
3000 lb. tongue jack with footplate
P205/75R15 tubeless tires – 6 ply
WEIGHTS & DIMENSIONS
Skid mounted
Dry weight: 2048 lbs (1038 kg)
Operating weight: 2517 lbs (1222 kg)
95 x 35 x 52 in
(2.41 x 0.89 x 1.32 m)
MMG25FHI Generac Specifications Continued:
Manufactured by Magnum Power Products LLC, a wholly owned subsidiary of Generac Power Systems Inc
Phone: 800-926-9768. Fax: 920-361-2214
www.m-p-llc.com Page 4 of 5
3/12
Trailer mounted
Dry weight: 2289 lbs
(1147 kg)
Operating weight: 2758 lbs (1331 kg)
150 x 57 x 67 in
(3.81 x 1.45 x 1.70 m)
WARRANTY
Engine and generator covered under OEM warranty – consult factory for details.
CERTIFICATIONS
CSA certified
MMG25FHI Options
ENGINE OPTIONS
In-line engine block heater (Kim Hotstart)
Fuel transfer pump
ELECTRICAL CONTROLS OPTIONS
720 CCA gel cell battery
Battery disconnect
Battery charger – 2A trickle
GENERATOR OPTIONS
PMG Generator - critical grade power quality
Super Start Generator - motor starting applications
VOLTAGE OUTPUT OPTIONS
4 position phase switch
Single phase – 120 / 240V Zig Zag
Three phase – 120 / 208V Low Wye
Three phase – 277 / 480V High Wye
Three phase – 120 / 240V Delta
Dedicated voltage configurations
Buck Transformer kit – Provides 120V at GFCI outlets when in 277/480V
Cam locks
SYSTEM CONTROLS OPTIONS
Analog gauges
Auxiliary strobe/audible indication for soft & hard alarm conditions
MMG25FHI Generac Specifications Continued:
Manufactured by Magnum Power Products LLC, a wholly owned subsidiary of Generac Power Systems Inc
Phone: 800-926-9768. Fax: 920-361-2214
www.m-p-llc.com Page 5 of 5
3/12
COOLANT OPTIONS
60/40 Coolant - cold weather applications
ENCLOSURE OPTIONS
Fire extinguisher
Interior cabinet light
Control panel light
FUEL TANK OPTIONS
36 hr. double wall fuel tank
120% Containment
TRAILER OPTIONS
Single axle trailer w/ surge brakes
Single axle trailer w/ electric brakes
Tandem axle trailer w/ surge brakes
Tandem axle trailer w/ electric brakes
6 pin or 7 spade electrical connectors
Spare tire/wheel kit
HITCH OPTIONS
3” lunette ring
2 5/16” ball
Adjustable height options:
2” ball
2 5/16” ball
Table des matières
Autres manuels Generac Power Systems Générateur portable
Generac Power Systems
Generac Power Systems NP-30G Series Mode d'emploi
Generac Power Systems
Generac Power Systems GP Series Manuel utilisateur
Generac Power Systems
Generac Power Systems GP Series Manuel utilisateur
Generac Power Systems
Generac Power Systems SG400 Manuel utilisateur
Generac Power Systems
Generac Power Systems 009600-4 Manuel utilisateur
Generac Power Systems
Generac Power Systems GP Series Manuel utilisateur
Generac Power Systems
Generac Power Systems MDG25IF4 Manuel utilisateur
Generac Power Systems
Generac Power Systems 005411-0 Manuel utilisateur
Generac Power Systems
Generac Power Systems GP6500 Manuel utilisateur
Generac Power Systems
Generac Power Systems Mobile Power MMG175 Manuel utilisateur
Generac Power Systems
Generac Power Systems 04389-0 Instructions d'installation
Generac Power Systems
Generac Power Systems WheelHouse 5500 Manuel utilisateur
Generac Power Systems
Generac Power Systems Protector Series Manuel utilisateur
Generac Power Systems
Generac Power Systems GP Series Manuel utilisateur
Generac Power Systems
Generac Power Systems GP15000E Manuel utilisateur
Generac Power Systems
Generac Power Systems 0595-0 Manuel utilisateur
Generac Power Systems
Generac Power Systems G0062540 Feuille d'instructions
Generac Power Systems
Generac Power Systems XG Series Manuel utilisateur
Generac Power Systems
Generac Power Systems 006001-0 Manuel utilisateur
Generac Power Systems
Generac Power Systems 005975-0 Manuel utilisateur
