Dell 5100cn Instructions d'installation et d'entretien
DELL®5100CN
TONER CARTRIDGE REMANUFACTURING INSTRUCTIONS
DELL 5100CN TONER CARTRIDGE
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact [email protected]
www.uninetimaging.com
DELL 5100CN TONER CARTRIDGE REMANUFACTURING INSTRUCTIONS
REMANUFACTURING THE
DELL 5100CN TONER CARTRIDGE
By Javier Gonzalez and the Technical Staff at UniNet
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact [email protected]
www.uninetimaging.com
DELL 5100CN TONER CARTRIDGE 1. Remove the gearless end cap (shown) to access the toner
fill cap. Using a small flat head screwdriver, carefully pry out
one side of the end cap to unlock it from the first set of tabs.
2. Rotate the cartridge and disengage the third tab in the
same manner.
3. Disengage the fourth tab as shown.
4. Carefully slide out the gearless end cap.
Note the original positioning for reassembly.
5. Carefully insert a small flat head screwdriver between the
base of the toner fill plug and its housing as shown.
6. Carefully lift the toner fill plug out as shown.
Be careful not to damage the plastic housing.
7. Toner fill plug removed.
Note the original positioning of the plug for reassembly.
DELL 5100CN TONER CARTRIDGE REMANUFACTURING INSTRUCTIONS
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact [email protected]
www.uninetimaging.com
8. Locate and grab hold of the gear side end cap (circled).
Remove the outer tube by sliding it out as shown.
9. Cartridge separated.
Note the original positioning of the outer tube.
Clean thoroughly using compressed air.
ALTERNATE CLEARSEAL™ASSEMBLY
10. First, using a pair of pliers, gently peel off the worn sealant
from the toner cartridge as shown.
11. Wipe the seal opening and surroundings clean using
isopropyl alcohol and a lint free cloth.
DELL 5100CN TONER CARTRIDGE REMANUFACTURING INSTRUCTIONS
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact [email protected]
www.uninetimaging.com
12. Make sure that the new seal is being placed in its proper
position (shown) before applying.
NOTE: Optional UniNet Clearseal™universal adhesive for use
in Dell 5100cn OEM C/M/Y/K toner cartridges (part #10353).
13. Remove the adhesive backing of the seal and carefully
place over the opening as shown. Apply pressure using your
fingers to ensure a tight seal.
14. Gently wrap the seal flap around the toner fill opening as
shown before inserting the cartridge. This will ensure that the
seal flap properly exits the opposite end of the tube.
15. Slide the cartridge into the tube until it is completely
inserted.
DELL 5100CN TONER CARTRIDGE REMANUFACTURING INSTRUCTIONS
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact [email protected]
www.uninetimaging.com
16. Final result.
You are now ready to fill the cartridge.
17. Place the cartridge in a vertical position and refill with the
appropriate amount of toner for use in Dell 5100cn. Install the
fill plug.
NOTE: Additional carrier may be required for this cartridge.
Consult your afermarket reseller for more details.
18. Wwrap the remaining seal around the toner fill plug as shown.
DELL 5100CN TONER CARTRIDGE REMANUFACTURING INSTRUCTIONS
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact [email protected]
www.uninetimaging.com
19. Place the gearless end cap, in its original positioning, over
the seal and toner fill plug as shown. Make sure that the
remaining seal flap is showing through as shown.
20. Push the end cap inward until it is properly secured by all
four locking tabs.
REPLACING THE OEM CHIP
21. Locate the OEM chip housing near the gearless side of the
cartridge.
22. Using a small flat head screwdriver, press down on the two
side tabs on the chip housing to release it.
DELL 5100CN TONER CARTRIDGE REMANUFACTURING INSTRUCTIONS
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact [email protected]
www.uninetimaging.com
23. Be sure to wear latex gloves when handing chips. 24. Unlock the actual chip from its housing by pressing on the
small tabs shown using an angled hook tool.
25. Carefully pry the chip from its housing. 26. Place the new contact chip on the cartridge as shown.
DELL 5100CN TONER CARTRIDGE REMANUFACTURING INSTRUCTIONS
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact [email protected]
www.uninetimaging.com
27. Place the housing over the chip as shown. 28. Press down until the side tabs lock it into place.
DELL 5100CN TONER CARTRIDGE REMANUFACTURING INSTRUCTIONS
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact [email protected]
www.uninetimaging.com
Autres manuels pour 5100cn
2
Autres manuels Dell Imprimante
Dell
Dell 5130CDN Manuel utilisateur
Dell
Dell 1250C Manuel utilisateur
Dell
Dell C7765DN Manuel utilisateur
Dell
Dell V305 Manuel utilisateur
Dell
Dell INSPIRON Inspiron 1100 Manuel utilisateur
Dell
Dell 1320c Manuel utilisateur
Dell
Dell 1710n - Laser Printer B/W Manuel utilisateur
Dell
Dell B5460dn Mono Laser Printer Manuel utilisateur
Dell
Dell 1720 - Vostro - Core 2 Duo 2.2 GHz Manuel utilisateur
Dell
Dell 3130cn - Color Laser Printer Manuel utilisateur
Dell
Dell Vostro 1710 Manuel utilisateur
Dell
Dell B5460dn Mono Laser Printer Manuel utilisateur
Dell
Dell Laser Printer 5530dn Manuel utilisateur
Dell
Dell S5840cdn Manuel utilisateur
Dell
Dell 2350 - Wireless WLAN Broadband Router Manuel utilisateur
Dell
Dell 5210n Mono Laser Printer Manuel utilisateur
Dell
Dell C7765DN Manuel
Dell
Dell 3115CN Manuel utilisateur
Dell
Dell Inspiron 1110 Manuel utilisateur
Dell
Dell B5460dn Mono Laser Printer Manuel utilisateur
