Cornelius 300026000 Manuel utilisateur

IMI Cornelius Inc. 1982-88 Revised: February 17, 1988

August 23, 1982

300099001

IMI CORNELIUS INC.

One Cornelius Place

Anoka. MN 55303-6234

Telephone (800) 238–3600

Facsimile (612) 422–3246

INSTALLATION KITS (P/N 300025000), (P/N 300025200),

(P/N 300026000), (P/N 300026200), (P/N 300388000) AND

(P/N 300388200) ON PRESSURIZED LIQUID-BASE

BEVERAGE DISPENSERS

Read and understand these instructions thoroughly before installing this kit. Retain these instructions as part of

your Service Manual.

NITROGEN GAS

CHECK VALVE

NITROGEN GAS

CYLINDER

DISPENSER

CONCENTRATE

TANK

WATER INLET

LINE CONNECTION

QUICK

DISCONNECT (2)

FIGURE 1. ONE-FLAVOR INSTALLATION KIT (P/N 300025000 OR P/N 300025200)

300099001 2

NITROGEN GAS

CHECK VALVE (2)

NITROGEN GAS

CYLINDER

DISPENSER

CONCENTRATE

TANK (2)

WATER INLET

LINE CONNECTION

QUICK

DISCONNECT (4)

FIGURE 2. TWO-FLAVOR INSTALLATION KIT (P/N 300026000 OR 300026200)

NITROGEN GAS

CHECK VALVE (4)

NITROGEN GAS

CYLINDER

GEMINI TWO-FLAVOR

DISPENSING VALVE (2)

DISPENSER

CONCENTRATE

TANK (4)

WATER INLET

LINE CONNECTION

QUICK

DISCONNECT (8)

1234

FIGURE 3. FOUR-FLAVOR INSTALLATION KIT (P/N 300388000 OR P/N 300388200)

3300099001

Kits Part Numbers and Their Part Quantities

Item-

No. Part

No. Name 300025000 300025200 300026000 300026200 300388000 300388200

1 183405000 Nitrogen Gas Regulator

Ass’y 111111

2 183301100 Check Valve 11––––

3 178025100 Tapered Gasket, White 335599

4 176090136 Gas Line Ass’y (with ball-

lock quick disconnect) 1–2–4–

178151136 Gas Line Ass’y (with pin-

lock quick disconnect) –1–2–4

5 176103148 Product Line Ass’y (with

ball-lock quick discon-

nect)

1–2–4–

178150148 Product Line Ass’y (with

ball-lock quick discon-

nect)

–1–2–4

6 183302100 Manifold Ass’y ––11––

183304100 Manifold Ass’y –––––1

IMPORTANT: Only qualified personnel should install this kit.

1. Unpack and inspect kit. Make sure all items are present and in good condition.

2. One Flavor Kit. (see Figure 1)

Install CHECK VALVE (item 2) in NITROGEN GAS REGULATOR ASS’Y (item 1) outlet. Use pipe thread

sealing compound to seal connection.

Two and Four–Flavor Kits. (see Figure 2 or 3)

Install MANIFOLD ASS’Y (item 6) in NITROGEN GAS REGULATOR (item 1) outlet. Use pipe thread seal-

ing compound to seal connection.

3. One-Flavor Kit. (see Figure 1)

A. Connect GAS LINE ASS’Y (item 4) to check valve installed in nitrogen gas regulator assembly. Seal

connection with TAPERED GASKET, WHITE (item 3).

B. Route, but do not connect, other end of gas line with quick disconnect on its end to concentrate tank

location.

C. Connect PRODUCT LINE ASS’Y (item 5) to 1/4-inch flare (7/16-20) concentrate inlet fitting on back of

dispenser. Seal connection with TAPERED GASKET, WHITE (item 3).

D. Route other end of product line, with quick disconnect on its end, to concentrate tank location.

300099001 4

Two and Four-Flavor Kits. (see Figure 2 or 3)

E. Connect GAS LINES ASSEMBLIES (item 4) to check valves on manifold assembly installed in nitro-

gen gas regulator assembly outlet. Seal connections with TAPERED GASKETS, WHITE (item 3).

F. Route, but do not connect, other ends of gas lines with quick disconnects on their ends to concentrate

tanks location.

G. Connect PRODUCT LINES ASSEMBLIES (item 5) to 1/4-inch flare (7/16-20) concentrate inlet fittings

on back of the Dispenser. Seal connections with TAPERED GASKETS, WHITE (item 3).

H. Route other ends of product lines, with quick disconnects on their ends, to concentrate tanks location.

4. Connect nitrogen gas pressure regulator and lines assembly to nitrogen gas cylinder as instructed in Ser-

vice Manual provided with the Dispenser.

5. Complete Dispenser installation as instructed in Service Manual provided with the Dispenser.

IMPORTANT: Nitrogen gas check valves (see applicable Figure 1, 2, or 3) must be inspected and

serviced at least once a year as instructed in Service Manual provided with the Dispenser.

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Cornelius Distributeur de boissons

Cornelius

Cornelius CHD22 Mode d’emploi

Cornelius

Cornelius FCB Pinnacle Manuel utilisateur

Cornelius

Cornelius DF 250 BCP Manuel utilisateur

Cornelius

Cornelius VIPER 2 FLAVOR Manuel utilisateur

Cornelius

Cornelius Jet Spray EJ1 Manuel utilisateur

Cornelius

Cornelius Quest Juice Dispenser Manuel utilisateur

Cornelius

Cornelius 2 Flavor Post-Mix Cold Coffee Dispenser Quest... Manuel utilisateur

Cornelius

Cornelius Flavorfusion Ice Drink Dispenser with Flavor... Manuel utilisateur

Cornelius

Cornelius ED 300 BC Manuel utilisateur

Cornelius

Cornelius IDC Pro Mode d’emploi

Cornelius

Cornelius Remcor TJ200 Manuel utilisateur

Cornelius

Cornelius ED 300 BC Manuel utilisateur

Cornelius

Cornelius 1522 Manuel utilisateur

Cornelius

Cornelius JetSpray JT30-W25 Manuel utilisateur

Cornelius

Cornelius Quest Elite 2000 Manuel utilisateur

Cornelius

Cornelius The Profile PR150 BC Manuel utilisateur

Cornelius

Cornelius A8530 Guide de configuration

Cornelius

Cornelius 6 Flavor Mode d’emploi

Cornelius

Cornelius VANTAGE Manuel utilisateur

Cornelius

Cornelius Enduro-200/250 Manuel utilisateur

Cornelius

Cornelius FCB VIPER Manuel utilisateur

Cornelius

Cornelius SPIRE 4.1 Manuel utilisateur

Cornelius

Cornelius REMCOR R-134A Supplément

Cornelius

Cornelius VIPER (E) 2 FLAVOR Manuel utilisateur

Manuels Distributeur de boissons populaires d'autres marques

PEGAS

PEGAS Evolution Manuel utilisateur

Ugolini

Ugolini MT micro Manuel utilisateur

Bunn

Bunn SLCA-7 Instructions d'installation

Gekkeikan

Gekkeikan Sake Machine Manuel utilisateur

Olympia

Olympia DH709 Manuel utilisateur

Marco

Marco ECOSMART PB10 Manuel utilisateur

Marvel

Marvel ML24BN Series Manuel

Cecilware

Cecilware 2K-GB-LD Manuel

Sure Vend

Sure Vend 673 Manuel utilisateur

Nostalgia Electrics

Nostalgia Electrics KEG7000SS Manuel utilisateur

Bunn

Bunn LCR-3 HV Guide de dépannage

Servend

Servend SV-200 Manuel utilisateur

EdgeStar

EdgeStar VBR440 Manuel utilisateur

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C Manuel utilisateur

Siemens

Siemens GA 3000 Manuel d'instructions et de sécurité

Selbach

Selbach Fruit Juice dispenser Manuel utilisateur

Taylor

Taylor C302NP Manuel utilisateur

Vinotemp

Vinotemp VT-WINEDISP2 Manuel utilisateur