American Dryer Corp. AD-310 Manuel utilisateur

ADC Part No. 113110

AD-310 Phase 7

(with Non-Tilting Options)

Installation Manual

For replacement parts, contact the reseller

from which the dryer was purchased or

American Dryer Corporation

88 Currant Road

Fall River A 02720-4781

Telephone: (508) 678-9000 / Fax: (508) 678-9447

E-mail: techsupport@amdry.com

042399D G/tcosta

WARNING: For your safety the

information in this manual must be

followed to minimize the risk of fire or

explosion or to prevent property dama e,

personal injury or death.

Do not store or use asoline or other flammable

vapor and liquids in the vicinity of this or any

other appliance.

WHAT DO YOU DO IF YOU SMELL GAS

* Do not try to li ht any appliance.

* Do not touch any electrical switch; do not use

any phone in your buildin .

* Clear the room, buildin or area of all

occupants.

* Immediately call your as supplier from a

nei hbor's phone. Follow the as supplier's

instructions.

* If you cannot reach your as supplier, call the

fire department.

Installation and service must be performed by a

qualified installer, service a ency or the as

supplier.

AVERTISSEMENT: Assurez-vous de bien

suivre les instructions données dans cette

notice pour réduire au minimum le risque

dincendie ou dexplosion ou pour éviter tout

domma e matériel, toute blessure ou la mort.

Ne pas entreposer ni utiliser dessence ni

dautres vapeurs ou liquides inflammables dans

le voisina e de cet appareil ou de tout autre

appareil.

QUE FAIRE SI VOUS SENTEZ UNE ODEUR

DE GAZ:

* Ne pas tenter dallumer dappareil.

* Ne touchez à aucun interrupteur. Ne pas

vous servir des téléphones se trouvant dans

le bâtiment où vous vous trouvez.

* Évacuez la pièce, le bâtiment ou la zone.

* Appelez immédiatement votre fournisseur de

az depuis un voisin. Suivez les instructions

du fournisseur.

* Si vous ne pouvez rejoindre le fournisseur

de az, appelez le service des incendies.

Linstallation et lentretien doivent être assurés

par un installateur ou un service dentretien

qualifié ou par le fournisseur de az.

Retain This Manual In A Safe Place For Future Reference

American Dryer Corporation products embody advanced concepts in engineering, design, and safety. If this product is

properly maintained, it will provide many years of safe, efficient, and trouble-free operation.

ONLY qualified technicians should service this equipment.

OBSERVE ALL SAFETY PRECAUTIONS displayed on the equipment or specified in the installation manual included with

the dryer.

The following FOR YOUR SAFETY caution must e posted near the dryer in a prominent location.

AD-310 Non-Tilting

IMPORTANT NOTE TO PURCHASER

Information must be obtained from your local as supplier on the instructions

to be followed if the user smells as. These instructions must be posted in a

prominent location near the dryer.

FOR YOUR SAFETY

Do not store or use asoline or

other flammable vapors or

liquids in the vicinity of this or

any other appliance.

POUR VOTRE SÉCURITÉ

Ne pas entreposer ni utiliser dessence

ni dautres vapeurs ou liquides

inflammables dans le voisina e de cet

appareil ou de yout autre appareil.

We have tried to make this manual as complete as possible and hope you will find it useful. ADC reserves the right to make

changes from time to time, without notice or obligation, in prices, specifications, colors, and material, and to change or

discontinue models.

Important

For your convenience, log the following information

DATE OF PURCHASE ____________________________ MODEL NO. __________________________________________

RESELLERS NAME _______________________________________________________________________________________

Serial Number(s) ________________________________________________________________________________________

________________________________________________________________________________________

Replacement parts can be obtained from your reseller or the ADC factory. When ordering replacement parts from the factory,

you can FAX your order to ADC at (508) 678-9447 or telephone your order directly to the ADC Parts Department at

(508) 678-9000. Please specify the dryer model number and serial number in addition to the description and part number, so

that your order is processed accurately and promptly.

IMPORTANT

YOU MUST DISCONNECT AND LOCKOUT THE ELECTRIC SUPPLY AND THE GAS

SUPPLY OR THE STEAM SUPPLY BEFORE ANY COVERS OR GUARDS ARE

REMOVED FROM THE MACHINE TO ALLOW ACCESS FOR CLEANING,

ADJUSTING, INSTALLATION, OR TESTING OF ANY EQUIPMENT PER OSHA

(Occupational Safety and Health Administration) STANDARDS.

WARNING

CHILDREN SHOULD NOT BE ALLOWED TO PLAY ON OR NEAR THE DRYER(S).

CHILDREN SHOULD BE SUPERVISED IF NEAR DRYERS IN OPERATION.

CAUTION

DRYERS SHOULD NE ER BE LEFT UNATTENDED WHILE IN OPERATION.

FOR YOUR SAFETY

DO NOT DRY MOP HEADS IN THE DRYER.

DO NOT USE DRYER IN THE PRESENCE OF DRY CLEANING FUMES.

WARNING

UNDER NO CIRCUMSTANCES sh uld the d r switch r the heat circuit devices

ever be disabled.

Caution: Label all wires prior to

disconnection when servicing controls. Wiring

errors can cause improper operation.

«Attention: Lor des opérations dentretien

des commandes étiqueter tous fils avant

de les déconnecter. Toute erreur de

câblage peut étre une source de danger et

de panne.»

WARNING

The dryer must never be perated with any f the back guards, uter t ps, r service

panels rem ved. PERSONAL INJURY OR FIRE COULD RESULT.

IMPORTANT

PLEASE OBSERVE ALL SAFETY PRECAUTIONS displayed n the equipment and/ r

specified in the installati n manual included with the dryer.

WARNING

DRYER MUST NEVER BE OPERATED WITHOUT THE LINT FILTER/SCREEN IN

PLACE, EVEN IF AN EXTERNAL LINT COLLECTION SYSTEM IS USED.

Dryers must not be installed or stored in an area where it will be exposed to water or weather.

The wiring diagram for the dryer is located in the front electrical control box area.

Table of Contents

SECTION I

IMPORTANT INFORMATION ............................................................................... 3

A. Receivin and Handlin ............................................................................................................... 3

B. Safety Precautions ...................................................................................................................... 4

SECTION II

SPECIFICATIONS/DIMENSIONS AND COMPONENT IDENTIFICATION6

A. Specifications (Gas and Steam) ................................................................................................... 6

B. Dimensions and Component Location ......................................................................................... 7

SECTION III

INSTALLATION PROCEDURES ........................................................................... 9

A. Reassembly Of Dryer ................................................................................................................. 9

B. Location Requirements ............................................................................................................. 14

C. Fresh Air Supply Requirements ................................................................................................. 15

D. Exhaust Requirements ............................................................................................................... 16

E. Compressed Air Supply System ................................................................................................ 22

F. Electrical Information ................................................................................................................ 25

G.. Gas Information ........................................................................................................................ 29

H. Water Supply Connection For Optional Sprinkler System .......................................................... 32

I. Steam Information .................................................................................................................... 33

J. Preoperational Tests ................................................................................................................. 38

K. Preparation For Operation/Start-Up ......................................................................................... 40

L. Shut Down Instructions ............................................................................................................. 41

SECTION IV

SERVICE/PARTS INFORMATION ...................................................................... 42

A. Service ..................................................................................................................................... 42

B. Parts ........................................................................................................................................ 42

SECTION V

WARRANTY INFORMATION .............................................................................. 43

A. Returnin Warranty Card(s) ...................................................................................................... 43

B. Warranty .................................................................................................................................. 43

C. Returnin Warranty Part(s) ........................................................................................................ 43

SECTION VI

ROUTINE MAINTENANCE .................................................................................. 45

A. Cleanin ................................................................................................................................... 45

B. Adjustments ............................................................................................................................. 47

C. Lubrication ............................................................................................................................... 47

SECTION VII

COMPONENT SYSTEM DESCRIPTIONS........................................................ 48

A. Basket (Tumbler) Drive System ................................................................................................. 48

B. Basket (Tumbler) ...................................................................................................................... 49

C. Air Blower Drive System .......................................................................................................... 49

D. Safety Devices .......................................................................................................................... 49

E. Steam Damper Actuator System ............................................................................................... 51

SECTION VIII

BURNER AND BASKET (TUMBLER /LINT CHAMBER MANUAL RESET

HI-LIMIT INSTRUCTIONS ................................................................................... 52

Gas Models Only ........................................................................................................................... 52

Steam Models Only ........................................................................................................................ 53

SECTION IX

DATA LABEL INFORMATION ............................................................................. 54

A. Data Label ............................................................................................................................... 54

SECTION X

PROCEDURE FOR FUNCTIONAL CHECK OF REPLACEMENT

COMPONENTS ....................................................................................................... 56

SECTION XI

PHASE 7 OPL SYSTEM DIAGNOSTICS ........................................................... 58

A. Dia nostic (L.E.D. Display) Fault Messa es .............................................................................. 58

B. I/O Board Input and Output L.E.D. Indicators .......................................................................... 60

SECTION XII

TROUBLESHOOTING ........................................................................................... 65

SECTION XIII

OPTIONAL SPRINKLER SYSTEM COMPONENTS ...................................... 73

Optional Sprinkler Circuit Components ........................................................................................... 73

Sprinkler Option Temperature Controller Settin s ............................................................................ 75

SECTION I

IMPORTANT INFORMATION

A. RECEIVING AND HANDLING

The dryer is shipped in a protective stretch wrap cover with protective cardboard corners and top cover

(or optional box) as a means of preventing damage in transit. Upon delivery, the dryer and/or packaging, and

wooden skid should be visually inspected for shipping damage. If any damage whatsoever is noticed, inspect

further before delivering carrier leaves.

Dryers damaged in shipment:

1. ALL dryers should be inspected upon receipt and before they are signed for.

2. If there is suspected damage or actual damage, the trucker’s receipt should be so noted.

3. If the dryer is damaged beyond repair, it should be refused. Those dryers, which were not damaged in a

damaged shipment should be accepted, but the number received and the number refused must be noted

on the receipt.

4. If you determine that the dryer was damaged after the trucker has left your location, you should call the

delivering carrier’s freight terminal immediately and file a claim. The freight company considers this concealed

damage. This type of freight claim is very difficult to get paid and becomes extremely difficult when more

than a day or two passes after the freight was delivered. It is your responsibility to file freight claims.

Dryer/parts damaged in transit cannot be claimed under warranty.

5. Freight claims are the responsibility of the consignee, and ALL claims must be filed at the receiving end.

ADC assumes no responsibility for freight claims or damages.

6. If you need assistance in handling the situation, please contact theADC Traffic Manager at (508) 678-9000.

IMPORTANT: The basket (tumbler) section of the dryer must be transported and handled in an

upright position at ALLtimes.

B. SAFETY PRECAUTIONS

WARNING: For your safety, the information in this manual must be followed to minimize the risk of

fire or explosion or to prevent property damage, personal injury, or loss of life.

WARNING: The dryer must never be operated with any of the back guards, outer tops, or

service panels removed. PERSONAL INJURY OR FIRE COULD RESULT.

1. DO NOT store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other

appliance.

2. Purchaser/user should consult the local gas supplier for proper instructions to be followed in the event the

user smells gas. The instructions should be posted in a prominent location.

3. WHAT TO DO IF YOU SMELL GAS...

a. DO NOT try to light any appliance.

b. DO NOT touch any electrical switch.

c. DO NOT use any phone in your building.

d. Clear the room, building, or area of ALL occupants.

e. Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

f. If you cannot reach your gas supplier, call the fire department.

4. Installation and service must be performed by a qualified installer, service agency, or gas supplier.

5. Dryer(s) must be exhausted to the outdoors.

6. Although ADC produces a very versatile dryer, there are some articles that, due to fabric composition or

cleaning method, should not be dried in it.

WARNING: Dry only water washed fabrics. DO NOT dry articles spotted or washed in dry

cleaning solvents, a combustible detergent, or “all purpose” cleaner.

EXPLOSION COULD RESULT.

WARNING: DO NOT dry rags or articles coated or contaminated with gasoline, kerosene, oil, paint,

or wax.

EXPLOSION COULD RESULT.

WARNING: DO NOT dry mop heads. Contamination by wax or flammable solvents will create a

fire hazard.

WARNING: DO NOT use heat for drying articles that contain plastic, foam, sponge rubber, or

similarly textured rubber materials. Drying in a heated basket (tumbler) may damage

plastics or rubber and also may be a fire hazard.

7. A program should be established for the inspection and cleaning of lint in the heating unit area, exhaust

ductwork, and inside the dryer. The frequency of inspection and cleaning can best be determined from

experience at each location.

WARNING: The collection of lint in the burner area and exhaust ductwork can create a potential fire

hazard.

8. For personal safety, the dryer must be electrically grounded in accordance to local codes and/or the

National Electrical Code ANSI/NFPA NO. 70-LATEST EDITION, or in Canada, the Canadian Electrical

Codes Parts 1 & 2 CSA C22.1-1990 or LATEST EDITION.

NOTE: Failure to do so will VOID THE WARRANTY.

9. UNDER NO CIRCUMSTANCES should the dryer door switches, lint door switch, heat safety circuit

ever be disabled.

WARNING: PERSONAL INJURY OR FIRE COULD RESULT.

10. This dryer is not to be used in the presence of dry cleaning solvents or fumes.

11. Remove articles from the dryer as soon as the drying cycle has been completed.

WARNING: Articles left in the dryer after the drying and cooling cycles have been completed can

create a fire hazard.

12. DO NOT operate steam dryers with more than 125 PSI (8.62 bars) steam pressure. Excessive steam

pressure can damage steam coil and/or harm personnel.

13. Replace leaking flexible hoses or other steam fixtures immediately. DO NOT operate the dryer with

leaking flexible hoses. PERSONAL INJURY MAY RESULT.

14. READ AND FOLLOW ALL CAUTION AND DIRECTION LABELS ATTACHED TO THE

DRYER.

15. For safety, proper operation, and optimum performance, the dryer must not be operated with a load less than

sixty-six percent (66%), 204 lbs. (92.53 kg.) of its rated capacity.

WARNING: YOU MUST DISCONNECT AND LOCKOUT THE ELECTRIC SUPPLY AND

THE GAS SUPPLY OR THE STEAM SUPPLY BEFORE ANY COVERS OR

GUARDS ARE REMOVED FROM THE MACHINE TO ALLOW ACCESS

FOR CLEANING, ADJUSTING, INSTALLATION, OR TESTING OF ANY

EQUIPMENT PER OSHA (Occupational Safety and Health Administration)

STANDARDS.

SECTION II

SPECIFICATIONS/DIMENSIONS

AND COMPONENT IDENTIFICATION

A. SPECIFICATIONS (GAS AND STEAM)

*Dryers must be provided with a clean, dry, and regulated 80 PSI +/- 10 PSI (5.51 bars +/- 0.68 bars) air supply

(equivalent volume = 9 cfh [0.25 cmh]).

NOTE: ADCreserves the right to make changes in specifications at any time without notice or

obligation.

MAXIMUM CAPACITY (DRY WEIGHT) 310 lbs 141 kg

BASKET (TUMBLER) DIAMETER 62-1/2” 158.75 cm

BASKET (TUMBLER) DEPTH 60” 152.4 cm

BASKET (TUMBLER) VOLUME 106.5 cu. ft. 3.02 cu. m.

DRIVE MOTOR 5 HP 3.73 kw

DOOR OPENING (DIAMETER) 36-3/4” w x 43” h 93.3 cm x 109.2 cm

DOOR STILL HEIGHT - LEVEL 36-1/2” 92.71 cm

COMPRESSED AIR 80 PSI 5.51 bars

COMPRESSED AIR CONNECTION 3/8” F.P.T.

VOLTAGE AVAILABLE 208-600v 3ø3, 4w 50/60 Hz

BLOWER MOTOR 15 HP 11.25 kw

HEAT INPUT 1,125,000 btu/hr 283,500 kcal/hr

APPROX. WEIGHT (UNCRATED) 5,100 lbs 2,314 kg

AIRFLOW 6,500 cfm 184.1 cmm

INLET PIPE SIZE 1-1/2”

VOLTAGE AVAILABLE 208-600v 3ø3, 4w 50/60 Hz

BLOWER MOTOR 25 HP 18.64 kw

APPROX. WEIGHT (UNCRATED) 5,600 lbs 2,540 kg

AIRFLOW 8,500 cfm 240.7 cmm

STEAM CONSUMPTION BOILER HP

NORMAL LOAD

1,153 lbs/hr 524 kg/hr 55

OPERATING STEAM PRESSURE STEAM SUPPLY STEAM RETURN

125 PSI max 8.62 bars 2” 2”

Shaded areas are stated in metric equivalents

Gas*Steam*

Autres manuels pour AD-310

Table des matières

Autres manuels American Dryer Corp. Séchoir

American Dryer Corp.

American Dryer Corp. AD-630 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. SL31-31 Manuel

American Dryer Corp.

American Dryer Corp. AD-410 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-285DH Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-202 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. Phase 7 OPL/Fire Suppression System EURO-14 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-575 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-530HS Guide de l'administrateur

American Dryer Corp.

American Dryer Corp. SL31 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-30 (Export) Guide de l'administrateur

American Dryer Corp.

American Dryer Corp. ADG / MLG-170DR Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-50V Manuel utilisateur

American Dryer Corp.

American Dryer Corp. ADE-50S Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-285 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-360X2 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. Phase 7 OPL with S.A.F.E. Gas DSI AD-78 IV Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-95HS Guide de l'administrateur

American Dryer Corp.

American Dryer Corp. Non-Tilting AD-200 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. Aquatex AD-52 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. Hot Surface Ignition System ADG-530 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. AD-24 II Manuel utilisateur

American Dryer Corp.

American Dryer Corp. Gas/Steam Models ML-82 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. ML-175 Manuel utilisateur

American Dryer Corp.

American Dryer Corp. ML-122 Manuel utilisateur

Manuels Séchoir populaires d'autres marques

Bosch

Bosch WTA79200GB Manuel utilisateur

Amana

Amana W10233410A Manuel utilisateur

Miele

Miele TWH 780 WP Manuel utilisateur

Asko

Asko T760 Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Manuel utilisateur

Bosch

Bosch Logixx 10 WTB76556GB Fiche technique

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Mode d’emploi

Electrolux

Electrolux EW2H328R2 Manuel utilisateur

Beko

Beko DS8433RX1M Manuel utilisateur

Dawlance

Dawlance Spinner DS 6000 C Manuel utilisateur

Electrolux

Electrolux TP5080TW Manuel utilisateur

AEG

AEG TR838P4OB Manuel utilisateur

Indesit

Indesit IDV 75 Manuel utilisateur

Infiniton

Infiniton SD-DG85C Manuel utilisateur

BOMANN

BOMANN WT 5019 Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems TMB795C Manuel utilisateur

Asko

Asko T793C Manuel utilisateur

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manuel utilisateur