Alliance Laundry Systems BD3LLFGS401UW01 Mode d'emploi

www.comlaundry.com

DRY716C

Part No. 513447

April 2010

Troubleshooting

Single and

Stacked Dryers

Refer to Page 6 for Model Numbers

the expressed written consent of the publisher.

513447 1

Table of

Contents

Section 1 – Safety Information ...............................................................3

Locating an Authorized Servicer...........................................................4

Section 2 – Introduction..........................................................................5

Customer Service...................................................................................5

Nameplate Location...............................................................................5

Model Identification ..............................................................................6

How Your Dryer Works ........................................................................9

Section 3 – Dryer Troubleshooting ......................................................10

1. Dryer Motor Does Not Run ........................................................10

2. Dryer Stops In Cycle; Quits After The First Few Loads;

Has A Burning Smell; Cycles On Motor Thermal Protector......12

3. Dryer Motor Runs But Cylinder Does Not Turn ........................13

4. Dryer Motor Does Not Stop........................................................14

5. Dryer Runs Only When Door is Open........................................15

6. Dryer Heating Assembly Does Not Heat or

Burner Does Not Ignite...............................................................16

7. Igniter Does Not Glow (Gas Supply Sufficient) –

Gas Dryer Models .......................................................................18

8. Burner Ignites and Goes Out Repeatedly –

Gas Dryer Models .......................................................................19

9. Igniter Glows But Burner Does Not Ignite –

Gas Dryer Models .......................................................................20

10. Dryer Heater Assembly Or Burner Shuts Off Prematurely ........21

11. Dryer Heater Assembly or Burner Repeatedly

Cycles Off On Limit Thermostat ................................................22

12. Dryer Heater Assembly or Burner Does Not Shut Off...............24

13. Clothes Do Not Dry in Dryer......................................................25

14. Clothes Are Too Hot When Removed From Dryer ....................26

15. Excessive Chattering Or Vibrating Noise in Dryer ....................27

16. Excessive Humming Or Whistling Noise in Dryer.....................28

Section 4 – Electronic Control Troubleshooting.................................29

17. Error Codes .................................................................................29

18. Coins Ignored When Entered......................................................30

19. No IR Communication................................................................31

20. No Display ..................................................................................32

21. Door Open...................................................................................34

22. Motor Will Not Start...................................................................36

23. No Heat (Electric) .......................................................................38

24. No Heat (Gas) .............................................................................40

Section 5 – Coin Drop Troubleshooting...............................................42

25. Troubleshooting Coin Drop ........................................................42

Section 6 – Adjustments........................................................................47

26. Leveling Legs..............................................................................47

27. Burner Flame (Gas Models)........................................................48

28. Cleaning Non-Electronic Coin Drop...........................................50

29. Cleaning Electronic Coin Drop...................................................52

2513447

Section 7 – Test Procedures ..................................................................55

30. Timer Contacts............................................................................55

31. Fabric Selector Switch ................................................................56

32. Drive Motor.................................................................................57

33. Accumulator (Metered Models)..................................................60

34. Motor Switch...............................................................................61

35. Burner System Operation (Gas Models).....................................63

36. Electrical Circuit To Ignition System (Gas Models) ..................65

37. Gas Valve Coils Check (Gas Models) ........................................65

38. Sensor Check (Gas Models)........................................................66

39. Igniter Check (Gas Models)........................................................66

40. Ignition Control Grounding Check (Silicon Nitride Ignition) ....66

41. Thermal Fuse (Electric Models) .................................................66

42. Heater Assembly (Electric Models)............................................67

43. Cycling or Limit Thermostat.......................................................67

44. Door Switch ................................................................................67

45. Thermistor...................................................................................68

Section 8 – Internal Wiring of Dryer Motor Switch...........................69

513447 3

Section 1

Safety Information

Throughout this manual and on machine decals, you will find precautionary statements (“CAUTION,”

“WARNING” and “DANGER”) followed by specific instructions. These precautions are intended for the personal

safety of the operator, user, servicer, and those maintaining the machine.

aDANGER

Danger indicates an imminently hazardous situation that, if not avoided, will cause severe personal injury or death.

WARNING

Warning indicates a hazardous situation that, if not avoided, could cause severe personal injury or death.

CAUTION

Caution indicates a hazardous situation that, if not avoided, may cause minor or moderate personal injury or

property damage.

Additional precautionary statements (“IMPORTANT” and “NOTE”) are followed by specific instructions.

IMPORTANT

The word “IMPORTANT” is used to inform the reader of specific procedures where minor machine damage will

occur if the procedure is not followed.

NOTE

The word “NOTE” is used to communicate installation, operation, maintenance or servicing information that is

important but not hazard related.

In the interest of safety, some general precautions relating to the operation of this machine follow.

• Failure to install, maintain, and/or operate this machine according to the manufacturer’s

instructions may result in conditions which can produce serious injury, death and/or property

damage.

• Do not repair or replace any part of the machine or attempt any servicing unless specifically

recommended or published in this Service Manual and that you understand and have the

skills to carry out.

• Whenever ground wires are removed during servicing, these ground wires must be

reconnected to ensure that the machine is properly grounded and to reduce the risk of fire,

electric shock, serious injury, or death.

W284

WARNING

4513447

Safety Information

NOTE: The WARNINGS and IMPORTANT INSTRUCTIONS appearing in this manual are not meant to

cover all possible conditions and situations that may occur. Common sense, caution and care must be

exercised when installing, maintaining or operating the machine.

Always contact your dealer, distributor, service agent or the manufacturer about any problems or conditions you do

not understand.

Locating an Authorized Servicer

Alliance Laundry Systems is not responsible for personal injury or property damage resulting from improper

service. Review all service information before beginning repairs.

Warranty service must be performed by an authorized technician, using authorized factory parts. If service is

required after the warranty expires, Alliance Laundry Systems also recommends contacting an authorized

technician and using authorized factory parts.

To reduce the risk of electric shock, fire, explosion, serious injury or death:

• Disconnect electric power to the dryer(s) before servicing.

• Close gas shut-off valve to gas dryer(s) before servicing.

• Never start the dryer(s) with any guards/panels removed.

• Whenever ground wires are removed during servicing, these ground wires must be

reconnected to ensure that the dryer is properly grounded.

W001R1

WARNING

Repairs that are made to your products by unqualified persons can result in hazards due to

improper assembly or adjustments subjecting you or the inexperienced person making such

repairs to the risk of serious injury, electrical shock or death.

W007

WARNING

If you or an unqualified person perform service on your machine, you must assume the

responsibility for any personal injury or property damage which may result. The manufacturer

will not be responsible for any injury or property damage arising from improper service and/or

service procedures.

W286

WARNING

513447 5

Section 2

Introduction

Customer Service

If literature or replacement parts are required, contact

the source from whom the machine was purchased or

contact Alliance Laundry Systems at (920) 748-3950

for the name and address of the nearest authorized parts

distributor.

For technical assistance, call (920) 748-3121.

Nameplate Location

When calling or writing about your dryer, be sure to

mention model and serial numbers. Model and serial

numbers are located on the nameplate. The nameplate

is in one of the four corners of the door well. The door

well is the shaded area shown.

D412P

Nameplate

6513447

Introduction

Model Identification

Information in this manual is applicable to these dryers.

Model

Number

Coin Drop

Ready

Coin Drop

Installed

Card Reader

Ready

Central Pay

Electric Heat

Gas Heat

BD3LLFGS401UW01 X X

BD3LLFSS401UN01 X X

BD3LXFGS401UW01 X X

BD3LXFSS401UN01 X X

BDGLLFGS301EW01 X X

BDGLLFSS301EN01 X X

BDGLXFGS301EW01 X X

BDGLXFSS301EN01 X X

HDELEFGS151CW01 X X

HDELEFGS151CWNA X X

HDELEFGS171CQ01 X X

HDELEFGS171CW01 X X

HDELERGS151CW01 X X

HDELERGS151CWNA X X

HDELERGS171CW01 X X

HDELXFGS151CW01 X X

HDELXFGS171CW01 X X

HDELXRGS151CW01 X X

HDELXRGS171CW01 X X

HDELYFGS151CW01 X X

HDELYFGS171CW01 X X

HDELYRGS151CW01 X X

HDELYRGS151CWNA X X

HDELYRGS171CW01 X X

HDGLEFGS111CW01 X X

HDGLERGS111CW01 X X

HDGLERGS111CWNA X X

HDGLXFGS111CW01 X X

HDGLXFGS111CWNA X X

HDGLXRGS111CW01 X X

HDGLYFGS111CW01 X X

HDGLYFGS111CWNA X X

HDGLYRGS111CW01 X X

HSELXFGW281CW01 X X

* Add Letter To Designate Color. L – Almond W – White Q – Bisque

513447 7

Introduction

HSELXFGW291CW01 X X

HSELYFGW281CW01 X X

HSELYFGW291CW01 X X

HSGLXFGW091CW01 X X

HSGLYFGW091CW01 X X

NDELXFGS301UW01 X X

NDGLXFGS301EW01 X X

RDELYFGS151CW01 X X

RDELYFGS171CW01 X X

RDGLYFGS111CW01 X X

SDELCFGS171TW01 X X

SDELCFSW171TN01 X X

SDELCRGS151TW01 X X

SDELCRGS171TW01 X X

SDELCRGS171TW02 X X

SDELCRGS171TWNA X X

SDELXRGS171TW01 X X

SDELXRGS171TW02 X X

SDELYFGS171TW01 X X

SDELYFSW171TN01 X X

SDELYRGS151TW01 X X

SDELYRGS171TW01 X X

SDGLCFGS111TW01 X X

SDGLCFSW111TN01 X X

SDGLCRGS111TW01 X X

SDGLCRGS111TW02 X X

SDGLCRGS111TWNA X X

SDGLXRGS111TW01 X X

SDGLXRGS111TW02 X X

SDGLYFGS111TW01 X X

SDGLYFGS111TWNA X X

SDGLYFSW111TN01 X X

SDGLYRGS111TW01 X X

SDGLYRGS111TWNA X X

SSELCFGS151TW01 X X

SSELCFGS171TW01 X X

SSELCFGW151TW01 X X

Model

Number

Coin Drop

Ready

Coin Drop

Installed

Card Reader

Ready

Central Pay

Electric Heat

Gas Heat

* Add Letter To Designate Color. L – Almond W – White Q – Bisque

8513447

Introduction

SSELCFGW171TW01 X X

SSELXFGW171TW01 X X

SSELYFGS171TW01 X X

SSELYFGW171TW01 X X

SSELYFGW171TWNA X X

SSGLCFGS111TW01 X X

SSGLCFGS111TWNA X X

SSGLCFGW111TW01 X X

SSGLCFGW111TWNA X X

SSGLXFGW111TW01 X X

SSGLYFGS111TW01 X X

SSGLYFGS111TWNA X X

SSGLYFGW111TW01 X X

SSGLYFGW111TWNA X X

Model

Number

Coin Drop

Ready

Coin Drop

Installed

Card Reader

Ready

Central Pay

Electric Heat

Gas Heat

* Add Letter To Designate Color. L – Almond W – White Q – Bisque

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Alliance Laundry Systems Séchoir

Alliance Laundry Systems

Alliance Laundry Systems 512685R5 Mode d’emploi

Alliance Laundry Systems

Alliance Laundry Systems 513006R3 Mode d’emploi

Alliance Laundry Systems

Alliance Laundry Systems DRY725C Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems 120 Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems DRY724C_SVG Mode d’emploi

Alliance Laundry Systems

Alliance Laundry Systems DRY684C Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems 512042R4 Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems continuity Manuel du propriétaire

Alliance Laundry Systems

Alliance Laundry Systems KE Series Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems 512906 Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems AT120FG Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems CHD25G2-CA025L Manuel du propriétaire

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumbler 70278501R5EN Manuel du propriétaire

Alliance Laundry Systems

Alliance Laundry Systems HA025E Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems LES33A F4562 Series Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems Clothes Dryer Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems ZE1010-1502 Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems T453I Guide de dépannage

Alliance Laundry Systems

Alliance Laundry Systems SWD439C Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems CA120L Manuel du propriétaire

Alliance Laundry Systems

Alliance Laundry Systems DRY725C_SVG Manuel utilisateur

Alliance Laundry Systems

Alliance Laundry Systems CHD25G2-CA025L Manuel du propriétaire

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers 50 Pound Capacity 75 Pound Capacity Model Identification Part No.... Manuel du propriétaire

Alliance Laundry Systems

Alliance Laundry Systems DR7000WE Manuel utilisateur

Manuels Séchoir populaires d'autres marques

Bosch

Bosch WTA79200GB Manuel utilisateur

Amana

Amana W10233410A Manuel utilisateur

Miele

Miele TWH 780 WP Manuel utilisateur

Asko

Asko T760 Manuel utilisateur

Bosch

Bosch Logixx 10 WTB76556GB Fiche technique

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Mode d’emploi

Electrolux

Electrolux EW2H328R2 Manuel utilisateur

Beko

Beko DS8433RX1M Manuel utilisateur

Dawlance

Dawlance Spinner DS 6000 C Manuel utilisateur

Electrolux

Electrolux TP5080TW Manuel utilisateur

AEG

AEG TR838P4OB Manuel utilisateur

Indesit

Indesit IDV 75 Manuel utilisateur

Infiniton

Infiniton SD-DG85C Manuel utilisateur

BOMANN

BOMANN WT 5019 Manuel utilisateur

Asko

Asko T793C Manuel utilisateur

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manuel utilisateur

Frigidaire

Frigidaire CAQE7077KW0 Manuel du propriétaire

Bosch

Bosch WTX8HKM9SN Manuel utilisateur