X-Stream CLEAN Volt XCMADD Manuel utilisateur

ELECTROSTATIC SPRAYER

Operation Guide

Model: XCEAHV

CLEAN WITH

CONFIDENCE

TABLE

OF CONTENTS

04 WARNINGS

.........................................................................................................

05 SAFETY

.........................................................................................................

08 REGISTER YOUR SPRAYER

.........................................................................................................

10 WHAT’S IN THE BOX

.........................................................................................................

09 SPRAYER CAPABILITIES

.........................................................................................................

12 ASSEMBLY & SPRAYING

.........................................................................................................

16 BATTERY CHARGING

.........................................................................................................

23 WARRANTY POLICY

.........................................................................................................

18 PARTS & ACCESSORIES

.........................................................................................................

20 TROUBLESHOOTING

.........................................................................................................

CLEAN WITH

CONFIDENCE™

ATTENTION

WARNING

• Never use this sprayer with liquids such as gasoline, ethanol, methanol, acid, caustic, or any other ammable, pressure, heat, or gas producing chemicals.

• Always read and follow chemical manufacturer’s instructions before use with this sprayer as some chemicals may be hazardous when used with this sprayer.

• Never leave chemicals or solutions sitting in your sprayer after using.

• After using sprayer with chemicals, it is important to rinse the tank and ush the sprayer with fresh water for 3-5 minutes to ensure residual chemicals in the gun, tank, pump,

and hose are cleaned out

• Read and follow all instructions and cautions on label of products used in this sprayer.

• Do not store your sprayer in extremely high temperatures. Heat can lead to the build-up of pressure within the sprayer, resulting in a possible explosion.

• Do not try to make modications to the sprayer. Always use X-Stream Clean® branded replacement parts from the manufacturer.

• Do not use batteries that are wet or have been damaged.

• Inspect sprayer hose, power switch, and gun for damage or loose connections before each use.

• Do not lift or carry the sprayer by the hose or gun. Only carry by the handle.

• Only spray when the air is calm (no wind or air movement) to prevent chemical spray from drifting into unintended areas.

• Keep sprayer and all chemicals out of the reach of children.

• Remove chemicals and thoroughly clean the sprayer after each use. Failure to clean the sprayer may cause contamination of subsequent applications, will cause

premature spray wear, and void the sprayer warranty.

NOTES

• The sprayer may have residual water in it when rst opened. This is due to quality testing every sprayer undergoes before leaving our factory.

• THIS SPRAYER IS DESIGNED TO OPERATE WITH ONLY X-Stream Clean®BRANDED BATTERIES. ANY OTHER BATTERIES COULD CAUSE SERIOUS HARM OR INJURY

TO THE OPERATOR AND SERIOUS DAMAGE TO THE SPRAYER.

WARNING

This product contains chemicals, including lead, known to the state of California to cause birth defects and other reproductive harm. This product is designed to apply chemicals that may

be harmful and could cause serious personal injury if inhaled or brought into contact with the user.

Please read the following information carefully. User must read and understand entire manual before operating this sprayer. Improper use or failure to follow instructions could lead to

sprayer failure and possible serious injuries.

SAFETY

& PRECAUTION

SAFETY

• Use the sprayer and accessories in accordance with these instructions, taking into consideration the working conditions and the work to be performed. Use of this sprayer for

applications that it was not intended for could result in a hazardous situation.

• Keep handles and lift points dry, clean and free from oil and grease. Slippery handles and lift points do not allow for safe handling and control of the sprayer.

• Risk of re or explosion: Never use this sprayer with liquids such as gasoline, ethanol, methanol, or any other ammable or gas producing chemicals. Do not use sprayer around

sparks, ame, or smoke.

• Failure to adhere to these instructions may cause the chemicals to ignite, resulting in potential injury and damage to property.

• To reduce the risk of re, personal injury, and product damage from a short circuit, never immerse the sprayer, battery, or charger in uids. Do not place or store sprayer where it

could fall or be pulled into a tub or sink. Corrosive or conductive uids, such as seawater, certain industrial chemicals, and bleach or bleach containing products, etc., can cause a

short circuit.

• Electric shock hazard: Never spray toward electrical outlets.

• Spray area must be well ventilated to avoid hazardous fume build-up. Always refer to the product label of the chemical being used for safety instructions and proper use practices.

• Avoid spraying on windy days. Spraying in windy conditions could cause chemicals to be blown onto persons, plants, or objects that are not intended to be sprayed.

• Do not store chemicals in the tank. Chemicals can degrade seals and hoses. Drain and clean sprayer after each use. Failure to do so may void the sprayer warranty.

• Remove gloves before handling the battery pack. Chemicals may be damaging to plastics.

• Thoroughly inspect the interior, exterior, and all components of the sprayer before each use. Check for cracked and deteriorated hoses, leaks, clogged nozzles and missing or

damaged parts. If damaged, ensure the sprayer is repaired before use. Many accidents are caused by poor maintenance.

• Always remove the battery pack from the sprayer before performing any maintenance, storing or draining of the sprayer.

• Do not eat or smoke while handling or operating the sprayer. Refer to the product label of the chemical being used for user safety practices.

• Do not use the battery compartment to store the battery.

• Always use common sense and be cautious when using the sprayer. It is not possible to anticipate every situation that could result in a dangerous outcome. Do not use this

sprayer if you do not understand these operating instructions or if you feel the work is beyond your capability.

Please read the following information carefully. User must read and understand entire manual before operating this sprayer. Improper use or failure to follow instructions could lead to

sprayer failure and possible serious injuries.

SAFETY

& PRECAUTION

Please read the following information carefully. User must read and understand entire manual before operating this sprayer. Improper use or failure to follow instructions could lead to

sprayer failure and possible serious injuries.

DO NOT RETURN SPRAYER TO STORE, if you experience problems or have questions contact our Customer

Support Center, M-F 9am-5pm, EST at +1 803.339.2500, or email: [email protected], or nd more information

at xstreamclean.com/troubleshoot.

OPERATING

• Do not allow familiarity with products to make you careless. Remember that a single moment of carelessness is sufcient to cause serious injury.

• Always wear eye protection with side shields when handling or operating this sprayer. Failure to do so could result in serious injury from chemical contact or ying dirt or debris.

• The Lithium-ion battery pack can be used in temperatures down to 32ºF. When operating in cold temperatures, put the battery pack in the battery compartment and use the sprayer

in a light duty application. After about a minute the battery pack will warm up and begin operating normally.

• Always use the correct power setting for your application. Using the correct PSI and ow-rate will result in a safer and more thorough treatment. For calibration resources please

contact X-Stream Clean® technical support. (Note: Always refer to local, state, and federal laws and regulations regarding your application.)

• Do not use the sprayer if the power switch is not functioning correctly. Any power tool that cannot be controlled with the switch is dangerous and must be repaired.

• Remove battery before making any adjustments, changing accessories, or storing the sprayer. Disconnect the sprayer from the power source by removing the battery pack. These

preventative safety measures reduce the risk of starting the sprayer accidentally.

STORING

• Store sprayer out of reach of children and do not allow persons unfamiliar with the power tool or these instructions to operate the sprayer. Power tools are dangerous in the hands

of untrained users.

• Maintain sprayers and accessories. Check for misalignment or binding of moving parts, breakage of parts and any other condition that may affect sprayer operation.

When using chemicals, always wear protective

clothing, including respiratory masks, gloves, eye

protection, etc.

Do not dispose of Lithium-ion batteries with household

waste; recycle where proper facilities exist.

SAFETY

& PRECAUTION

WORK AREA

• Keep work area clean and well lit. Cluttered or dark areas invite accidents.

• Do not operate sprayer in explosive environments, such as in the presence of ammable liquids, gases or dust. Power tools can create sparks which may ignite the dust or fumes.

• Keep children and bystanders away while operating the sprayer. Distractions can cause you to lose control.

ELECTRICAL

• Avoid body contact with earthed or grounded surfaces, such as pipes, radiators, ranges and refrigerators. There is an increased risk of electric shock if your body is earthed or

grounded.

• Do not expose sprayer to rain or wet conditions. Water entering the electrical compartment of the sprayer will increase the risk of electric shock.

• Do not expose to rain; store indoors.

PERSONAL

• Stay alert, watch what you are doing and use common sense when operating the sprayer. A moment of inattention while operating power tools may result in serious personal injury.

• Use personal protective equipment. Always wear eye protection. Protective equipment such as a respiratory mask, non-skid safety shoes, hard hat or hearing protection used for

appropriate conditions will reduce the chance of personal injuries.

• Prevent unintentional starting. Ensure the switch is in the off-position before connecting the power source (battery pack), picking up, or carrying the sprayer.

• Do not overreach. Keep proper footing and balance at all times. This enables better control of the sprayer in unexpected situations.

• Dress properly. Do not wear loose clothing or jewelry. Keep your hair and clothing away from moving parts. Loose clothes, jewelry or long hair can be caught in moving parts.

• Do not let familiarity gained from frequent use of the sprayer allow you to become complacent and ignore tool safety principles. A careless action can cause severe injury within a

fraction of a second.

PLEASE NOTE

• To reduce static electricity buildup, consider wearing our Electrostatic Discharge (ESD) Grounded Foot Strap - XCAAKJ. See page 19.

Please read the following information carefully. User must read and understand entire manual before operating this sprayer. Improper use or failure to follow instructions could lead to

sprayer failure and possible serious injuries.

LET’S

GET

SPRAYING!

To take advantage of the 1-year Limited Warranty from WESSOL, LLC.

xstreamclean.com/register

Please read and follow this manual carefully to ensure that you get the

most out of your new sprayer. If you need assistance with the assembly

or operation of your sprayer, please don’t hesitate to contact WESSOL via

the support methods below:

xstreamclean.com

[email protected]

+1 803.339.2500

WHAT

YOUR SPRAYER IS CAPABLE OF

Scan the QR code to view the most

updated manual online!

or visit xstreamclean.com/operation-guides

The X-Stream Clean®Volt™ 1-Liter electrostatic sprayer is a highly efcient battery powered backpack sprayer for the

toughest cleaning, sanitation, and decontamination jobs.

Introducing the all-new Volt™ 1-Liter Electrostatic Backpack sprayer by X-Stream Clean®! Designed to make sanitation & decontamination projects faster and easier, the

Volt™ can spray for up to 6 hours with a lightweight spray gun. Simply ll up your sanitizing solution and strap on to start spraying!

X-STREAM CLEAN®VOLT™1-LITER ELECTROSTATIC SPECIFICATIONS

Model Number XCEAHV Polarity Positive Ions

Gun 12V Grounded Electrostatic Pump Type Diaphragm

Battery 18V / 5.2Ah Lithium-Ion Pressure 85 psi with included nozzles

Battery Charger 21V/2.5A Spray Distance Up to 12 feet

Coverage per Tank Up to 4,500 ft2Tank Capacity 1 liter / .25 gallons

Battery Cycle Life 1000 cycles Seals Viton™

Spray Time Up to 6 hours

* (Up to 4 hours on Turbo Boost™ Mode) Pump Life 1000 hours