WaterLogic WL900 Manuel utilisateur

WL900 Manual Page 13 – Revision: 1-21-2021

SERVICE REQUIREMENTS

WARNING! Read and understand the contents of this manual before attempting to

service WL900 Water Treatment System. Failure to follow the instructions in this

manual could result in death, serious personal injury, or severe property damage.

Only trained and qualified technicians should attempt to install, maintain, or service

Waterlogic Equipment.

1. Visually inspect all electrical and water connections for signs of wear or damage.

2. Ensure there is adequate (minimum of 2”) clearance around the WL900 Water and Ice

Machine and clean the condenser grill and compressor fan to provide efficient cooling

system operation.

3. Sanitize the cold tank, ambient tank, and ice-making area per instructions in the pre-

installation procedures.

WARNING! SANITIZER MAY CONTAIN HAZARDOUS CHEMICALS. Use of proper

personal protective equipment such as rubber gloves and eye protection are required.

4. Clean and sanitize external surfaces of the WL900 Water and Ice Machine. Use soap and

water or chemicals that are compatible with ABS plastic and will not damage or degrade the

product surfaces.

5. Remove and clean the Faucet on every service visit.

6. Change out filters every 6 months, or as needed.

WL900 Manual Page 14 – Revision: 1-21-2021

REPLACEMENT COMPONENTS (CONSUMABLES)

Component

WLCP Part No.

Frequency of Replacement

Sediment Filter 22-1835 Every 6 Months

Carbon Pre-Filter 22-1840 Every 6 Months

RO Membrane Filter 22-1845 Every 6 Months

Carbon Post Filter 22-1850 Every 6 Months

Hot Tank Assembly 22-1660 Every 5 Years depending on use

CAUTION! Use only Waterlogic Replacement parts that can be obtained from Waterlogic

or an Authorized Waterlogic Dealer, failure to do so will void the Warranty.

See Installation and Service Manual for additional information.

Hot Tank Service

Hot Tanks (with controls) must be replaced every 5 years.

Surface Cleaning

Clean on a regular basis with damp lint free cloth. Never use harsh chemicals (alcohol or acid

based) or abrasive agents on any part of the product to avoid damage. A mild cleaner such as

Simple Green or equivalent is recommended.

Tank Sanitization

Clean and sanitize the inside of the ambient tank, ice bin, and cold tank on an annual basis to

inhibit issues with biofilm and mold. This process is covered in the Installation section.

DISPOSAL

End of Life

At the end of this product’s life, ensure that it is disposed of in an environmentally friendly

manner which is fully compliant with all Federal/State/Local Requirements and Guidelines.

Do not dispose of this appliance with normal household or business waste.

WL900 Manual Page 15 – Revision: 1-21-2021

WL900 MAIN DRAWING AND PARTS LIST

Yellow = Consumables

Green = Recommended

spare parts

145

213

142

173

172

133

129

132

174

187

182

143

138

105

181

176

180

178

177

179

141

228

167

212

224

175

215

219

168

134

103

130

137

228

135

228

158

N/A

127

169

170

171

WL900 Manual Page 16 – Revision: 1-21-2021

110

111

107

229

N/A

225

118

101

132

N/A

186

185

184

154

N/A

157

N/A

116

113

117

115

114

157

209

210

WL900 ICE UNIT DRAWING AND PARTS LIST

WL900 Manual Page 17 – Revision: 1-21-2021

WLCP Part

No.

Description Part No Purchase as:

1 22-1000 Base Panel Assembly 91-2250-0 Assembly

2 22-1005 FM Valve 1/4”PTC 11-1624-1 Individually

3 22-1010 Gutter FM Valve 11-1346-0 Assembly

4 22-1015 Caster 21-0313-0 Assembly

5 22-1020 Tube End 3/8” 31-0867-0 Assembly

6 22-1025 Base Panel 21-0403-4 Assembly

7 22-1030 Leg: Nob-less 11-0351-0 Assembly

8 22-1035 Booster Pump 41-1494-1 Individually

9 22-1040 Solenoid V/V: Raw Water 41-0789-3 Individually

10 22-1045 Wire AC #3 with Fuse and

Fuse Holder 41-2030-0 Individually

11 22-1050 Fixed Clip: Capacitor 25-0056-1 Individually

WL900 Manual Page 18 – Revision: 1-21-2021

12 22-1055 Compressor :

Samsung MSA670C-D1G 41-1828-1 Individually

13 22-1060 Refrigerant Step Valve 41-1607-1 Individually

14 22-1065 Left Side Panel Assy 91-3415-0 Assembly

15 22-1070 Drain Connector Assy 11-2467-0 Assembly

16 22-1075 Bulk Head 1/4”PTC 11-0297-0 Assembly

17 22-1080 Left Side Panel 21-0717-1 Assembly

18 22-1085 Ball Valve 1/4”PTC 11-0527-0 Assembly

19 22-1090 Drain Tube Assy PVC 91-2696-0 Assembly

20 22-1095 Spring Clip 17mm

Diameter 21-0521-0 Assembly

21 22-1100 Tube PVC 77-1188-0 Assembly

22 22-1105 Ice Unit Assembly 91-2783-0 Assembly

23 22-1110 Unit Panel 21-0709-0 Assembly Not Shown

WL900 Manual Page 19 – Revision: 1-21-2021

24 22-1115 Hook Ice Basket 11-2216-0 Assembly

25 22-1120 Ice Unit 11-2468-1 Assembly

26 22-1125 Seal Unit 31-0932-0 Assembly

27 22-1130 Bushing Spiral 11-2991-0 Assembly

28 22-1135 Sensor: Ice Full Transmit 41-0524-1 Assembly

29 22-1140 O-Ring P10A 31-0327-0 Assembly

30 22-1145 Ice Full Transmitter 11-0631-1 Assembly

31 22-1150 Sensor: Ice Full Receive 41-1810-0 Assembly

32 22-1155 O-Ring P10A 31-0327-0 Assembly

33 22-1160 Ice Full Receiver 11-0630-0 Assembly

34 22-1165 Rubber Bracket EVA 31-0934-0 Individually

WL900 Manual Page 20 – Revision: 1-21-2021

35 22-1170 Ice Basket 11-2470-1 Individually

36 22-1175 Ice Separator 11-2471-1 Individually

37 22-1180 Distributor Gasket 31-0885-0 Individually

38 22-1185 Head Pump Circulator

Seal 31-0324-1 Individually

39 22-1190 Cold Sensor Seal 31-0035-1 Individually

40 22-1195 Cold Water Level Sensor 41-1795-0 Individually

41 22-1200 Cold Water Temp Sensor 41-1801-0 Individually

42 22-1205 Pipe Assy SUS 3/8” 91-2763-0 Assembly

43 22-1210 Straight PTC Fitting 3/8 11-0434-0 Assembly

44 22-1215 Tee Fitting 3/8” 11-0435-0 Assembly

45 22-1220 O-ring P9 31-0329-0 Assembly

WL900 Manual Page 21 – Revision: 1-21-2021

46 22-1225 Pipe SUS 3/8” 21-0713-2 Assembly

47 22-1230 Pipe Bucket In 11-2493-1 Assembly

48 22-1235 Circulation Pump Head 11-2224-0 Assembly

49 22-1240 Water Distributor

Assembly 91-2764-0 Assembly

50 22-1245 O-Ring P8 31-0328-0 Assembly

51 22-1250 Distributor 91-2546-0 Assembly

52 22-1255 Connector Elbow 11-2215-1 Assembly

53 22-1260 Ice Discharge Motor 41-1911-0 Individually

54 22-1265 Auger Coupler Connector 11-2930-0 Individually

55 22-1270 Auger Bushing Connector

SUS 11-2931-0 Individually

56 22-1275 Spiral Auger 21-0839-2 Individually

WL900 Manual Page 22 – Revision: 1-21-2021

57 22-1280 EPS Upper Unit 61-1475-0 Individually

58 22-1285 EPS Lower Unit 61-1476-1 Individually

59 22-1290 Auger Coupler 11-2206-0 Individually

60 22-1295 O-Ring AN012 31-0880-0 Individually

61 22-1300 Rubber Bracket EVA 31-0934-0 Individually

62 22-1305 Rear Bracket Assy EVA 91-2765-0 Assembly

63 22-1310 Rear Bracket EVA 11-2487-0 Assembly

64 22-1315 Rubber Bracket EVA 31-0934-0 Assembly

65 22-1320 Ice Tray Rotational

Coupler 11-2220-2 Individually

66 22-1325 EPS Motor Panel 61-1782-0 Individually

67 22-1330 Motor Link Gasket 31-0881-0 Individually

Autres manuels pour WL900

Autres manuels WaterLogic Système d'eau

WaterLogic

WaterLogic WL3FW Manuel utilisateur

WaterLogic

WaterLogic WL100 Manuel utilisateur

WaterLogic

WaterLogic 12-WL200CT Manuel utilisateur

WaterLogic

WaterLogic BLUPURA FIZZ 80 Manuel utilisateur

WaterLogic

WaterLogic BLUPURA FIZZ 80 Manuel utilisateur

WaterLogic

WaterLogic WL2FLT Manuel utilisateur

WaterLogic

WaterLogic WL800 - MAX II Manuel utilisateur

Manuels Système d'eau populaires d'autres marques

Spirotech

Spirotech SPIROVENT SUPERIOR S250 Manuel utilisateur

Culligan

Culligan Aqua-Cleer Aqua-Cleer Advanced Drinking Water... Manuel utilisateur

A.O. Smith

A.O. Smith Dura-Max AJH - 1000A - P Manuel utilisateur

Microline

Microline T.F.C.-4 Manuel

Eureka Forbes

Eureka Forbes Aquaguard Select Manuel utilisateur

Cetetherm

Cetetherm AquaEfficiency Manuel utilisateur

CB Tech

CB Tech CB-VOC Manuel utilisateur

Vaillant

Vaillant auroFLOW plus VPM 15 D Manuel utilisateur

resideo

resideo Braukmann HS10S Manuel utilisateur

Gude

Gude INOX 100/24 Manuel utilisateur

Mono

Mono Eco 1-60 Manuel

SpectraPure

SpectraPure Drinking Water Kit Manuel utilisateur

HydroCare

HydroCare Dual Action Manuel utilisateur

NEXT pool

NEXT pool STERILOR Cu/Ag Schéma de câblage

Alpha

Alpha SolarSmart 150 Guide de l'utilisateur

TA FRISTAR3 Manuel utilisateur

GÜDE

GÜDE HWA 800 K Manuel utilisateur

Rainfresh

Rainfresh UCS2 Manuel utilisateur