Velleman K1803 Manuel utilisateur

K1803

ILLUSTRATED ASSEMBLY MANUAL H1803IP'2

T ot al sold e r poi n ts: 29

Difficulty level: beginner 1 2 3 4 5 advanced

Thiskithasbeendevelopedaspre-modulefor

anumberofaudioapplicationswherethereis

insufficientinputsignal.Applicationsasa

microphonepre-amplifierorforlevelcorrection.

UNIVERSAL MONO PREAMPLIFIER

Specifications

 Power supply: 10-30VDC / 10mA.

 Output impedance: 1Kohm.

 Adjustable output level: max. 40dB.

 Frequency range: 20Hz to 20kHz ± 3dB.

 Max. input signal: 40mV.

 PCB dimensions: 30 x 40mm (1.2" x 1.57").

VELLEMAN NV

Legen Heirweg 33

9890 Gavere

Belgium Europe

www.ve llem an.be

www.velleman-kit.com

Assembly hints

1. Assembly (Skipping this can lead to troubles ! )

Ok, so we have your attention. These hints will help you to make this project successful. Read them carefully.

1.1 Make sure you have the right tools:

• A good quality soldering iron (25-40W) with a small tip.

• Wipe it oft en on a wet s p onge or cl oth, t o k ee p it cl ean; th en ap ply sol de r t o t he ti p, t o gi ve it a wet look . Th is is c al le d ‘thinning’ and will

protect the tip, and enables you to make good connections. When solder rolls off the tip, it needs cleaning.

• Thin raisin-core solder. Do not use any flux or grease.

• A diagonal cutter to trim excess wires. To avoid injury when cutting excess leads, hold the lead so they

cannot fly towards the eyes.

• Needle nose pliers, for bending leads, or to hold components in place.

• Small blade and Phillips screwdrivers. A basic range is fine.

For some projects, a basic multi-meter is required, or might be handy

1.2 Assembly Hints :

⇒Make sure the skill level matches your experience, to avoid disappointments.

⇒Follow the instructions carefully. Read and understand the entire step before you perform each operation.

⇒Perform the assembly in the correct order as stated in this manual

⇒Position all parts on the PCB (Printed Circuit Board) as shown on the drawings.

⇒Values on the circuit diagram are subject to changes.

⇒Values in this assembly guide are correct*

⇒Use the check-boxes to mark your progress.

⇒Please read the included information on safety and customer service

* Typographical inaccuracies excluded. Always look for possible last minute manual updates, indicated as ‘NOTE’ on a separate leaflet.

Assembly hints

1.3 Soldering Hints :

1- Mount the component against the PCB surface and carefully solder the leads

2- Make sure the solder joints are cone-shaped and shiny

3- Trim excess leads as close as possible to the solder joint

REMOVE THEM FROM THE TAPE ONE AT A TIME !

You will find the colour code for the resistances on our website: www.velleman.be

DO NOT BLINDLY FOLLOW THE ORDER OF THE

COMPONENTS ONTO THE TAPE. ALWAYS CHECK

THEIR VALUE ON THE PARTS LIST!

 R1 : 100K (1 - 0 - 4 - B)

 R2 : 100K (1 - 0 - 4 - B)

 R3 : 100K (1 - 0 - 4 - B)

 R4 : 100K (1 - 0 - 4 - B)

1. Resistors

R...

 IC1 : 8p

2. IC socket, Watch the po-

sition of the notch!

 AF IN (2 x)

 AF OUT (2x)

 Power (+)

 Power (-)

4. PCB pins

Constructi o n

 RV1 : 220K (250K)

6. Trim potentiometer

RV.. .

 C1 : 10µF

 C2 : 10µF

 C3 : 10µF

 C4 : 10µF

 C5 : 10µF

5. Electrolytic capacitors.

Watch the polarity !

C...

 IC1 : LM358

 Pay attention

to the

position of

the notch!

7. IC mounting

 R5 : 100K (1 - 0 - 4 - B)

 R6 : 100K (1 - 0 - 4 - B)

 R7 : 2K2 (2 - 2 - 2 - B)

3. Vertical resistors

R...

8. Connection

Conne c tion

 Connect a stabilized supply between 10 and 30V with the points “+” and “-” on the print.

 The input is connected on the points “AF IN”.

 The output is taken on the connection “AF OUT” and the ground “-”.

 To connect your in– and output you’d better use a screened wire, this to avoid interferences and rumble

 With the trimmer RV1 you can control the output signal between 0 and max.

Connec tion e xa mple

Dyna mic mi crop hone

Telephone pick up coil

...

MAX. 40mV

To : Amplifier, Mixing

panel, Tape recorder, ...

10 ... 30VDC

INPUT

OUTPUT

9. Schematic diagram.

Schematic diagram & PCB

100K

10µ

GND

10µ

SK1

AF IN

SK2

AF OUT

IC1A

IC1B

10µ

2K2

100K

RV1

220K

10. PCB

Modifications and typographical errors reserved

H1803IP - 2010 - ed.2

VELLEMAN NV

Legen Heirweg 33, 9890 Gavere

Belgium - Europe

5 410329 434977

Table des matières

Autres manuels Velleman Amplificateur

Velleman

Velleman HQ Power PA100U Manuel utilisateur

Velleman

Velleman VM113 Manuel utilisateur

Velleman

Velleman 8021 Manuel utilisateur

Velleman

Velleman K4005B Manuel utilisateur

Velleman

Velleman 8040 Manuel utilisateur

Velleman

Velleman K4040 Manuel utilisateur

Velleman

Velleman HQ Power VPA2100U1 Manuel utilisateur

Velleman

Velleman K4040 Manuel utilisateur

Velleman

Velleman VAS4A Manuel utilisateur

Velleman

Velleman K8060 Manuel utilisateur

Velleman

Velleman HQ Power VPA2350MB Manuel utilisateur

Velleman

Velleman ARDUINO VMA408 Manuel utilisateur

Velleman

Velleman K8084 Manuel utilisateur

Velleman

Velleman High-Q K2572 Manuel utilisateur

Velleman

Velleman HQ-POWER SAGIRA 100 Manuel utilisateur

Velleman

Velleman VM100 Manuel utilisateur

Velleman

Velleman HQ Power ONELINER 200 Manuel utilisateur

Velleman

Velleman HQ Power PA100U Manuel utilisateur

Velleman

Velleman K8040 Manuel utilisateur

Velleman

Velleman High-Q K2572 Manuel utilisateur

Velleman

Velleman HQ Power PAA04 Manuel utilisateur

Velleman

Velleman K8066 Manuel utilisateur

Velleman

Velleman K4003 Manuel utilisateur

Velleman

Velleman POWER BLOCK K8081 Manuel utilisateur

Manuels Amplificateur populaires d'autres marques

ASTRO

ASTRO HVO V40 P Manuel utilisateur

Marantz

Marantz SUPERSCOPE BLA-545 Instructions de montage

NAD

NAD CI980 Manuel utilisateur

Technics

Technics SE-CH770 Manuel utilisateur

Harman Kardon

Harman Kardon HK6300 Manuel utilisateur

NAD

NAD T975 Manuel utilisateur

McIntosh

McIntosh MA6850 Manuel utilisateur

Electro-Harmonix

Electro-Harmonix ENGLISH MUFF’N Manuel utilisateur

Viatron

Viatron Autrix Manuel utilisateur

GME

GME GA9800 Manuel utilisateur

Atlas

Atlas CP700 Manuel utilisateur

Roland

Roland KC-1000 Manuel utilisateur

Pyle

Pyle PFMRA350BW Manuel utilisateur

Advantage

Advantage S-250 Manuel utilisateur

IRT Electronics

IRT Electronics DVA-3007 Manuel utilisateur

Dimavery

Dimavery BA-100 Series Manuel utilisateur

Sony

Sony XM-S400D Manuel utilisateur

Schertler

Schertler ROY X Manuel utilisateur