Vego IQ 450 Manuel utilisateur

TABLE OF CONTENTS

Safety Information 1

Table of Contents 2

Notice 3

Scooter Diagram 4

Setup Guide 5-9

Charging Instructions 10

Pre-Ride Checklist 11

Trouble Shooting 12-13

Specifications 14

Maintenance Schedule 15-18

Limited Warranty 19-22

IQ 451 Manual 1/1/04 12:04 AM Page 1

YOUR INSURANCE POLICIES MAY

NOT PROVIDE COVERAGE FOR

ACCIDENTS INVOLVING THE USE OF

THIS SCOOTER. TO DETERMINE IF

COVERAGE IS PROVIDED, YOU

SHOULD CONTACT YOUR

INSURANCE COMPANY.

NOTICE

IQ 451 Manual 1/1/04 12:04 AM Page 2

SCOOTER DIAGRAM

•Throttle

•Handle

Bar Quick

Release

•Steer Tube

•Seat

•Seat Post

•Seat Height

Adjustment

Bolt

•Seat Tube

•Circuit

Breaker

• Charge Jack

•Black

Locking

Lever

•Quick

Release

Lever

IQ 451 Manual 1/1/04 12:04 AM Page 3

SETUP GUIDE

1Unfold Scooter

Install Handlebars

2CAUTION:

If you are not

familiar with bicy -

cle assembly tech -

niques please

bring your scooter

to a qualified

mechanic for prop -

er assembly and

tightening of all

components.

See next page

for further

instructions on

inserting

Handlebars.

(a) Loosen

quick release

lever.

(b) Pull the

gray locking

lever

upwards.

the scooter.

IQ 451 Manual 1/1/04 12:04 AM Page 4

SETUP GUIDE

3Adjust Handlebar Height

Tighten Handlebars

Tighten the quick release lever

to lock the handlebars in place. You

may need to adjust the tensioner nut

on the quick release lever to hold the

handlebar firmly in position. Check

for proper tightness by holding the

front wheel stationary inbetween

your feet while wiggling the handle-

bars. If the handlebars are loose

open the quick release lever, tighten

the tensioner nut, close the quick

release lever again and check again

for tightness.

Press

the small gold

button while

inserting the

handlebar into

the steer tube.

Make sure the

gold button is

locked into one

of the four pre-

set height set-

tings.

•Tensioner

Nut

IQ 451 Manual 1/1/04 12:04 AM Page 5

SETUP GUIDE

Fully insert the seat

assembly and tighten the seat

tube quick release lever at the

base of the seat tube. Adjust seat

height with supplied allen

wrench. Do not adjust seat height

at the base of the seat tube.

Caution: The seat tube must be

fully inserted into the scooter

frame. Leaving the seat tube par -

tially inserted in the frame could

cause the seat tube to dislodge

unexpectedly and cause serious

injury to the rider.

Securely

tighten the

folding mecha-

nism quick

release lever

and the seat

tube quick

release lever.

Remember to

adjust the ten-

sioner nuts if

necessary.

5Install Seat

6Tighten Quick Release Levers

IQ 451 Manual 1/1/04 12:04 AM Page 6

SET UP GUIDE

7Wear a Helmet

Turn Power On

Make sure to add air to

the tires before riding. Use the

pump included with your Vego

scooter to do this. Fasten the

pump head to the air valve on

the scooter wheels. Your scooter

rides best with 50 psi in the

tires. You should use a tire

pressure to check the exact

pressure regularly. In order to

have a safe ride and abide by

federal law you must wear a

helmet every time you ride your

Vego scooter. Please wear your

helmet every time you ride!

Turn the scooter power

on using the key. The power

gauge will illuminate indicat-

ing the scooter power is on.

Careful the scooter will start

moving once you twist the

throttle. All three lights will be

on when the battery is full. The

green light will go out at 70%

charge and the yellow light will

go out at 30% charge. Warning:

completely discharging the bat-

tery significantly reduces its

usable life.

• Key

Switch

•Power

Gauge

IQ 451 Manual 1/1/04 12:04 AM Page 7

1. Plug your smart charger into a regular household outlet.

Note: Your smart charger is equipped with a multivolt feature.

This allows you to plug the charger into an outlet in a foreign

country or any power source from 100 to 240volts AC.

2. Plug the charger into the charge port located on the

front of the scooter or if you wish remove the batteries for

charging you can plug the charger directly into the charge

port on the battery.

3. The light on the side of the charger will turn red indicat-

ing that the battery is charging. The charger will automati-

cally shut off and the light will turn green when the charge

is complete. Your scooter will be fully charged in 4-6 hours.

Note: It will take 8-10 hours to charge the batteries the first four

charges. This is part of the normal battery break-in period.

4. Recharge your scooter after every use. Leaving the bat-

teries empty overnight allows the acid in the cells to eat

away at components inside the batteries. Keeping the bat-

teries full when not in use will ensure property battery

lifetime.

CHARGING

•Charge

Port

•Charge Port

IQ 451 Manual 1/1/04 12:04 AM Page 8

Warning : If you do not perform these simple saftey checks before

each ride, you risk serious injury due to improperly maintained

equipment.

•Read and understand all safety instructions.

•Check all three quick release levers for tightness.

a.Handlebar quick release lever

b.Seat tube quick release lever

c. Folding mechanism quick release lever

•Check the brakes for proper function. If you can

pull the brake lever all the way down to the handle

grip you should have the brakes adjusted before rid-

ing.

•Make sure the tires are properly inflated.

•Charge batteries to 100% charged.

PRE-RIDE CHECKLIST

IQ 451 Manual 1/1/04 12:04 AM Page 9

•Battery charge jack is

not properly connected

to the charger. See

Charging section of

this manual for

instructions on con-

necting charger to bat-

tery. or

•Batteries have been

depleted beyond the

point which they can

be charged. Leave the

charger on for 24 hours

and check status again.

If batteries will not

accept charge after 24

hours see

www.govego.com for

battery pack order info.

•Sometimes the batter-

ies will take up to 24

hours to charge, espe-

cially during break-in

period (the first four

charges).

Solution

TROUBLE SHOOTING

Problem •Green Power light illu-

minates when charger is

plugged into household

outlet but red charge

light does not illumi-

natewhen charger is

plugged into battery.

•Red charging light illu-

minates but green

charge complete light

does not come on.

•Charge light does not

come on, scooter will

not recharge.

Symptom

IQ 451 Manual 1/1/04 12:04 AM Page 10

Autres manuels pour IQ 450

Table des matières

Autres manuels Vego Scooter

Vego

Vego IQ 450 Manuel utilisateur

Vego

Vego SX600 Manuel utilisateur

Manuels Scooter populaires d'autres marques

TEKTRO

TEKTRO CHEETAH Manuel utilisateur

Douglas

Douglas Vespa Sprint Guide d'installation

PLAYTIVE

PLAYTIVE AS-2448 Manuel utilisateur

Ebinger

Ebinger DONKEY XL Manuel utilisateur

Flyer

Flyer Mountain Guide de l'utilisateur

BackCountry eBikes

BackCountry eBikes Storm Manuel utilisateur

equipmed

equipmed FreeRoam II Manuel utilisateur

Yoto

Yoto Lion Manuel utilisateur

WESTHILL BIKES

WESTHILL BIKES LINK Manuel utilisateur

BAnff

BAnff eProdigy series Manuel utilisateur

Winther

Winther 475 Manuel utilisateur

Jetson

Jetson JBZL17 Manuel utilisateur

First Choice Mobility

First Choice Mobility Roma Medical Corella S741 Manuel utilisateur

Carrera

Carrera impel Manuel utilisateur

Afikim

Afikim Superlight SL-3 Manuel utilisateur

CareCo

CareCo ZOOM Manuel utilisateur

Douglas

Douglas Vespa G.S. Manuel utilisateur

Gazelle

Gazelle with BOSCH System Manuel utilisateur