UFREE SCOOTER FS-E11 Manuel utilisateur

UFREE SCOOTER www.scooter-manufacturer.com

ELECTRICSCOOTERFS–E11

UFREE SCOOTER www.scooter-manufacturer.com

INSTRUCTION

1. Safety caution

Please follow all the instructions mentioned in this manual and operate it

correctly.

1.1 To ensure your and other people's safety, please obey all traffic rules and

regulations, the user should ride it on the slow lane without taking

anybody.

1.1.2To ensure this scooter to have a long life, please read the manual

instructions before your operation to this scooter. Don't lend it to the

people who can't operate this scooter correctly.

1.1.3 Since the speed is fast, please be careful to use it in the snow or rain

weather, have a brake in advance when braking is necessary.

1.1.4 Without adult's supervision, minors mustn't operate this scooter.

1.2 Operation instruction

1.2.1 To check if the scooter is in good situation.

1.2.2To turn on the switch, the power light is on; it means the power is

connected.

1.2.3 To hold two handle bars, lift the kickstand off the ground, turn the

right accelerator at anticlockwise movement slowly, the scooter will

speed up.

1.2.4This scooter has the function of braking with power disconnect, when

riding, use the brake to disconnect the power if necessary, and ensure

to be safety.

1.2.5 When the volt of battery is lower 20.5V, the warning "beep" is

sounding, please stop riding and charge soon.

1.2.6When finishing ride, please turn off the switch and put down the

kickstand.

UFREE SCOOTER www.scooter-manufacturer.com

1.3 Charge instruction

1.3.1 To avoid damaging the battery, it is a must to use the charger ap-

pointed

to charge the battery.

1.3.2To confirm the charger input voltage in accordance with the socket

voltage, then connect, if the red and green light in the charger are

on, it means the power is connected. When the red light is becoming

green, indicate the battery is full.

1.3.3 Charge time is not more than 18 hours.

1.3.4To finish charge, please disconnect the power and unplug the charger

plug.

1.3.5 Before storage, please charge the scooter fully; also suggest to charge

the scooter per month.

1.4 Caution:

1.4.1 When riding on the smooth road at low windy speed, under the safety

condition, should not stop and start the scooter frequently.

1.4.2 To ensure the battery to be in good condition, please charge it in

time after your riding.

1.4.3 Should not start up the scooter frequently on the grade road.

2. Frame and instruction

2.1 This scooter is equipped with the battery of high power and lead-acid

free of maintenance.

The battery is located in the best place, make the gravity point low, and

insure the balance & safety to the rider.

2.2 This scooter is equipped with the electric driving control non-grade

HUOER accelerator system, which can protect the motor and battery

effectively and have a safety operation.

UFREE SCOOTER www.scooter-manufacturer.com

2.3 One special full automatic charger is used to this scooter, which can

avoid overcharge.

3. Main technical parameter and function index

3.1 Entire scooter specification:

Max speed: 12.5 miles/hour

Range per charge: 10 miles

Max load: 200 lbs

Incline capacity: approx. 4°

Net weight including battery: 45 lbs

Tyre: 12" pneumatic

3.2 Motor parameter:

Rated power: 250W-350W Rated volt: 24V

3.3 Battery:

Type: high power lead-acid storage battery free of maintenance Current:

12AH Voltage: 12Vx2

3.4 Charger:

Input volt: 110-220V Charge time: 6-8H

4. Assemble and adjust method

4.1 Assemble

4.1.1 Take out the scooter from the carton. (Figure 1)

4.1.2 Loose the flat bolt in the handle bar, remove the pin and

insert the connector to handle bar, then insert the pin shaft,

tighten the bolt, turn and tighten the folding unit to steady

the handle. (Figure 2)

UFREE SCOOTER www.scooter-manufacturer.com

4.1.3 Assemble the handle bar, put the accelerator correct location, fix it

with hex spanner. (Figure 3)

4.2 Assemble the saddle pipe, adjust and tighten. (Figure 4)

4.3 Adjust the rear brake

4.3.1 Adjust the rear adjusting bolt, tighten the brake bar to insure rear

wheel not turning, loose the brake bar, rear wheel turning freely.

(Figure 5)

4.3.2 If brake shoe (brake rubber) wear-tear too much, please replace it in

time.

4.4 Front wheel assembly, maintenance and service.

4.4.1 Loose the front shaft nut, remove the special washer to the hole

(O6.5), tighten front shaft nut, insure the front wheel in correct

location. (Figure 6)

4.5 Adjust the chain

4.5.1 Loose the rear shaft nut.

4.5.2 Loose the bolts on both sides, move the rear wheel backside, adjust

and make the chain running freely, tighten rear shaft nut. (Figure 7)

4.6 Assembly the rear wheel

4.6.1 Loose the rear shaft nut, put off the chain, take out the rear wheel.

4.6.2 Put the chain, adjust the bolts on both sides, finally, tighten the rear

shaft nut. (Figure 8)

5. Maintenance and service

5.1Daily inspection and service

UFREE SCOOTER www.scooter-manufacturer.com

5.1.1To make sure if the motor has the clash, noise etc. Abnormal

phenomenon while running, please repair it in time if

necessary.

5.1.2To check if all parts and connectors are fixed well.

5.1.3To check if the brake works well, any problem, please adjust or

replace.

5.1.4To check if all control and stay lines are perfect & flexible. Should

not

have any jamming phenomenon.

5.1.5To check the pressure of two wheels to be up to instruction.

5.1.6 Please clean the scooter after use.

5.2 Regular inspection and maintenance

Please fill the front & rear axle, chain wheel etc. with lubricant

regularly. Chart 1 term inspection and maintenance

Note: I-inspection, clean and adjust T: tighten A: adjust L: lubricate

300miles 600miles 1200miles 1800mile

Brake A I A I

Different control L I L I

Tyre I I I I

All the connect lines I I T I

Front fork and frame I I

UFREESCOOTER www.scooter-manufacturer.com

6. Troubleshooting

Please see the chart 2.

Chart 2: troubleshooting

Numb Troubles Reaso

Removin

1 The s

eed control 1. The batter

is Full

char

e the

order or the 2. The magnet steel Clamp it after

is lower than l0km/h. mechanism Replace the spring.

steel cable is loose.

3. The spring of

jamming or loosing

2 The electric 1. The batter

wire is Re

air and

rotating after 2. The magnet steel Clamp after

power supply. mechanism Repair and replace;

steel cable is loose. Replace the blown

3. The wire plug of Reconnect.

machinery is loose

4. Burn out the blown

5. Lead wire of the

broken.

3 The drivin

distance 1. The t

e is short of Full

char

e the

of the requirement 2. Failure of the Repair the charger;

charged once. 3. Failure of Change the

4. The battery is aged Change the battery;

5. Charging and Continually using

new battery is battery, charge and

6. Many ascents, low it more than 10

heavy wind, the

road surface isn't

weight is over 200

Over many brake

4 The char

er can't

e 1. The char

hten the ru

-in;

2. Fuse burned out. Change the blown

3. The lead of the Reconnect.

5 No dis

of the 1. Start the electric Re

lace a new

charging state of the see if the battery Reconnect and

and the electric than 20.5V;

can't start. 2. The battery bus is

UFREE SCOOTER www.scooter-manufacturer.com

Switch panel

Turning light switch

Horn switch

Head light

Accelerator

Saddle

Brake

UFREE SCOOTER www.scooter-manufacturer.com

E-SCOOTER

Figure 2

Figure 3

Figure 5

Figure 4

Table des matières

Autres manuels UFREE SCOOTER Scooter

UFREE SCOOTER

UFREE SCOOTER FS-E35 Manuel du propriétaire

UFREE SCOOTER

UFREE SCOOTER FS-E31 Manuel utilisateur

UFREE SCOOTER

UFREE SCOOTER FS-E12 Manuel utilisateur

UFREE SCOOTER

UFREE SCOOTER FS-E20B Manuel utilisateur

UFREE SCOOTER

UFREE SCOOTER FS-E20C Manuel utilisateur

UFREE SCOOTER

UFREE SCOOTER FS-E07 Manuel du propriétaire

Manuels Scooter populaires d'autres marques

TEKTRO

TEKTRO CHEETAH Manuel utilisateur

Douglas

Douglas Vespa Sprint Guide d'installation

PLAYTIVE

PLAYTIVE AS-2448 Manuel utilisateur

Ebinger

Ebinger DONKEY XL Manuel utilisateur

Flyer

Flyer Mountain Guide de l'utilisateur

BackCountry eBikes

BackCountry eBikes Storm Manuel utilisateur

equipmed

equipmed FreeRoam II Manuel utilisateur

Yoto

Yoto Lion Manuel utilisateur

WESTHILL BIKES

WESTHILL BIKES LINK Manuel utilisateur

BAnff

BAnff eProdigy series Manuel utilisateur

Winther

Winther 475 Manuel utilisateur

Jetson

Jetson JBZL17 Manuel utilisateur

First Choice Mobility

First Choice Mobility Roma Medical Corella S741 Manuel utilisateur

Carrera

Carrera impel Manuel utilisateur

Afikim

Afikim Superlight SL-3 Manuel utilisateur

CareCo

CareCo ZOOM Manuel utilisateur

Douglas

Douglas Vespa G.S. Manuel utilisateur

Gazelle

Gazelle with BOSCH System Manuel utilisateur