Trane GEHB018 Manuel utilisateur

Crankcase Heater

Wiring

For KIT14712 and KIT14718

Models: GEHB018, GEVB018, KIT14712, KIT14718

Installation

PART-SVN100A-EN

2 Crankcase Heater Wiring PART-SVN100A-EN

Installation

Literature change history

PART-SVN100A-EN (October 2006) manual first release.

Warnings and Cautions

Instructions

 WARNING

Hazardous Voltage w/Capacitors!

Disconnect all electric power, including remote disconnects and discharge all

motor start/run capacitors before servicing. Follow proper lockout/tagout

procedures to ensure the power cannot be inadvertently energized. Verify

with an appropriate voltmeter that all capacitors have discharged. Failure to

disconnect power and discharge capacitors before servicing could result in

death or serious injury.

Note: For additional information regarding the safe discharge of capacitors,

see PROD-SVB06A-EN or PROD-SVB06A-FR.

This KIT includes a relay, wiring assembly, and crankcase (sump) heater. The

following information and wiring digram shown in Figure 1 (p. 3) should be

used to install this device.

HTR06811 - Crankcase heater, 30 Watt, 5.07” diameter, 208/230 Vac or

HTR06851 - Crankcase heater, 30 Watt, 5.07” diameter, 265 Vac

and

RLY01357 - DPDT relay, 24 Vac coil 50/60 HZ, 3 A 277 Vac pilot duty contacts

WIR004682 - Wire harness for adding crankcase heater

1Turn off all power sources to the unit. Follow proper lock out and tag out

procedures.

2Install mechanical components, heater and relay.

NOTICE: Warnings and Cautions appear at appropriate sections

throughout this literature. Read these carefully.

WARNING: Indicates a potentially hazardous situation which, if not

avoided, could result in death or serious injury.

 CAUTION: Indicates a potentially hazardous situation which, if not

avoided, may result in minor or moderate injury. It may also be used to

alert against unsafe practices.

CAUTION: Indicates a situation that may result in equipment or prop-

erty-damage only accidents.

PART-SVN100A-EN Crankcase Heater Wiring 3

Installation

3Connect new blue wire 3 to incoming compressor power and terminal 1

on the new relay

4Connect new black wire 4 to the second incoming compressor power and

terminal 4 on the new relay.

5Connect crankcase heater wires to terminals 2 and 5 on the new relay.

6Connect the new relay coil (double tab terminals) to the terminals 4 and 6

on the customer terminal block. Use wires yellow 1 and orange 2.

Figure 1. Crankcase heater wiring diagram

Crankcase Heater

Relay

Wire relay terminals 1 & 4

to the compressor

contactor incoming power

Connect heater ground wire

to the unit chassis ground

Connect Relay coil leads to

terminal 4 & 6 on the

customer terminal block. The

relay coil terminals have

double tabs.

Connect heater leads

to relay terminals 2 & 5

Installation

Tr a n e

A business of American Standard Corporation

www.trane.com

For more information, contact your local Trane

office or e-mail us at comfor[email protected]

Trane has a policy of continuous product data and product improvement and reserves the right to

change design and specifications without notice. Only qualified technicians should perform the

installation and servicing of equipment referred to in this bulletin.

Literature Order Number PART-SVN100A-EN

File Number SV-SP-PART-SVN100A-EN-1006

Supersedes New

Stocking Location Electronic only

Ce manuel convient aux modèles suivants

Autres manuels Trane Pompe à chaleur

Trane

Trane Ultra-Low NOx Series Instructions de montage

Trane

Trane RAUS 040 Manuel du propriétaire

Trane

Trane 5TTR4018A Manuel utilisateur

Trane

Trane Axiom GET024-036 Instructions d'installation et d'utilisation

Trane

Trane ComfortLink 4TWZ0060A1000A Manuel utilisateur

Trane

Trane Axiom GEHE006 Instructions d'installation et d'utilisation

Trane

Trane 5TTR3018-060 Manuel utilisateur

Trane

Trane Horizon OABE/F Instructions d'installation et d'utilisation

Trane

Trane 4TTR4018L Instructions de montage

Trane

Trane 4TTR3 Instructions d'installation

Trane

Trane LIFT 162-P-1204-P Manuel du propriétaire

Trane

Trane 2/4WCC30 Series Instructions de montage

Trane

Trane WEATHERTRON 4TWX6 Instructions d'installation

Trane

Trane Horizon OABE/F Series Instructions d'installation et d'utilisation

Trane

Trane Axiom EXHF006 Instructions d'installation et d'utilisation

Trane

Trane WEATHERTRON 4TWX6 Instructions de montage

Trane

Trane 4TTX7 Manuel utilisateur

Trane

Trane GEHE 072-180 Instructions d'installation et d'utilisation

Trane

Trane GETB Manuel utilisateur

Trane

Trane 4TWR6 Manuel utilisateur

Trane

Trane Voyager PKGP-PRC001-EN Manuel utilisateur

Trane

Trane Thermo King T-590 Series Manuel utilisateur

Trane

Trane 4TWR3 Instructions de montage

Trane

Trane 4WCC4024E1000A Manuel utilisateur

Manuels Pompe à chaleur populaires d'autres marques

MICROWELL

MICROWELL HP 1000 GREEN Manuel utilisateur

Sanyo

Sanyo SAP120FCH Manuel utilisateur

Daikin

Daikin EHYHBH05AA Manuel utilisateur

Panasonic

Panasonic WH-SDF03E3E5 Mode d’emploi

Bryant

Bryant 544B Manuel utilisateur

Airxcel

Airxcel 45000 Series Manuel

Mitsubishi Electric

Mitsubishi Electric PUZ-SWM60VAA Manuel utilisateur

Dimplex

Dimplex LI 16I-TUR Guide de l'utilisateur

Carrier

Carrier WSHP Open v3 Guide de configuration rapide

TGM

TGM CTV14CN018A Manuel utilisateur

Carrier

Carrier 38MGQ Series Manuel utilisateur

Kokido

Kokido K2O K880BX/EU Guide de dépannage

Viessmann

Viessmann VITOCAL 300-G PRO Type BW 2150 Guide rapide

Carrier

Carrier 48EZN Manuel utilisateur

Viessmann

Viessmann KWT Vitocal 350-G Pro Series Mode d'emploi

Ariston

Ariston NIMBUS Manuel utilisateur

Weishaupt

Weishaupt WWP L 7 Guide de l'utilisateur

GE Zoneline AZ85H09EAC Manuel utilisateur