Toro 72085 Wheel Horse 267H Manuel utilisateur

Operator’s Manual

IMPORTANT: Read this manual carefully. It contains information about your

safety and the safety of others. Also become familiar with the controls and

their proper use before you operate the product.

FORM NO. 3319–612

Wheel Horse

267H

Lawn & Garden

Tractor

Model No. 72085 – 8900001 & Up

The Toro Company – 1997

Introduction

Thank you for purchasing a Toro product.

All of us at Toro want you to be completely satisfied

with your new product, so feel free to contact your

local Authorized Service Dealer for help with service,

genuine replacement parts, or other information you

may require.

Whenever you contact your Authorized Service

Dealer or the factory, always know the model and

serial numbers of your product. These numbers will

help the Service Dealer or Service Representative

provide exact information about your specific

product. You will find the model and serial number

plate located in a unique place on the product as

shown below.

1202

1. Model and Serial Number Plate (under the seat)

For your convenience, write the product model and

serial numbers in the space below.

Model No:

Serial No.

Read this manual carefully to learn how to operate

and maintain your product correctly. Reading this

manual will help you and others avoid personal injury

and damage to the product. Although we design,

produce and market safe, state-of-the-art products,

you are responsible for using the product properly

and safely. You are also responsible for training

persons, who you allow to use the product, about safe

operation.

The warning system in this manual identifies

potential hazards and has special safety messages that

help you and others avoid personal injury, even death.

DANGER, WARNING and CAUTION are signal

words used to identify the level of hazard. However,

regardless of the hazard, be extremely careful.

DANGER signals an extreme hazard that will cause

serious injury or death if the recommended

precautions are not followed.

WARNING signals a hazard that may cause serious

injury or death if the recommended precautions are

not followed.

CAUTION signals a hazard that may cause minor or

moderate injury if the recommended precautions are

not followed.

Two other words are also used to highlight

information. “Important” calls attention to special

mechanical information and “Note” emphasizes

general information worthy of special attention.

The left and right side of the machine is determined

by sitting on the seat in the normal operator’s

position.

The engine exhaust from this product

contains chemicals known to the State of

California to cause cancer, birth defects,

or other reproductive harm.

Contents

Page

Safety 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Safe Operating Practices 2. . . . . . . . . . . . . .

Slope Chart 5. . . . . . . . . . . . . . . . . . . . . . . . .

Safety and Instruction Decals 7. . . . . . . . . .

Gasoline and Oil 8. . . . . . . . . . . . . . . . . . . . . . . .

Recommended Gasoline 8. . . . . . . . . . . . . .

Stabilizer/Conditioner 8. . . . . . . . . . . . . . . .

Filling the Fuel Tank 8. . . . . . . . . . . . . . . . .

Check Engine Oil Level 8. . . . . . . . . . . . . . .

Operation 9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Think Safety First 9. . . . . . . . . . . . . . . . . . .

Controls 9. . . . . . . . . . . . . . . . . . . . . . . . . . .

Parking Brake 9. . . . . . . . . . . . . . . . . . . . . . .

Starting and Stopping the Engine 10. . . . . . .

Operating the Power Take Off (PTO) 11. . . .

The Safety Interlock System 11. . . . . . . . . . .

Indicator Control Module 12. . . . . . . . . . . . .

Hourmeter 12. . . . . . . . . . . . . . . . . . . . . . . . .

Driving Forward or Backward 13. . . . . . . . . .

Stopping the Machine 13. . . . . . . . . . . . . . . .

Attachment Lift Lever 14. . . . . . . . . . . . . . . .

Adjusting Dial-A-Height 14. . . . . . . . . . . . . .

Positioning the Seat 15. . . . . . . . . . . . . . . . . .

Page

Headlights 15. . . . . . . . . . . . . . . . . . . . . . . . .

Positioning the Tilt Steering Wheel 15. . . . . .

Using the Cruise Control 16. . . . . . . . . . . . . .

Pushing the Machine by Hand 16. . . . . . . . . .

Maintenance 17. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Service Interval Chart 17. . . . . . . . . . . . . . . .

Air Cleaner 18. . . . . . . . . . . . . . . . . . . . . . . . .

Engine Oil 20. . . . . . . . . . . . . . . . . . . . . . . . .

Spark Plug 22. . . . . . . . . . . . . . . . . . . . . . . . .

Greasing and Lubrication 23. . . . . . . . . . . . . .

Tire Pressure 23. . . . . . . . . . . . . . . . . . . . . . . .

Brake 24. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel Tank 25. . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel Filter 26. . . . . . . . . . . . . . . . . . . . . . . . . .

Front Wheel Toe-In 27. . . . . . . . . . . . . . . . . .

Transaxle Fluid 28. . . . . . . . . . . . . . . . . . . . . .

Fuse 28. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Headlights 29. . . . . . . . . . . . . . . . . . . . . . . . .

Battery 30. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Wiring Diagram 33. . . . . . . . . . . . . . . . . . . . .

Cleaning and Storage 34. . . . . . . . . . . . . . . . .

Troubleshooting 35. . . . . . . . . . . . . . . . . . . . . . . . .

Warranty Back Cover. . . . . . . . . . . . . . . . . . . . . . . . . .

Safety

This machine meets or exceeds the B71.1–1990

specifications of the American National Standards

Institute, in effect at the time of production.

However, improper use or maintenance by the

operator or owner can result in injury. To reduce

the potential for injury, comply with these safety

instructions and always pay attention to the safety

alert symbol, which means CAUTION,

WARNING, or DANGER—“personal safety

instruction.” Failure to comply with the

instruction may result in personal injury or death.

Safe Operating Practices

This product is capable of amputating hands and feet

and throwing objects. Always follow all safety

instructions to avoid serious injury or death.

POTENTIAL HAZARD

•Engine exhaust contains carbon monoxide,

which is an odorless, deadly poison.

WHAT CAN HAPPEN

•Carbon monoxide can kill you and is also

known to the State of California to cause

birth defects.

HOW TO AVOID THE HAZARD

•Do not run engine indoors or in an enclosed

area.

General Operation

1. Read, understand, and follow all instructions in

the operator’s manual and on the machine before

starting.

2. Allow only responsible adults who are familiar

with the instructions to operate the machine.

3. Clear the area of objects such as rocks, toys,

wire, etc., which could be picked up and thrown

by the blade.

4. Be sure the area is clear of other people before

mowing. Stop the machine if anyone enters the

area.

5. Never carry passengers.

6. Do not mow in reverse unless absolutely

necessary. Always look down and behind before

and while backing.

7. Be aware of the mower discharge direction and

do not point it at anyone. Do not operate the

mower without either the entire grass catcher or

the guard in place.

8. Slow down before turning. Sharp turns on any

terrain may cause loss of control.

9. Never leave a running machine unattended.

Always turn off blades, set parking brake, stop

engine, and remove key before dismounting.

10. Turn off blades when not mowing.

11. Keep hands, feet, hair and loose clothing away

from attachment discharge area, underside of

mower and any moving parts while engine is

running.

12. Stop the engine before removing the grass

catcher or unclogging the chute.

Safety

13. Mow only in daylight or good artificial light.

14. Do not operate the machine while under the

influence of alcohol or drugs.

15. Watch for traffic when operating near or crossing

roadways.

16. Use extra care when loading or unloading the

machine onto a trailer or truck.

17. Do not touch equipment or attachment parts

which may be hot from operation. Allow to cool

before attempting to maintain, adjust or service.

Slope Operation

Slopes are a major factor related to loss-of-control

and tip-over accidents, which can result in severe

injury or death. All slopes require extra caution. If

you cannot back up the slope or if you feel uneasy on

it, do not mow it.

•Mow up and down slopes greater than 5°, not

across.

•Mow downhill only on slopes above 10°, never

mow uphill. If a steep slope must be ascended,

back up the hill, and drive forward down the hill,

keeping the machine in gear.

•Remove obstacles such as rocks, tree limbs, etc.

from the mowing area. Watch for holes, ruts or

bumps, as uneven terrain could overturn the

machine. Tall grass can hide obstacles.

•Use slow speed. Choose a low gear so that you

will not have to stop or shift while on the slope.

•Follow the manufacturer’s recommendations for

wheel weight or counterweights to improve

stability.

•Use extra care with grass catchers or other

attachments. These can change the stability of

the machine.

•Keep all movement on slopes slow and gradual.

Do not make sudden changes in speed or

direction.

•Avoid starting or stopping on a slope. If tires

lose traction, disengage the blades and proceed

slowly straight down the slope.

DO NOT

•Do not operate machine on hillsides or slopes

exceeding 15°.

•Avoid turning on slopes. If you must turn, turn

slowly and gradually downhill, if possible.

•Do not mow near drop-offs, ditches, or

embankments. The machine could suddenly turn

over if a wheel goes over the edge of a cliff or

ditch, or if an edge caves in.

•Do not mow on wet grass. Reduced traction

could cause sliding.

•Do not try to stabilize the machine by putting

your foot on the ground.

•Do not use a grass catcher on steep slopes.

Heavy grass bags could cause loss of control or

overturn the machine.

Safety

Children

Tragic accidents can occur if the operator is not alert

to the presence of children. Children are often

attracted to the machine and the mowing activity.

Never assume that children will remain where you

last saw them. The following requirements must be

followed to prevent injury to children.

1. Keep children out of the mowing area and under

the watchful care of another responsible adult.

2. Be alert and turn the machine off if children

enter the area.

3. Before and while backing, look behind and down

for small children.

4. Never carry children. They may fall off and be

seriously injured or interfere with safe machine

operation.

5. Never allow children to operate the machine.

6. Use extra care when approaching blind corners,

shrubs, trees, the end of a fence or other objects

that may obscure vision.

Service

1. Stop the engine and disconnect spark plug

wire(s) before performing any service, repairs,

maintenance or adjustments.

2. Use extra care when handling gasoline and other

fuels. They are flammable and vapors are

explosive.

A. Use only an approved container.

B. Never remove the gas cap or add fuel when

the engine is running. Allow the engine to

cool before refueling. Do not smoke.

C. Never refuel the machine indoors.

D. Never store the machine or fuel container

inside where there is an open flame, such as

near a water heater or furnace.

3. Never run a machine inside a closed area.

4. Keep nuts and bolts tight, especially the blade

attachment bolts. Keep equipment in good

condition.

5. Never tamper with safety devices. Check safety

systems for proper operation before each use.

6. Keep the machine free of grass, leaves, or other

debris build-up. Clean up oil or fuel spillage.

Allow the machine to cool before storing.

7. Stop and inspect the equipment if you strike an

object. Repair, if necessary, before restarting.

8. Grass catcher components are subject to wear,

damage and deterioration, which could expose

moving parts or allow objects to be thrown.

Frequently check components and replace with

manufacturer’s recommended parts, when

necessary.

9. Mower blades are sharp and can cut. Wrap the

blade(s) or wear gloves, and use extra caution

when servicing them.

10. Use only genuine replacement parts to ensure

that original standards are maintained.

11. Check brake operation frequently. Adjust and

service as required.

12. Battery acid is poisonous and can cause burns.

Avoid contact with skin, eyes and clothing.

Protect your face, eyes and clothing when

working with a battery.

13. Battery gases can explode. Keep cigarettes,

sparks and flames away from battery.

Safety

Slope Chart

Read all safety instructions on pages 2–4.

Safety

Safety and Instruction Decals

Safety decals and instructions are easily visible to the operator and are located near

any area of potential danger. Replace any decal that is damaged or lost.

ON STEERING TOWER

(Part No. 93–0302)

ON DASH

LEFT SIDE

(Part No. 92–6720)

ON DASH

RIGHT SIDE

(Part No. 92–6721)

ON FRAME

RIGHT REAR

(Part No. 92–6726)

ON FRAME

CENTER REAR

(Part No. 92–6727)

ON FRAME STEP

(Part No. 92–6725)

ON LIFT LEVER

(Part No. 112168)

ON DIAL-A-HEIGHT KNOB

(Part No. 78–9740)

ON FRAME STEP

(Part No. 92–8946)

DASH INDICATOR PANEL

(Part No. 92–6973)

ON STEERING TOWER

(Part No. 83–6620)

Gasoline and Oil

Recommended Gasoline

Use UNLEADED Regular Gasoline suitable for

automotive use (85 pump octane minimum). Leaded

regular gasoline may be used if unleaded regular is

not available.

IMPORTANT: Never use methanol, gasoline

containing methanol, or gasohol containing

more than 10% ethanol because the fuel

system could be damaged. Do not mix oil with

gasoline.

POTENTIAL HAZARD

•In certain conditions gasoline is extremely

flammable and highly explosive.

WHAT CAN HAPPEN

•A fire or explosion from gasoline can burn

you, others, and cause property damage.

HOW TO AVOID THE HAZARD

•Use a funnel and fill the fuel tank outdoors,

in an open area, when the engine is cold.

Wipe up any gasoline that spills.

•Do not fill the fuel tank completely full.

Add gasoline to the fuel tank until the level

is 1/4” to 1/2” (6 mm to 13 mm) below the

bottom of the filler neck. This empty space

in the tank allows gasoline to expand.

•Never smoke when handling gasoline, and

stay away from an open flame or where

gasoline fumes may be ignited by a spark.

•Store gasoline in an approved container

and keep it out of the reach of children.

Never buy more than a 30-day supply of

gasoline.

Stabilizer/Conditioner

Add the correct amount of gas stabilizer/conditioner

to the gas. Using a stabilizer/conditioner that is

isopropyl-based in the machine:

•Keeps gasoline fresh during storage

•Cleans the engine while it runs

•Eliminates gum-like buildup in the fuel system,

which causes hard starting

IMPORTANT: Never use fuel additives

containing methanol or ethanol.

Filling the Fuel Tank

1. Shut the engine off and raise the seat.

2. Clean around the fuel tank cap and remove the

cap. Use a funnel and add unleaded regular

gasoline to the fuel tank, until the level is 1/4 to

1/2 inch (6 mm to 13 mm) below the bottom of

the filler neck. This space in the tank allows

gasoline to expand. Do not fill the fuel tank

completely full.

3. Install the fuel tank cap securely. Wipe up any

gasoline that may have spilled.

4. Low fuel level is viewed

through frame in rear of machine.

Check Engine Oil Level

Before you start the engine and use the machine,

check the oil level in the engine crankcase; refer to

Checking Oil Level, page 20.

Table des matières

Autres manuels Toro Tondeuse à gazon

Toro

Toro 2210 Manuel utilisateur

Toro

Toro 21848 Manuel utilisateur

Toro

Toro 22177 Manuel utilisateur

Toro

Toro 58620 Manuel utilisateur

Toro

Toro 74656 Manuel utilisateur

Toro

Toro TimeMaster 21199 Manuel utilisateur

Toro

Toro Greensmaster 3000 Series Manuel utilisateur

Toro

Toro 78281 Manuel utilisateur

Toro

Toro TimeCutter Z 79214 Manuel utilisateur

Toro

Toro 03721 Manuel utilisateur

Toro

Toro 14AQ81RP748 Manuel utilisateur

Toro

Toro Reelmaster Edge Series Manuel utilisateur

Toro

Toro 20340 Manuel utilisateur

Toro

Toro MX 5000 Manuel utilisateur

Toro

Toro ProLine 30180 Manuel utilisateur

Toro

Toro TimeCutter SWX 4250 Manuel utilisateur

Toro

Toro Recycler 20017 Manuel utilisateur

Toro

Toro 30551 Manuel utilisateur

Toro

Toro GrandStand 74568TE Manuel utilisateur

Toro

Toro 74179 Manuel utilisateur

Toro

Toro 20959 Manuel utilisateur

Toro

Toro eTimeMaster 21491 Manuel utilisateur

Toro

Toro Greensmaster TriFlex 3300 Manuel utilisateur

Toro

Toro 74650 Manuel utilisateur

Manuels Tondeuse à gazon populaires d'autres marques

RHINO

RHINO 1958 Manuel utilisateur

Wolf Garten

Wolf Garten Compact plus 40 B Manuel utilisateur

Cub Cadet

Cub Cadet LTX 1045 Manuel utilisateur

Craftsman

Craftsman 917.378461 Manuel utilisateur

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Manuel utilisateur

Challenge

Challenge CH18V2 Instructions de fonctionnement

TALEN TOOLS

TALEN TOOLS AVR HGM30 Manuel utilisateur

DEWEZE

DEWEZE ATM-725 Manuel d'utilisation

Weed Eater

Weed Eater 180083 Manuel utilisateur

Husqvarna

Husqvarna Poulan Pro PP185A42 Manuel utilisateur

Better Outdoor Products

Better Outdoor Products Quick Series Manuel utilisateur

Cub Cadet

Cub Cadet 23HP Z-Force 60 Manuel d'utilisation

MTD

MTD 795, 792, 791, 790 Manuel utilisateur

Dennis

Dennis FT 610 Manuel utilisateur

AIRFORCE

AIRFORCE F-15 Gen 3 Manuel utilisateur

MTD

MTD 126-220-000 Manuel utilisateur

Stihl

Stihl RMA 443 PV Manuel utilisateur

Yard-Man

Yard-Man 3700-0 Manuel utilisateur