Tera Gear 13 01 3007TG Guide de démarrage rapide
1
Loblaws Inc.,
1 President’s Choice Circle,
Brampton, Ontario
L6Y 5S5
WARNING
You must read this owner’s guide before operating
your gas grill. Failure to follow these instructions
could result in re or explosion that could cause
property damage, personal injury or death.
For your safety: This gas appliance is designed
for outdoor use only and shall not be used in a
building, garage or any other enclosed area.
Do not use in or on boats or recreational vehicles.
WARNING
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
damage to property.
2. Read the assembly, installation, operation and
maintenance thoroughly before assembling,
installing, or servicing the equipment.
3. Failure to follow these instructions could result
in re or explosion which could cause property
damage, personal injury or death.
If the outdoor cooking gas appliance is not in use,
the gas must be turned o at the supply cylinder(s).
Storage of an outdoor cooking gas appliance
indoors is permissible only if the cylinder(s) is (are)
disconnected and removed from the outdoor
cooking gas appliance.
Cylinders must be stored outdoors out of the reach of
children and must not be stored in a building, garage
or any other enclosed area.
Stainless Steel 60,000BTU BBQ
propane gas
assembly instructions and
owner’s guide
MODEL NUMBER:
13 01 3007TG
SERIAL NUMBER:
propane
TG3007 LP U&C-2012 FA.indd 1 12-09-26 4:06 PM
2
THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open the lid.
4. If odor persists, keep away from the appliance and
immediately call your gas supplier or the fire department.
DO NOT RETURN THE BARBECUE TO STORE.
For assistance, call Customer Service at 1-800-737-8815
Monday to Friday from 9 a.m. to 5 p.m. Eastern Standard Time.
WARNING:
Do not ignite this gas appliance without rst reading the operating instructions in this manual.
Save these instructions for future reference.
NOTICE TO INSTALLER:
These instructions must be left with the owner and the owner should keep them for future reference.
NOTICE TO CONSUMER:
Retain this manual for future reference.
WARNING:
Follow all leak check procedures carefully in this manual prior to barbecue operation.
Do this even if the barbecue was dealer-assembled.
Do not repair or replace any parts of the grill unless specically recommended in this manual or by
customer service. All other service and maintenance should be performed by a qualied technician.
WARNING:
1. Do not store or use gasoline or other ammable liquids, vapours or materials in the vicinity of this or
any other appliance.
2. A LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
Safety Instructions
TG3007 LP U&C-2012 FA.indd 2 12-09-26 4:06 PM
3
BEFORE USING THIS GRILL PERFORM THE SAFETY CHECK.
1. Read and understand the manual.
2. Perform the leak test as found on page 32.
3. Ensure that the barbecue is not positioned under unprotected construction, against a wall, near
aluminum or vinyl siding, windows, fencing or anything else that may be ammable.
4. Inspect and clean burner tubes to avoid ash res caused by spider webs and other blockages.
See page 34 for cleaning instructions.
5. Avoid dangerous grease res by cleaning out the grease cup and grease tray. See instructions
on page 35.
6. Before opening the gas supply, ensure that the lid is open, burner knobs are in the o position,
gas is turned o and the regulator is properly attached to the tank.
7. Follow the proper lighting procedure on page 33.
Table of Contents
General Warnings 4
Assembly Instructions 7
Connecting your Tank 31
Leak Testing 32
Operating Main Burners 33
Operating the Side Burner 34
Excess Flow Safety Valve Reset 34
Cleaning 34
Seasonal Cleaning 36
Tips for Cooking 37
Trouble Shooting 38
TG3007 LP U&C-2012 FA.indd 3 12-09-26 4:06 PM
4
General Warnings
This barbecue is not convertible to natural gas. Any
attempt to do so could result in injury or damage to
property and will void the warranty.
WARNINGS
Failure to follow the dangers, warnings and cautions
contained in this Owner’s Manual may result in re or
explosion causing property damage, personal injury or
death.
Do not store a spare or disconnected LP cylinder under
or near this barbecue.
Incorrect assembly may be dangerous. Please carefully
follow the assembly instructions. Do not assemble with
missing or damaged parts. If you do not understand
the instructions or need replacement parts, contact
Customer Service at 1-800-737-8815.
Check your local building codes for the proper method of
installation or in the absence of local codes, with either
the National Fuel Gas Code, ANSI Z223.1/NFPA 54,
Natural Gas and Propane Installation Code, CSA B149.1,
or Propane Storage and Handling Code, B149.2
The use of alcohol, prescription or non-prescription drugs
may impair an individual’s ability to properly assemble or
safely operate this barbecue.
Always place your barbecue on a hard and level
surface. An asphalt surface or wooden deck may not be
acceptable.
The gas barbecue should be thoroughly cleaned on a
regular basis.
If the barbecue has been stored or left unused for a
period of time, it should be checked for gas leaks and
burner obstructions before use. See instructions in this
manual for correct cleaning and leak testing procedures.
Do not enlarge valve orices or burner ports when cleaning
the valves or burners. Follow the proper procedures as
outlined in the burner cleaning section of this manual.
Keep ventilation openings for the cylinder storage clear of
debris.
Do not operate the gas barbecue if there is an odor of
gas present or a gas leak.
Do not use a ame to check for gas leaks.
Combustible materials should never be within 24 inches
(61 cm) of the back or sides of your gas barbecue.
Always position the barbecue where there is ample air
ow for combustion and ventilation, but never in the path
of a strong wind.
Do not use this barbecue under an overhead combustible
surface or covered area such as a gazebo, umbrella
porch or awning.
Do not put a barbecue cover or anything ammable on
or in the storage area under the barbecue or on the side
shelves. Keeping outdoor cooking gas appliance area
clear and free from combustible materials, gasoline and
other ammable vapors and liquids.
Your gas barbecue should never be used by children. Do
not let children or pets play around or below the grill or in
the cart. Never allow children or pets to crawl inside the
cart. Accessible parts of the barbecue may be very hot.
You should exercise care when operating your gas
barbecue. It will be hot during cooking or cleaning and
should never be left unattended or moved while in
operation.
When using the barbecue do not touch the grill rack, lid,
re box or anything in the immediate vicinity of these
parts, as they can become extremely hot and may cause
serious burns.
Never lean over an open grill.
Use only dry pot holders and oven mitts. Moist or damp
pot holders or oven mitts on hot surfaces may cause
burns from steam. Do not use a towel or a bulky cloth in
place of pot holders or oven mitts, as they may touch hot
portions of the grill rack.
For personal safety, wear appropriate clothing. Loose-
tting clothing should never be worn while using this
appliance. Some synthetic bers are highly ammable
and should not be worn while cooking.
Should the burners go out while in operation, turn all
gas valves o. Open the lid and wait ve minutes before
attempting to relight, using the igniting instructions.
Do not use charcoal, lighter uid or lava rock in your gas
barbecue.
Do not use aluminum foil to line the grill racks or the re
box. This can interfere with air ow or trap excessive heat
in the re box or control area.
Should a grease re occur, turn o all burners and leave
lid closed until re is out.
Only the pressure regulator and hose assembly supplied
with the unit should be used. Never substitute regulators
for those supplied with the grill. If a replacement is
necessary contact Customer Service for a replacement.
TG3007 LP U&C-2012 FA.indd 4 12-09-26 4:06 PM
5
Do not attempt to disconnect any gas tting while your
barbecue is in operation.
Do not repair or replace any part of the grill unless
specically recommended by the manual or Customer
Service. All other service should be referred to a qualied
technician.
Keep any electrical supply cord and the fuel supply hose
away from any heated surfaces and the grease cup and
tray where hot grease could drip down.
Combustion by-products produced when using
this product contain chemicals known to the state
of California to cause cancer, birth defects or other
reproductive harm.
Do not build this model of grill in any built-in or slide-in
construction. Ignoring this warning could cause re or
explosion that can cause property damage, personal
injury or death.
Do not heat unopened food containers as a build-up of
pressure may cause the container to burst causing injury
or damage to property.
This barbecue is not intended for commercial use.
Liquid Propane Gas Units Only:
Use the pressure regulator and hose assembly that is
supplied with your gas barbecue.
Do not attempt to disconnect the gas regulator and hose
assembly or any gas tting while your barbecue is in
operation.
A dented or rusty liquid propane cylinder may be
hazardous and should be checked by your liquid propane
supplier. Do not use a liquid propane cylinder with a
damaged valve.
Although your liquid propane cylinder may appear to be
empty, gas may still be present, and the cylinder should
be transported and stored accordingly.
Propane Characteristics: Propane is ammable, explosive
under pressure and heavier than air so it will settle and
pool in low areas and prevent dispersion.
If you see, smell or hear the hiss of escaping gas from the
liquid propane cylinder:
1. Move away from liquid propane cylinder.
2. Do not attempt to correct the problem yourself.
3. Call your re department.
Safe Gas Handling
Liquid propane has an odor similar to natural gas. You
should be aware of this odor.
Never store or transport the LP cylinder where
temperatures can reach 125°F (too hot to hold by hand.)
Do not leave the LP cylinder in a car on a hot day.
Treat empty LP cylinders with the same care as when full.
Even when the LP tank is empty of liquid there still may
be gas pressure in the cylinder. Always close the cylinder
valve before disconnecting.
CAUTION: Place dust cap on cylinder valve outlet
whenever the cylinder is not in use. Only install the type
of dust cap on the cylinder valve outlet that is provided
with the cylinder valve. Other types of caps or plugs may
result in leakage of propane.
The joint where the hose connects to the LP cylinder
must be leak tested each time the LP cylinder is
reconnected. For example, test each time the LP cylinder
is relled.
WARNING: Replacement LP tanks must match the
regulator connection supplied with this barbecue.
1 Type 1 Valve
2 Gas Control Valve
3 External Thread
4 Regulator Coupling
5 Regulator
6 Collar
LIQUID PROPANE CYLINDER REQUIREMENTS
Check to be sure that cylinders (1) have a D.O.T.
certication, and (2) have been date tested within ve
years of use. Your LP gas supplier can do this for you.
The LP cylinder must be a 20-lb. size approximately
18¼ inches high and 12¼ inches in diameter. The
cylinder must be provided with a cylinder valve outlet
specied, as applicable for connection type QCC1 is the
standard for compressed gas cylinder valve outlet and
inlet connection ANSI/CSA-V-1.
Main Manifold operating pressure:
11” water column (W.C.)/2.74KPA.
LP cylinder must be provided with a listed overlling
prevention device. This safety feature prevents the
cylinder from being overlled, which can cause a
malfunction of the cylinder, regulator and/or gas grill.
1
6
4
5
2 3
TG3007 LP U&C-2012 FA.indd 5 12-09-26 4:06 PM
6
The cylinder must be constructed and marked in
accordance with the specications for LP - Gas Cylinders
of the U.S. Department of Transportation (D.O.T.) or the
National Standard of Canada, CAN/CSA-B339, Cylinders,
Spheres and Tubes or Transportation of Dangerous
Goods; and Commission.
1. The LP gas cylinder must have a shuto valve outlet
that is compatible with a Type 1 tank connection
device. The LP gas cylinder must also have a safety
relief device that has a direct connection with the
vapor space of the cylinder.
2. The cylinder system must be arranged for vapor
withdrawal.
3. All LP cylinders must include a collar to protect the
cylinder valve.
Always keep LP cylinders in an upright position.
DANGER - NEVER store a spare LP cylinder under or
near gas appliances.
NEVER ll the tank beyond 80% full. Failure to follow
these statements exactly may result in re or explosion
which could cause property damage, personal injury or
death.
The total consumption (per hour) of this grill with all
burners set to “MAX” is 60,000 BTU/hr.
Four main burners: 48,000 BTU/hr
Side burner: 12,000 BTU/hr
CORRECT WRONG WRONG WRONG
Vapor Vapor Vapor Vapor
Liquid Liquid Liquid Liquid
TG3007 LP U&C-2012 FA.indd 6 12-09-26 4:06 PM
7
Assembly Instructions
INTRODUCTION
Do not return this product to store.
For assistance call Customer Service at 1-800-737-8815.
Please have the following information available.
Serial Number
The serial number can be found inside the front left door
of the barbecue on the top left hand corner of the rating
label. It can also be found on the cover of this manual.
Model Number
The model number is located on the front of this manual
and in the top left-hand corner of the rating label.
For easiest assembly:
1. Make sure all the parts are present. If parts are
missing or damaged, contact Customer Service.
2. To avoid losing small components, assemble the
barbecue on a smooth, level surface.
3. Clear an area large enough to lay out all the
components and hardware.
4. You must follow all steps in order to properly
assemble your barbecue.
5. To properly align the frame and doors, assemble
grill on a at and level surface.
To complete your assembly you will need:
1. A #2 Phillips head screw driver
2. Leak detection solution see
(Leak Detection section on page 32)
3. Precision-lled LP Gas Grill tank with an
Acme Type 1 external threaded valve connection
TG3007 LP U&C-2012 FA.indd 7 12-09-26 4:06 PM
8
Parts List
CODE PART QTY
1 Fire Box Assembly 1
2 Warming Rack 1
3 Cooking Grill 2
4 Heat Tent 4
5 Grease Tray Assembly 1
6 Grease Cup 1
7 Side Burner Grate 1
8 Side Burner Electrode 1
9 Side Burner Assembly 1
10 Side Burner 1
11 Side Burner Control Panel 1
12 Side Burner Knob 1
13 Side Table Assembly 1
14 Side Table Control Panel 1
15 Side Table Handle 1
16 Left Front Leg 1
17 Left Rear Leg 1
18 Right Front Leg 1
19 Right Rear Leg 1
20 Door Transom 1
21 Left Cart Side Panel 1
22 Right Cart Side Panel 1
23 Left Front Door 1
24 Right Front Door 1
25 Door Handle 2
26 Bottom Shelf Assembly 1
27 Cart Wire Support 1
28 Cart Support Bracket 2
29 Bottom Skirt - Front 1
30 Bottom Skirt - Left 1
31 Bottom Skirt - Right 1
32 Caster 2
33 Locking Caster 2
34 Lighting Rod 1
TG3007 LP U&C-2012 FA.indd 8 12-09-26 4:06 PM
9
Parts Diagram
TG3007 LP U&C-2012 FA.indd 9 12-09-26 4:06 PM
10
Hardware Reference Diagram
A
B
FE
C D
CODE PART QTY
A M6x12mm Bolt 39
B M6x8mm Bolt 4
C M5x8mm Bolt 4
D M6x40mm Bolt 2
E Washer 6
F M4x10mm Bolt 12
1:1 SCALE
TG3007 LP U&C-2012 FA.indd 10 12-09-26 4:06 PM
Table des matières
Autres manuels Tera Gear Gril
Tera Gear
Tera Gear TER 25K BTU PRO Manuel utilisateur
Tera Gear
Tera Gear PC22B Manuel utilisateur
Tera Gear
Tera Gear Weekend Warrior GSF3916 Manuel utilisateur
Tera Gear
Tera Gear GSS2020 Manuel utilisateur
Tera Gear
Tera Gear 13 01 3008TG Guide de démarrage rapide
Tera Gear
Tera Gear TG 1201 2561 Manuel utilisateur
Tera Gear
Tera Gear NG 993066 Manuel utilisateur
Tera Gear
Tera Gear GSF2616AC Manuel d'exploitation et d'entretien
Tera Gear
Tera Gear GSS2520JA Manuel utilisateur
Tera Gear
Tera Gear GSF2616AC Manuel utilisateur
