Siemens SL10 Manuel de l'opérateur
Information and Communication Products
Communication Devices
SL10
Level 2.5
Repair Documentation
V 1.3
V1.3 Page 1 of 31 ICP CD ST
D. Schnoor
08/98
Information and Communication Products
Communication Devices
Table of Contents
1 INTRODUCTION................................................................................................................................................3
2 TCXO
...................................................................................................................................................................................4
3 FUSE 1A
...................................................................................................................................................................................9
4 CONNECTOR X1 - LOWER MMI
.................................................................................................................................................................................13
5 CONNECTOR X2 - UPPER MMI + FLEXIBLE CABLE
.................................................................................................................................................................................18
6 RINGER
.................................................................................................................................................................................24
31ΜH COIL
.................................................................................................................................................................................2
8 FLEXIBLE CABLE MICROPHONE
.................................................................................................................................................................................32
V1.3 Page 2 of 31 ICP CD ST
D. Schnoor
08/98
Information and Communication Products
Communication Devices
1 Introduction
This manual is intended to hel you carry out SL10 re airs on level 2.5, meaning limited
com onent re airs. Failure highlights are documented and should be re aired in the local
worksho s.
It must be noted that all re airs have to be carried out in an environment set u according to
the ESD (Electrostatic Discharge Sensitive Devices) regulations defined in international
standards.
If you have any questions regarding the re air rocedures or s are arts do not hesitate to
contact our technical su ort team in Kam -Lintfort, Germany:
Tel.: +49 2842 95 4666
Fax: +49 2842 95 4302
e-mail: dominik.schnoor@klf.siemens.de
V1.3 Page 3 of 31 ICP CD ST
D. Schnoor
08/98
Information and Communication Products
Communication Devices
2 TCXO
2.1 Affected Units
2.1.1 Type SL10
2.1.2 Affected IMEIs / Date Codes All / All
2.1.3 Affected SW-Versions All
2.1.4 Fault Code for LSO reporting 3TCX
2.2 Fault Description
2.2.1 Fault Symptoms for customers
Network Search
Handset not logging into network
2.2.2 Fault Symptom on GSM-Tester
Frequency error in synchronized mode >90 Hz
No location u date ossible
V1.3 Page 4 of 31 ICP CD ST
D. Schnoor
08/98
Information and Communication Products
Communication Devices
The TCXO (Tem erature Com ensated Crystal Oscillator) is res onsible for generating the
13 MHz reference frequency of the handset.
If it is defective, the handset cannot synchronize to the base station anymore.
2.3 Priority
........ Mandatory
........ Re air
........ O tional
........ Not Yet Defined
2.4 Repair Documentation
2.4.1 Description of procedure
2.4.1.1 Diagnosis
Check the out ut frequency of the TCXO using the level-2 testing
rogram for SL10.
Set the „Simulator“ o tion in the S611.INI file to 0 and restart
the rogram. Start the test. When the rogram says „Check ower and
hase of external antenna with your GSM-Tester“, switch the CMD to
„LOCAL“ mode and enter the „MODULE TEST“.
On the CMD dis lay you can see the frequency error of the handset.
(Make sure that the CMD is on channel 124, ower level 5!)
If the frequency error is higher than 2kHz, the TCXO has to be
re laced.
2.4.1.2 Repair by component change
Use hot air blower to remove defective TCXO.
Avoid excessive heat!
Watch surrounding com onents!
Resolder new TCXO afterwards.
2.4.1.3 Repair by SW-Booting
Not ossible!
V1.3 Page 5 of 31 ICP CD ST
D. Schnoor
08/98
Information and Communication Products
Communication Devices
2.4.1.4 Test
Retest handset after re air as described above.
The frequency error must now be < 2kHz.
2.4.2 List of needed material
2.4.2.1 Components
TCXO
Part-Number: L36145-G300-Y17
2.4.2.2 Jigs and Tools
Hot Air Blower
Soldering Iron
2.4.2.3 Special Tools
None
2.4.2.4 Working materials
Desolder Wick / Braid
Solder
V1.3 Page 6 of 31 ICP CD ST
D. Schnoor
08/98
Information and Communication Products
Communication Devices
2.4.3 Drawings
V1.3 Page 7 of 31 ICP CD ST
D. Schnoor
08/98
Figure 1 SL10 Board TCXO Side
Information and Communication Products
Communication Devices
V1.3 Page 8 of 31 ICP CD ST
D. Schnoor
08/98
Figure 2 TCXO (Z601) Placement (Top View)
Information and Communication Products
Communication Devices
3 Fuse 1A
3.1 Affected Units
3.1.1 Type SL10
3.1.2 Affected IMEIs / Date Codes All / All
3.1.3 Affected SW-Versions All
3.1.4 Fault Code for LSO reporting 3FU1
3.2 Fault Description
3.2.1 Fault Symptoms for customers
Battery charging not ossible
3.2.2 Fault Symptom on GSM-Tester
This fault cannot be detected with a GSM-Tester
3.3 Priority
........ Mandatory
........ Re air
........ O tional
........ Not Yet Defined
V1.3 Page 9 of 31 ICP CD ST
D. Schnoor
08/98
Information and Communication Products
Communication Devices
3.4 Repair Documentation
3.4.1 Description of procedure
3.4.1.1 Diagnosis
Check the status of the fuse by measuring its resistance with
a multimeter. The fuse is defective if the resistance is higher than 10
ohms.
3.4.1.2 Repair by component change
Use soldering iron to remove defective fuse.
Avoid excessive heat!
Watch surrounding com onents!
Resolder new fuse afterwards.
3.4.1.3 Repair by SW-Booting
Not ossible!
3.4.1.4 Test
Retest handset after re air as described above.
The resistance must now be close to zero.
V1.3 Page 10 of 31 ICP CD ST
D. Schnoor
08/98
Autres manuels pour SL10
6
Table des matières
Autres manuels Siemens Téléphone portable
Siemens
Siemens S40 Manuel utilisateur
Siemens
Siemens CF62 Manuel utilisateur
Siemens
Siemens SL65 Guide de configuration
Siemens
Siemens RUGGEDCOM i802 Manuel utilisateur
Siemens
Siemens Gigaset SL55 Manuel de l'opérateur
Siemens
Siemens AX75 Guide de configuration
Siemens
Siemens SL65 Manuel utilisateur
Siemens
Siemens Gigaset S45 Manuel utilisateur
Siemens
Siemens C55/2128 Manuel utilisateur
Siemens
Siemens A65 Manuel utilisateur
Siemens
Siemens CX75 Manuel utilisateur
Siemens
Siemens AL21 Manuel utilisateur
Siemens
Siemens M35i Manuel utilisateur
Siemens
Siemens C62 Manuel utilisateur
Siemens
Siemens A35 Manuel utilisateur
Siemens
Siemens A62 Manuel utilisateur
Siemens
Siemens XELIBRI 2 Manuel utilisateur
Siemens
Siemens C65 Manuel utilisateur
Siemens
Siemens SL10 Manuel utilisateur
Siemens
Siemens SK65 Guide de sécurité
