Scotsman ACM 85 Manuel utilisateur

SERVICE MANUAL

ACM 85

AC 125

AC 175

AC 225

R 134 A / R 404 AVERSIONS

Electronic cubers

with storage

MS 1000.08 REV. 03/98

Table of contents page

Specifications ACM 85

Specifications AC 125

Specifications AC 175

Specifications AC 225

GENERAL INFORMATION AND INSTALLATION

Introduction

Unpacking and Inspection

Location and levelling

Electrical connections

Water supply and drain connections

Final check list

Installation practice

OPERATING INSTRUCTIONS

Start up

Operational checks

OPERATING PRINCIPLES (How it works)

Freezing cycle

Harvest cycle

Control sequence

Component description

ADJUSTMENT, REMOVAL AND REPLACEMENT PROCEDURES

Adjustment of the cube size

Replacement of evaporator temperature sensor

Replacement of condenser temperature sensor

Replacement of ambient temperature sensor

Replacement of ice level light control

Replacement of P.C. Board

Replacement of the water pump (ACM 85)

Replacement of the water pump (AC 125 & AC 175 )

Replacement of the water pump (AC 225)

Replacement of water inlet solenoid valve

Replacement of hot gas valve coil

Replacement of water drain solenoid valve

Replacement of fan motor

Replacement of plastic curtain (ACM 85 & AC 125-175)

Replacement of spray platform and chute (ACM 85 & AC 125-175)

Replacement of spray bar (AC 225)

Replacement of drier

Replacement of hot gas valve body

Replacement of evaporator platen

Replacement of air cooled condenser

Replacement of water cooled condenser

Replacement of water regulating valve (water cooled models)

Replacement of compressor

Wiring diagram (ACM 85)

Wiring diagram (AC 125-175 & AC 225)

Service diagnosis

MAINTENANCE AND CLEANING INSTRUCTIONS

General

Icemaker

Cleaning instructions of water system

Page 01

TABLE

OF CONTENTS

SPECIFICATIONS

ELECTRONIC CUBER MODEL ACM 85

Important operating requirements:

MIN MAX

Air temperature 10°C (50°F) 40°C (100°¯F)

Water temperature 5°C (40°F) 40°C (100°F)

Water pressure 1 bar (14 psi) 5 bar (70 psi)

Electr. voltage

variations from

voltage rating

specified on

nameplate -10% +10%

ice making capacity

NOTE.

With the unit in “built-in” conditions, the ice production is gradually reduced in respect to the

levels shown in the graf, up to a maximum of 10% at room temperatures higher than 32

The daily ice-making capacity is directly related to the condenser air inlet temperature, water

temperature and age of the machine.

To keep your SCOTSMAN CUBER at peak performance levels, periodic maintenance checks

must be carried out as indicated on page 38 of this manual.

Page 02

Kg.

32 °C

AIR COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

Kg.

°C

WATER COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

27 21 15 10 32 27 21 15 10

Basic electr. Amps. Start Amps Watts No of Wires Amp. Fuse

Page 03

SPECIFICATIONS (CONT'D)

Electr. power cons.

Kwh per 24 Hrs

230/50/1 3.2 17 500 10 3 x 1 m/m 10

Cubes per harvest: 24 medium

* At 15°C (60°F) water temperature

ACM 85 - CUBER MACHINE SPECIFICATION

Model Cond. Finish Comp. HP Ice bin cap. Water requirem

Kgs. LTx24 HR

ACM 85 AS Air S/Steel 140*

3/8 14

ACM 85 WS Water S/Steel 380*

FRONT VIEW

HEIGHT (without legs) 790 mm.

HEIGHT (with legs) 930 mm.

WIDTH 457 mm.

DEPTH 523 mm.

WEIGHT 44 Kgs.

SPECIFICATIONS

ELECTRONIC CUBER MODEL AC 125

Important operating requirements:

MIN MAX

Air temperature 10°C (50°F) 40°C (100°¯F)

Water temperature 5°C (40°F) 40°C (100°F)

Water pressure 1 bar (14 psi) 5 bar (70 psi)

Electr. voltage

variations from

voltage rating

specified on

nameplate -10% +10%

ice making capacity

NOTE.

With the unit in “built-in” conditions, the ice production is gradually reduced in respect to the

levels shown in the graf, up to a maximum of 10% at room temperatures higher than 32

The daily ice-making capacity is directly related to the condenser air inlet temperature, water

temperature and age of the machine.

To keep your SCOTSMAN CUBER at peak performance levels, periodic maintenance checks

must be carried out as indicated on page 38 of this manual.

Production charts shown indicate the production of ACM models; ice production of ACL and

ACS models is 10% lower.

Page 04

Kg.

32 °C27 21 15 10

AIR COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

Kg.

°C

WATER COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

10 21

32 27 21 15 10

Basic electr. Amps. Start Amps Watts No of Wires Amp. Fuse

Page 05

SPECIFICATIONS (CONT'D)

Electr. power cons.

Kwh per 24 Hrs

230/50/1 3.8 20 670 13 3 x 1 m/m 10

Cubes per harvest: 36 large / 48 medium / 84 small

* At 15°C (60°F) water temperature

Ice bin cap. Water requirem

Kgs. LTx24 HR

AC 125 AS Air S/Steel 160*

1/2 28

AC 125 WS Water S/Steel 680*

AC 125 - CUBER MACHINE SPECIFICATIONS

Model Cond. Finish Comp. HP

FRONT VIEW

HEIGHT (without legs) 900 mm.

HEIGHT (with legs) 1020 mm.

WIDTH 675 mm.

DEPTH 520 mm.

WEIGHT 75 Kgs.

SPECIFICATIONS

ELECTRONIC CUBER MODEL AC 175

Important operating requirements:

MIN MAX

Air temperature 10°C (50°F) 40°C (100°¯F)

Water temperature 5°C (40°F) 40°C (100°F)

Water pressure 1 bar (14 psi) 5 bar (70 psi)

Electr. voltage

variations from

voltage rating

specified on

nameplate -10% +10%

ice making capacity

NOTE.

With the unit in “built-in” conditions, the ice production is gradually reduced in respect to the

levels shown in the graf, up to a maximum of 10% at room temperatures higher than 32

The daily ice-making capacity is directly related to the condenser air inlet temperature, water

temperature and age of the machine.

To keep your SCOTSMAN CUBER at peak performance levels, periodic maintenance checks

must be carried out as indicated on page 38 of this manual.

Production charts shown indicate the production of ACM models; ice production of ACL and

ACS models is 10% lower.

Page 06

87,5

Kg.

32 10 °C

AIR COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

WATER COOLED MODELS

27 21 15

82,5

77,5

72,5

67,5

62,5

57,5

87,5

Kg.

32 10 °C

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

27 21 15

82,5

77,5

72,5

67,5

92,5

Basic electr. Amps. Start Amps Watts No of Wires Amp. Fuse

SPECIFICATIONS (CONT'D)

Electr. power cons.

Kwh per 24 Hrs

230/50/1 5.3 29 850 18 3 x 1 m/m 16

Cubes per harvest: 36 large / 48 medium

* At 15°C (60°F) water temperature

Ice bin cap. Water requirem

Kgs. LTx24 HR

AC 175 AS Air S/Steel 0160*

3/4 28

AC 175 WS Water S/Steel 1000*

AC 175 - CUBER MACHINE SPECIFICATIONS

Model Cond. Finish Comp. HP

FRONT VIEW

HEIGHT (without legs) 900 mm.

HEIGHT (with legs) 1020 mm.

WIDTH 675 mm.

DEPTH 520 mm.

WEIGHT 75 Kgs.

Page 07

SPECIFICATIONS

ELECTRONIC CUBER MODEL AC 225

Important operating requirements:

MIN MAX

Air temperature 10°C (50°F) 40°C (100°¯F)

Water temperature 5°C (40°F) 40°C (100°F)

Water pressure 1 bar (14 psi) 5 bar (70 psi)

Electr. voltage

variations from

voltage rating

specified on

nameplate -10% +10%

ice making capacity

NOTE.

With the unit in “built-in” conditions, the ice production is gradually reduced in respect to the

levels shown in the graf, up to a maximum of 10% at room temperatures higher than 32

The daily ice-making capacity is directly related to the condenser air inlet temperature, water

temperature and age of the machine.

To keep your SCOTSMAN CUBER at peak performance levels, periodic maintenance checks

must be carried out as indicated on page 38 of this manual.

Production charts shown indicate the production of ACM models; ice production of ACL and

ACS models is 10% lower.

Page 08

150

145

140

135

130

125

120

115

110

105

100

Kg.

32 °C

AIR COOLED MODELS

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

WATER COOLED MODELS

27 21 15 10

160

155

150

145

140

135

130

125

120

115

110

105

100

Kg.

32 °C

WATER TEMPERATURE

AMBIENT TEMPERATURE

ICE PRODUCED PER 24 HRS.

°C

27 21 15 10

Basic electr. Amps. Start Amps Watts No of Wires Amp. Fuse

Page 09

SPECIFICATIONS (CONT'D)

Electr. power cons.

Kwh per 24 Hrs

230/50/1 5.3 29 1100 22 3 x 1.5 m/m 16

Cubes per harvest: 72 large / 102 medium / 198 small.

* At 15°C (60°F) water temperature

FRONT VIEW

HEIGHT (without legs) 1006 mm.

HEIGHT (with legs) 1126 mm.

WIDTH 1078 mm.

DEPTH 660 mm.

WEIGHT 115 Kgs.

AC 225 - CUBER MACHINE SPECIFICATIONS

Model Cond. Finish Comp. HP Ice bin cap. Water requirem

Kgs. LTx24 HR

AC 225 AS Air S/Steel 0250*

170

AC 225 WS Water S/Steel 1500*

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Scotsman Machine à glaçons

Scotsman

Scotsman FM1202R Manuel utilisateur

Scotsman

Scotsman Prodigy C2148 Mode d’emploi

Scotsman

Scotsman DMS21SB Manuel utilisateur

Scotsman

Scotsman AF Series Manuel utilisateur

Scotsman

Scotsman SCE275 Manuel d'instructions

Scotsman

Scotsman DC33 Manuel utilisateur

Scotsman

Scotsman NME1250R Manuel utilisateur

Scotsman

Scotsman CMS1202R Manuel utilisateur

Scotsman

Scotsman CSWE1 Manuel utilisateur

Scotsman

Scotsman MV 426 Mode d'emploi

Scotsman

Scotsman MAR 78 Manuel utilisateur

Scotsman

Scotsman EH330 C Series Manuel utilisateur

Scotsman

Scotsman MDT5N25 Manuel utilisateur

Scotsman

Scotsman DCE33 Series Manuel de référence

Scotsman

Scotsman Prodigy Eclipse 600 Manuel utilisateur

Scotsman

Scotsman C1448R Manuel utilisateur

Scotsman

Scotsman F0522 Manuel utilisateur

Scotsman

Scotsman CME650R Manuel utilisateur

Scotsman

Scotsman C2648 - Manuel utilisateur

Scotsman

Scotsman MAR1400 Manuel utilisateur

Scotsman

Scotsman C1848R Manuel utilisateur

Scotsman

Scotsman FME 1204 Manuel utilisateur

Scotsman

Scotsman CME506R Manuel utilisateur

Scotsman

Scotsman N0922L Manuel utilisateur

Manuels Machine à glaçons populaires d'autres marques

Hoshizaki

Hoshizaki KMD-460MWJ Manuel utilisateur

Sub-Zero

Sub-Zero 315I Instructions d'utilisation

Unold

Unold 48945 Manuel utilisateur

Kenmore

Kenmore 2217402A Manuel utilisateur

Cornelius

Cornelius WM600 Mode d'emploi

GE XPIO43SCSS Manuel utilisateur

Hoshizaki

Hoshizaki KMD-901MAH Manuel utilisateur

Whynter

Whynter FIM-450HA Manuel utilisateur

U-Line

U-Line UMCR014-SC01A Manuel d'installation

Andrew James

Andrew James AJ000522 Manuel utilisateur

Kärcher

Kärcher IP 120 Manuel utilisateur

U-Line

U-Line SS1095 Manuel utilisateur

Maytag

Maytag MIM1554WRS - Ice Maker Manuel utilisateur

Hoshizaki

Hoshizaki KM-630MAH Manuel utilisateur

Princess

Princess Yonanas Manuel utilisateur

Unold

Unold 48946 Manuel utilisateur

Electrolux

Electrolux E15IM60GP Manuel utilisateur

Cornelius

Cornelius UC150 ICE ONLY Manuel utilisateur