Raypak 751-1501 Manuel utilisateur

Catalog No.: 2000.36G Effective: 2-1-08 Replaces: 5-1-05

Job:

Engineer:

Contractor:

Prepared By: Date:

Model: Indoor/Outdoor:

100% Factory Fire Tested

Efficiency: 84%

Maximum Outlet Temperature: 230°F

Minimum Non-Condensing Inlet Temperature: 105°F

Thermal Shock Proof Heat Exchanger

Footprint: Less Than 5-1/2 ft2

Limited Twenty-Year Thermal Shock Warranty

Limited Ten-Year Heat Exchanger Warranty

Ten-Year Unconditional Burner Head Warranty

Operation Status Center and Full Diagnostic Panel

Heat Exchanger

Bronze Headers

ASME Inspected and Stamped

160 PSIG Working Pressure

National Board Approved

Copper-finned Tubes

ASME Steel Tube Retainer

Silicone High Temp O-Rings

60 PSIG ASME Pressure Relief

Valve

Temperature and Pressure Gauge,

Shipped Loose

Control

120V, 60Hz, Power Supply

120/24V 60Hz Transformer

100% Pilot Shutoff/Lockout

Electronic Intermittent Ignition Pilot

(IID)

High Limit Control, Manual Reset

High Limit Control, Auto Reset

On/Off Switch

Flow Switch

Blocked Vent Pressure Switch

Combustion Air Proving Switch

Time Delay Pump Off Control

Central Point Wiring Diagnostics

Panel

Burner

Aerodynamically Stabilized

Non-Clog Burner

Ultra-Low NOx: Less than 30 PPM

Gas Train

Fuel

Natural Gas

Propane (Models 751 & 1001)

Manual Gas Shut-off Valves

Gas Pressure Regulator

Safety Shut-off Valve

Firing Control Valve

Manual Low Gas Pressure Switch

On/Off Firing Mode (H4)

Design Certified ANSI Z21.13/

CSA 4.9

Construction

Indoor/Outdoor Construction

Front Controls Enclosed

PolyTuf Powder Coat Finish

Connections (Water, Electrical,

Gas)

Rear – Standard

Right Side – Option A-8

Venting

Vent Location

Rear – Standard

Right Side – Option Z-2

Vent Termination Cap

Outdoor - Option D-11

Indoor, Horizontal – Option D-15

Indoor, Vertical (by others)

Temperature Controls

B-20 Single-Stage Controller,

100-200°F

B-6 2-Stage Controller, 100-200°F

B-21 4-Stage TempTracker Digital

Controller, Loose

B-23 4-Stage TempTracker Digital

Controller, Outdoor Reset, Loose

Y-241 Electronic Sequencer,

1-4 Stages

Y-281 Electronic Sequencer,

5-8 Stages

Additional Safety Controls (Optional)

F-10 Low Water Cut-off,

Remote Probe

S-2 Manual High Gas Pressure

Switch

Regulatory Agency Requirements

C-5 Ignition Lockout Module

Other Equipment

Condensing Heat Exchanger

Pump

ADB™ - Type H

Hydronic Heating Boilers

Models 751-1501

Catalog No.: 2000.36G Effective: 2-1-08 Replaces: 5-1-05

ADB – Type H

Models 751-1501 Model

MBTUH B D E F G H K M P

Ship

Weight Foot-

print Amps*

Model Input Output Height NPT NPT

Flue ∅(Lbs.) (Ft2)

H 751 750 630 64 38 44-1/2 29-3/4 1-1/2 2 8 17-3/4 41 680 5.4 8

H 1001 999 840 72 46 52-1/2 37-3/4 1-1/2 2-1/2 10 21-1/2 49 720 5.4 10

H 1501 1499 1260 82 56 62-1/2 47-3/4 1-1/2 2-1/2 12 20-1/4 59 780 5.4 12

- Dimensions are in inches.

- Ratings shown are for elevations up to 5,000 feet. For installations at elevations

above 5,000 feet, please consult the factory for additional instructions.

- For direct vent applications, please contact the factory about relocating the pump.

* Current draw does NOT include pump.

(Supply breaker must have delayed trip.)

RATES OF FLOW AND PRESSURE DROPS

20°F ∆T 30°F ∆T 40°F ∆T Maximum Flow Minimum Flow

Model GPM

∆P (ft.) GPM ∆P (ft.) GPM ∆P (ft.) GPM ∆P (ft.) ∆T (°F) GPM ∆P (ft.) ∆T (°F)

H 751 63 5.8 42 2.9 32 1.8 110 17.0 11 32 1.8 40

H 1001 84 11.8 56 5.6 42 3.4 110 20.0 15 42 3.4 40

H 1501 126 31.4 84 14.9 63 9.1 126 31.4 20 63 9.1 40

Certified Clearances

Front 24” (for service)

Rear 12” (water side)

Right 1”

Left 1”

Top 0” (see note 1)

Floor 0” (see note 2)

Vent 1”

Notes:

1. 24” required for service

2. DO NOT install on carpeting

Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 (805) 278-5300 Fax (800) 872-9725 www.raypak.com

Ce manuel convient aux modèles suivants

Autres manuels Raypak Chaudière

Raypak

Raypak 503-2003 Manuel

Raypak

Raypak Xtherm 1005 Guide de configuration

Raypak

Raypak 0180B Type H Manuel utilisateur

Raypak

Raypak 1001 Fiche technique

Raypak

Raypak XFYRE 500 Manuel utilisateur

Raypak

Raypak MVB TYPE B 504-2004 Manuel

Raypak

Raypak 1005-2005 Manuel utilisateur

Raypak

Raypak 0090B 0135B Manuel utilisateur

Raypak

Raypak 302-902 Manuel utilisateur

Raypak

Raypak MVB 504A Instructions d'installation

Raypak

Raypak Raytherm H-182 Manuel utilisateur

Raypak

Raypak H-0030B Mode d’emploi

Raypak

Raypak Hydronic Space Heating 42-180 Manuel utilisateur

Raypak

Raypak H7 504-2004 Manuel utilisateur

Raypak

Raypak 504-2004 Mode d’emploi

Raypak

Raypak 302BE-902BE Manuel utilisateur

Raypak

Raypak Raytherm H-2100 Manuel utilisateur

Raypak

Raypak 2342BE Manuel utilisateur

Raypak

Raypak HI DELTA HD101 THRU 2342B Mode d’emploi

Raypak

Raypak 399B-2339B Manuel

Raypak

Raypak DEL TA LIMITED 399B Manuel utilisateur

Raypak

Raypak 1000 .19C Manuel utilisateur

Raypak

Raypak FlexGas 302BD Manuel utilisateur

Raypak

Raypak 2503 Manuel

Manuels Chaudière populaires d'autres marques

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manuel utilisateur

Radijator

Radijator BIO max 23.1 Manuel utilisateur

Brunner

Brunner BSV 20 Manuel utilisateur

Buderus

Buderus Logamax GB062-24 KDE H V2 Manuel utilisateur

Potterton

Potterton 50e Fiche technique

UTICA BOILERS

UTICA BOILERS TriFire Manuel utilisateur

Joannes

Joannes LADY Series Manuel

ECR International

ECR International UB90-125 Manuel d'instructions

Froling

Froling FHG Turbo 3000 Manuel utilisateur

Froling

Froling P4 Pellet 8 - 105 Manuel utilisateur

U.S. Boiler Company

U.S. Boiler Company K2 Manuel utilisateur

Henrad

Henrad C95 FF Manuel utilisateur

NeOvo

NeOvo EcoNox EF 36 Manuel utilisateur

Potterton

Potterton PROMAX SL 12 Manuel utilisateur

Eco Hometec

Eco Hometec EC 25 COMPACT Manuel utilisateur

Viessmann

Viessmann VITODENS 200 Mode d’emploi

Baxi

Baxi Prime 1.24 Manuel utilisateur

REXNOVA

REXNOVA ISA 20 BITHERMAL Manuel utilisateur