Progrill CS157 Manuel utilisateur

formerly DOUGHPRO. New Name. Same Quality. Superior Service.

proluxe.com

Operations Manual

Model: CS157

15”x 7” Clamshell Grill

Operation Instructions

Please read carefully before attempting to use this appliance.

Step 1. Carefully unpack and clean grill plates with mild soap then sponge clean

with cold water.

Step. 2. Place in location where it will be used allowing for clearances per the

dimensions indicated.

WARNING! Allow 2” minimum clearance between adjacent equipment and/or

wall areas.

Do not touch hot surfaces.

Step 3. Plug into proper 3 prong wall outlet. If other appliances are connected

to the same circuit make sure the total load does not exceed maximum

ampacity of the circuit. Electrical information is as follows:

120V/60Hz/1 phase/1150W/9.6 Amps

208V/60Hz/1 phase/2800W/13.5 Amps

Step 4: Warm-up

Energize by turning on the power switch which will illuminate when turned

on. The display flashes and shows left preset timer during warm-up. Pre-

heat temperature time will be 40-50 minutes. When the set point is

reached, the display stops flashing and beeps 3 times.

Step 4: Operation

Simply place product on grill, close lid and press the

desired pre-set time cycle (ex: 10 seconds). After the time cycle is

finished press it again to reset the time cycle.

Cleaning Instructions

NOTE! Always turn off power and allow to cool down before attempting to clean.

Never submerge grill in water or other liquid nor use mineral spirits

or other flammable material to clean this appliance.

!Never use ice to cool down grill, warranty will be void!

Clean stainless steel and griddle surfaces with soap and water using a

soft, clean cloth periodically as required, but at least once daily. Never

use harsh abrasives. Use only non-abrasive scouring pads when required.

Clean Cycle

275°F is the factory default temp for the CLEAN cycle. To change the CLEAN cycle temp, simultaneously

hold down the TEMP and CLEAN buttons for 15 seconds.

Using the up or down arrows to adjust to the desired temp.

To start a clean cycle, push CLEAN button once so the CLEAN LED light is turned on. All preset LED’s are

turned off, and the temperature set point is changed to the clean set point of 275°F. This also initiates

the cool down to clean set point condition as well the display starts flashing until the clean set point is

reached.

To stop the clean cycle, simply press the CLEAN button once to deactivate the clean cycle. The CLEAN

LED is turned off, the preset LED’s are restored, the temperature set point is changed to the main set

point. Again, the warm-up condition is initiated and the display flashes until the cook set point is

reached.

CS157 Operating Instructions:

1. Press desired time to start the time cycle. After the cycle is finished, press it again to

reset the time cycle

2. If for any reason the timer has to be reset in the middle of a cycle, you must press and hold

the corresponding timer button for 3 seconds.

Instruction’s for Adjusting the Temperature

PRESS and hold the TEMP and

ARROW up

buttons simultaneously for 15

seconds.

Using the ARROW buttons, you

may now adjust the temperature

to your desired setting.

Once you have set your desired

temperature simply push

the TEMP button. The digital

displays will now read the

preset times.

Instruction’s for Adjusting the Set-Time

PRESS the desired button you

wish to program.

Now press BOTH button and

TEMP buttons simultaneously

for 5 seconds.

The digital displays will now read their preset

time. The unit is capable of having

up to 4 different settings.

Now using the ARROW buttons you

can set your desired time.

Once you have set the desired time simply press the

TEMP button, the unit will display the new set-time.

68 18

MODEL CS157

A2P

SHEET 1 OF 3

EXPCS157 R4 1012 102113

71A

A1P

A4P

78A

SHEET 2 OF 3

MODEL CS157

20 63

EXPCS157 R4 1012 102113

CS157P

77 27 38 58

43 46

48 4

646 43

62 84 83 61

84 82 15

37 42 16

SHEET 3 OF 3

A6P

MODEL CS157

EXPCS157 R4 1012 102113

CS157P

MODEL CS157 PARTS LIST

MODEL

CS157A

MODEL

CS157PA

QTY.

ITEM # DESCRIPTION 120V 120V

1 LOWER WRAP AROUND SHROUD ASSY 110103901 110103901 1

3 SPRING, DETENT 1/2 LONG 110115555 110115555 1

4 FUSE HOLDER MPPF708 MPPF708 1

5 FUSE BUSS 1 AMP MPPF701R MPPF701R 1

6 TRANSFORMER 11096975 11096975 1

7 TERMINAL BLOCK #6 6016 6016 1

8 STRAIN FELIEF 11016546468 11016546468 1

9 CORD, POWER 120V 110969174 110969174 1

10 TUBBING-PAD 110115531 110115531 1

11 COVER, LOWER PLATTEN ASSY 110103909 110103909 1

12 LOWER PLATEN INSULATION 110103910 110103910 1

13 GREASE TRAY 110103903 110103903 1

14 GREEN INSULATION WASHER C4401 C4401 9

15 TOP LINK 110115508 110115508 1

16 BOLT, HEX 5/16-18 X1 1/2 SST BH516181S BH516181S 2

17 E-CLIP, RETAINING RING LCC3478 LCC3478 2

18 PIN, BACK STOP 110115543 110115543 1

19 HANDLE GRIP 110901168 110901168 1

20 SST SET SCREW KNURLED CUP POINT 5/16-18 x 3/8 SST5161838KN SST5161838KN 6

21 RUBBER GROMET, 5/16 X 1/2 110115554 110115554 1

22 INSULATION, UPPER PLATEN RIGHT HAND 110888251R 110888251R 1

23 BUSHING, TEFLON , 3/4" LONG 110113441 110113441 1

24 GROMET, RUBBER 3/4 X 1 3/8 110103919 110103919 1

27 SPACER, NYLON 1/4X.141 X 9/32 11090109 11090109 4

28 WASHER, SAE #8 WSAE8 WSAE8 4

29 NUT, HEX 8-32 NH832 NH832 3

30 SCREW, PAN HEAD PHILLIPS 2-56 X1/4 SP25614 SP25614 1

31 WASHER #5/16 INTERNAL TOOTH LOCK WLIT516 WLIT516 2

32 WASHER #8 INTERNAL TOOTH LOCK WLIT8 WLIT8 2

33 RELAY 110942520 110942520 2

34 BOTTOM COVER 110103917 110103917 1

36 FLANGE TEFLON BUSHING 110115563 110115563 1

37 BUSHING TEFLON 1” LONG 110115541 110115541 3

38 WASHER, STEEL 311150019 311150019 4

40 MARKER STRIP #6 DOUBLE MS6016 MS6016 1

41 WASHER, CUT 5/16-18 WC516 WC516 3

42 WASHER, 5/16 SPLIT LOCK WL516 WL516 5

43 WASHER, #6 INTERNAL TOOTH LOCK WLIT6 WLIT6 12

44 WASHER, SAE 3/8 WSAE38 WSAE38 4

45 NUT, HEX 3/8-16 NH3816 NH3816 4

46 NUT, HEX 6-32 NH632 NH632 12

47 SCREW, PHILLIPS 8-32X3/8 SST SP83238S SP83238S 13

48 SCREW, PHILLIPS 6-32X3/8 SP63238 SP63238 6

49 SCREW, PAN HEAD SLOTED 10-32 X 3/8 SST SPS103238S SPS103238S 6

50 SCREW, SOCKED HEAD 5/16-18 X 3/4 SSH5161834 SSH5161834 3

51 SCREW, SET 3/8-16 X 1/2 SST381612 SST381612 3

52 SCREW, PAN HEAD PHILLIPS 6-32 X1/4 SP63214 SP63214 2

53 WASHER 3/8 SPLIT LOCK WL38 WL38 4

54 WASHER, SAE #6 WSAE6 WSAE6 2

55 BOLT, HEX 1/4-20 x 1.00 SST BH14201S BH14201S 1

56 WASHER, SAE 1/4" WSAE14 WSAE14 1

57 WASHER, SPLIT LOCK , 1/4" WL14 WL14 1

58 DIGITAL CONTROL 110171433052 110171433052 1

60 PLUNGER ASSY 110115544 110115544 1

61 UPPER LEVELING BRACKET 110115510 110115510 1

62 UPPER LEVELING SHIM 110115557 110115557 1

63 HANDLE, SPRING ADJUSTING COLLAR 110115528 110115528 1

64 COLLAR, HOLDER 110115530 110115530 1

65 BACK COVER 110103907 110103907 1

66 COUNTER BALANCE SPRING 1101039154 1101039154 1

67 RIGHT SHROUD ASSY 11016546455 11016546455 1

68 RTD SENSOR (LOWER) 1108881102 1108881102 1

PLCS157 R4 1012 102113.DOC

MODEL CS157 PARTS LIST

MODEL

CS157A

MODEL

CS157PA

QTY.

ITEM # DESCRIPTION 120V 120V

69 RTD SENSOR (TOP) 1108881101 1108881101 1

70 SCREW, PAN HEAD PHILLIPS 8-32 X1 SP8321 SP8321 1

72 HANDLE RIGHT ASSY 110103916 110103916 1

73 CLEVIS ASSY, RIGHT HAND 110115504 110115504 1

75 SST SET SCREW 3-8-16 X 1.00 SST38161 SST38161 1

76 NUT, SERRATED FLANGED HEX 1/4-20 NHSF1420 NHSF1420 1

77 OVERLAY OCS157 OCS157 1

78 UPPER PLATEN, RIGHT 110115540R120 11011557R120 1

79 WIRE HARNESS 110103950 110103950 1

82 PIN, PIVOT BACK 110115566 110115566 1

83 PIN, PIVOT FRONT 110115565 110115565 1

84 RETAINING RING 110115567 110115567 4

87 MANUAL CS157 MSCS157 MSCS157 1

88 SST SET SCREW 3-8-16 X 1 1/2 SST3816112 SST3816112 4

89 TRANSFORMER INSULATION 1101159180 1101159180 1

90 SCREW, PHILLIPS 6-32X5/8 SP63258 SP63258 2

A1P LOWER PLATEN PANINI WITH WIRING N/A 110103932307 1

A1 LOWER PLATEN WITH WIRING 110103932207 N/A 1

A2P LOWER PLATEN PANINI ASSEMBLY N/A 110103932PK 1

A2 LOWER PLATEN ASSEMBLY 110103932K N/A 1

A4P UPPER PLATEN PANINI RIGHT HAND WITH WIRING N/A 1101155304 1

A4 UPPER PLATEN RIGHT HAND WITH WIRING 1101155204 N/A 1

A6P UPPER PLATEN PANINI RIGHT HAND ASSEMBLY N/A 1101155313 1

A6 UPPER PLATEN RIGHT HAND ASSEMBLY 1101155113 N/A 1

A7 SCRAPER, PANINI 110115580 110115580 1

PLCS157 R4 1012 102113.DOC

Table des matières

Autres manuels Progrill Gril

Progrill

Progrill PROLUXE CS157A Manuel utilisateur

Progrill

Progrill TW1520 Manuel utilisateur

Manuels Gril populaires d'autres marques

Orbegozo

Orbegozo GR 2300 Manuel utilisateur

bora

bora PT11 Manuel utilisateur

Klarstein

Klarstein 10031664 Manuel utilisateur

Garland

Garland MWE3W Manuel utilisateur

Char-Broil

Char-Broil 463722714 Manuel utilisateur

Nexgrill

Nexgrill 720-0830HK Manuel utilisateur

Kenmore

Kenmore 415.16123800 Manuel utilisateur

Camp Chef

Camp Chef PG24CLAU Manuel utilisateur

Tucker Barbecues

Tucker Barbecues GTR Series Instructions de montage

Monogram

Monogram ZGG540NCP1SS Manuel utilisateur

Equipex

Equipex Sodir Savoy Manuel utilisateur

Gaggenau

Gaggenau VR 414 610 Manuel utilisateur

Miele

Miele KM 408-1 Manuel utilisateur

George Foreman

George Foreman GGR50B Manuel utilisateur

AOG

AOG T series Manuel utilisateur

Gorenje

Gorenje TG2000CB Mode d’emploi

Weber

Weber Genesis Silver-B Permamount NG 051701 Manuel utilisateur

Glen

Glen SA 3037 Manuel utilisateur