Optoma ML300 Manuel utilisateur
SERVICE MANUAL
Prepared:Cherry Checked:Amy Approved: Alick
Date Revise Version Description
2012.01.12 V1.0 Initial Issue
2012.05.23 V2.0
Add Engine Adjustment in chapter 2-10
Modify
Pixel specication
in chapter 4-3
Modify LED Calibration in chapter 4-4
Add Wavie Items in chapter 4-5
ML300
Copyright May 2012 All Rights Reserved
ML300 Condential I
Preface
This manual is applied to ML300 projection system.The manual gives you a brief description of
basic technical information to help in service and maintain the product.
Your customers will appreciate the quick response time when you immediately identify problems
that occur with our products.We expect your customers will appreciate the service that you offer
them.
This manual is for technicians and people who have an electronic background.Please send the
product back to the distributor for repairing and do not attempt to do anything that is complex or is
not mentioned in the troubleshooting.
Notice:
The information found in this manual is subject to change without prior notice. Any subsequent
changes made to the data herein will be incorporated in future edition.
ML300 Service Manual
Copyright May 2012
All Rights Reserved
Manual Version 2.0
Condential
ML300
II
Table of Content
Chapter 1 Introduction
Highlight 1-1
Compatible Mode 1-2
Chapter 2 Disassembly Process
Equipment Needed & Product Overview 2-1
Disassemble Top Cover Module 2-2
Disassemble Daughter Board and Keypad Board 2-3
Disassemble LED Cable 2-5
Disassemble Focus Ring 2-5
Disassemble Fan 2-7
Separate Engine Module and Main board 2-8
Disassemble Engine Module and LED 2-10
Disassemble Bottom Cover Module 2-13
Engine Adjustment 2-14
Repair Action 2-15
Chapter 3 Troubleshooting
LED Lighting Message 3-1
Main Procedure 3-2
Condential
ML300 III
Chapter 4 Function Test & Alignment Procedure
Test Equipment Needed 4-1
Test Condition 4-1
VGA Port Test 4-2
Composite Port And Audio Test 4-5Composite Port And Audio Test 4-5
HDMI 4-6
SD Card /USB ash disk/USB Test 4-6
Calibration 4-8
Waive Items 4-11
Run In Test 4-12
Test Inspection Procedure 4-13
Chapter 5 Firmware Upgrade
Section 1: System Firmware Upgrade 5-1
Equipment Needed 5-1
Check FW version 5-2
Section 2 : PIC Firmware Upgrade 5-3
Equipment Needed 5-3
PIC Firmware Upgrade 5-4
Section 3: MST7286 Firmware Upgrade 5-7
Equipment Needed 5-7
USB Driver Upgrade Procedure 5-8
MST7286 Firmware Upgrade Procedure 5-10MST7286 Firmware Upgrade Procedure 5-10
Section 4 : SSD1938 FW Upgrade 5-14
SSD1938 Firmware Upgrade Procedure 5-15
Condential
ML300 IV
Chapter 6 EDID Upgrade
EDID upgrade 6-1
Appendix A Exploaded Overview I
Appendix B Serial Number System Denition I
PCBA Code Denition II
ML300 1-1
Chapter 1
Introduction
No
1
3
10 DMD
11
13
1-1 Highlight
ML300
1-2 Compatible Mode
● Computer compatibility
Compatibility Resolution V-Sync[Hz]
● Compatibility: Multimedia Format
Video
Note: Video format does not support content with B-Frame function
ML300 1-3
Photo
Audio
Microsoft Ofce Viewer
Note: If the Computer Compatibility supportive signal is different from User’s Manual,
please refer to User’s Manual.
ML300 2-1
Chapter 2
Disassemble And Repair Action
2-1 Equipment Needed & Product Overview
Before you start: This process is protective level II. Operators should wear electrostatic chains.
2-2
ML300
2-2 Disassemble Top Cover
Module
3.
Autres manuels pour ML300
2
Table des matières
Autres manuels Optoma Projecteur
Optoma
Optoma DX609v Manuel utilisateur
Optoma
Optoma TWR1693 Manuel utilisateur
Optoma
Optoma EX531p Manuel utilisateur
Optoma
Optoma EX762 Manuel utilisateur
Optoma
Optoma X313 Manuel technique
Optoma
Optoma EP739H Manuel utilisateur
Optoma
Optoma EP719 Manuel utilisateur
Optoma
Optoma ZU820TST Manuel utilisateur
Optoma
Optoma TW1692 Manuel utilisateur
Optoma
Optoma TX610ST Manuel utilisateur
Optoma
Optoma DX326 Manuel utilisateur
Optoma
Optoma EX774N Manuel technique
Optoma
Optoma EP783S Manuel utilisateur
Optoma
Optoma EW766 Manuel utilisateur
Optoma
Optoma Projector with lens cap Manuel utilisateur
Optoma
Optoma EP757 Manuel utilisateur
Optoma
Optoma DS302 Manuel utilisateur
Optoma
Optoma TW610ST Manuel utilisateur
Optoma
Optoma Theme Scene HD82 Manuel utilisateur
Optoma
Optoma FX5200 Manuel utilisateur
Manuels Projecteur populaires d'autres marques
Panasonic
Panasonic PTL735NTU - LCD PROJECTOR-NETWORK IB Manuel utilisateur
NEC
NEC NP600S EDU Manuel utilisateur
BenQ
BenQ SH753P Manuel utilisateur
Eiki
Eiki EK-623U series Manuel utilisateur
Epson
Epson PowerLite Pro Cinema 6020UB Manuel utilisateur
Epson
Epson PowerLite Home Cinema 705HD Manuel utilisateur
