Nokia RM-11 Series Instructions d'installation

CC Technical Documentation

RM-11 Series Transceivers

Issue 2 09/2005 Confidential ©2005 Nokia Corporation

Disassembly

RM-11

Disassembly CC Technical Documentation

Page 2 ©2005 Nokia Corporation Confidential Issue 2 09/2005

Step-by-Step Disassembly Instructions

Always use ESD protection when assembling or dissasembling a phone.

Figure 1: ESD protection equipment

Disassembly Instructions

Step-by-Step Disassembly Instructions (Model 3205)

1. Hold the phone with the top down, facing you.

Press the Release Key and push the battery cover

out from the phone in the direction indicated (see

arrows in the above photo).

2. Remove the A-Cover by gently pulling from the top

end in the direction indicated by the above arrow.

3. Remove the Keymat. 4. Use SRT-10 camera removal tool to remove the

Antenna.

Note: Be careful not to damage mechanical parts. Do

not touch the antenna plate inside unless you are wear-

ing proper ESD gloves.

CC Technical Documentation Disassembly

RM-11

Issue 2 09/2005 ©2005 Nokia Corporation Confidential Page 3

5. Remove the six screws that hold the C-Cover in

place (torque 21Ncm and speed 480rpm).

6. Remove the PWB/UI module from the C-Cover.

7. Remove the UI module from the engine module.

Note: The UI module and the engine board are linked

together by two board-to-board connectors. Be careful

not to touch them.

UI module and engine module after separation.

8. Remove the microphone by gently pressing on its

edge or by placing tweezers between the frame and

the microphone and lifting it out of the frame.

9. Remove the speaker by lifting it from the guiding

pin.

Note: The speaker is attached into the frame with adhe-

sive tape. Therefore, it may not loosen easily.

Step-by-Step Disassembly Instructions (Model 3205)

RM-11

Disassembly CC Technical Documentation

Page 4 ©2005 Nokia Corporation Confidential Issue 2 09/2005

10. Open the snaps on both sides of the Display shield

and remove the shield.

Note: Be careful not to damage the shield.

11. Remove the LCD Module by holding the UI module

in one hand while loosening the LCD frame a little at

the same time at one side. Press the LCD module gently

from the same side you are loosening until the LCD

Module detaches.

Note: Be careful not to damage the sensitive parts. Do

not press the LCD Module too hard.

12. Remove the UI board from the LCD frame.

Note: Be careful not to damage the LCD frame.

13. Remove the Power Key.

Power Key removal. 14. Lift the Vibra to remove it.

Step-by-Step Disassembly Instructions (Model 3205)

CC Technical Documentation Disassembly

RM-11

Issue 2 09/2005 ©2005 Nokia Corporation Confidential Page 5

15. Lift the DC Jack out of its place.

Note: Be careful not to damage the C-Cover when

removing the DC Jack.

16. Use tweezers to lift the Release Spring.

17. Remove the Release Key. 18. Remove the A-cut cover from the A-Cover.

19. Remove the B-cut cover from the B-Cover. 20. Pry the battery out of the phone as indicated.

Step-by-Step Disassembly Instructions (Model 3205)

RM-11

Disassembly CC Technical Documentation

Page 6 ©2005 Nokia Corporation Confidential Issue 2 09/2005

Autres manuels pour RM-11 Series

5

Autres manuels Nokia Émetteur-récepteur

Nokia

Nokia RH-27 Series Mode d’emploi

Nokia

Nokia NHM-1 Series Mode d’emploi

Nokia

Nokia NKC-1X Series Mode d’emploi

Nokia

Nokia RH-18 Series Manuel utilisateur

Nokia

Nokia RM-696 Manuel utilisateur

Nokia

Nokia N92 RM-100 Manuel utilisateur

Nokia

Nokia RH-34 Series Guide de démarrage rapide

Nokia

Nokia NPM-10 Series Mode d’emploi

Nokia

Nokia NSB-9 Mode d’emploi

Nokia

Nokia NPM-6 Series Mode d’emploi

Nokia

Nokia NPM-10 Series Mode d’emploi

Nokia

Nokia NSB-6 Series Mode d’emploi

Nokia

Nokia NME-3 Series Manuel utilisateur

Nokia

Nokia RH-41 Series Manuel utilisateur

Nokia

Nokia NPM-10 Series Guide de démarrage rapide

Nokia

Nokia NME-2A Series Mode d’emploi

Nokia

Nokia RM-11 Series Mode d'emploi

Nokia

Nokia RH-27 Series Mode d’emploi

Nokia

Nokia NHM-8NX Series Mode d’emploi

Nokia

Nokia NSM-4 Series Instructions d'installation

Nokia

Nokia NSB-1 Series Manuel utilisateur

Nokia

Nokia NSC-1 SERIES Guide de configuration

Nokia

Nokia NSM-1 Series Mode d’emploi

Nokia

Nokia NSM-1 Series Instructions d'installation

Manuels Émetteur-récepteur populaires d'autres marques

Yaesu

Yaesu FT-7B Manuel utilisateur

Kenwood

Kenwood ProTalk TK-3201 Manuel utilisateur

Texas Instruments

Texas Instruments TLK10232 Manuel utilisateur

Mizuho

Mizuho MX-2 Guide produit

Kenwood

Kenwood TK-3180 Manuel d'utilisation et d'entretien

Blitz

Blitz MJ-398U Manuel utilisateur

Utilicom

Utilicom LongRanger 2050 Manuel utilisateur

Standart

Standart HX290UKA Manuel utilisateur

Altronix

Altronix Pace1PTM Manuel utilisateur

Kirisun

Kirisun PT2208 Manuel utilisateur

ELECRAFT

ELECRAFT KX2 Manuel utilisateur

Zodiac

Zodiac K3 Manuel utilisateur

Assa Abloy

Assa Abloy SecureComm HKC GSM-WIFI U Manuel utilisateur

Kenwood

Kenwood TK-2217 Manuel utilisateur

Siemens

Siemens PSO 4000 Manuel utilisateur

Kenwood

Kenwood TS-590SG Manuel utilisateur

Midland

Midland G8E-BT Manuel

ComNav

ComNav Mariner X2 Manuel utilisateur