Minuteman C82904-07 Mode d’emploi

OPERATION SERVICE PARTS CARE

Micro

Model: C82904-07

Vacuum

FOR COMMERCIAL USE ONLY

IMPORTANT SAFETY INSTRUCTIONS

When using an electrical appliance, basic precautions should always be followed, including the

following:

READ ALL INSTRUCTIONS BEFORE USING

WARNING- To reduce the risk of fire, electric shock, or injury:

• Do not leave appliance when plugged in. Unplug from outlet when not in use and

before servicing.

• To avoid electrical shock, do not expose to rain, store indoors.

WARNING:

To reduce the risk of electrical shock - Do not use on wet surfaces. Do not expose to

rain. Store indoors.

• Do not allow to be used as a toy. Close attection is necessary when used by or near

children.

• Use only as described in this manual. Use only manufacturer’s recommended

attachments.

• Do not use with damaged cord or plug. If appliance is not working as it should, has

been dropped, damaged, left outdoors, or dropped into water, return it to a service

center.

• Do not pull or carry by cord, use cord as a handle, close a door on cord, or pull cord

around sharp edges or corners. Do not run appliance over cord. Keep cord away

from heated surfaces.

• Do not unplug by pulling on cord. To unplug, grasp the plug, not the cord.

• Do not handle plug or appliance with wet hands.

• Do not put any object into openings. Do not use with any opening blocked; keep

free of dust, lint, hair, and anything that may reduce air flow.

• Keep hair, loose clothing, fingers, and all parts of body away from openings and

moving parts.

• Do not pick up anything that is burning or smoking, such as cigarettes, matches,

or hot ashes.

• Do not use without dustbag and/or filters in place.

• Turn off all controls before unplugging.

• Use extra care when cleaning on stairs.

• Do not use to pick up flammable or combustible liquids such as gasoline or use in

areas where they may be present.

• Connect to a properly grounded outlet only. See grounding instructions.

SAVE THESE INSTRUCTIONS

INSPECTION

Carefullyunpackandinspectyourmachineforshippingdamage.Eachunitistestedandthoroughly

inspectedbeforeshipment, andanydamage istheresponsibility ofthedelivery carrierwhoshould

benotified immediately.

ELECTRICAL - 115 Volt

This machine is designed to operate on a standard 15 amp. 115 volt, 60 hz,AC circuit. Voltages

below 105 voltsAC or above 125 voltsAC could cause serious damage to the motor.

GROUNDING INSTRUCTIONS

Thisappliancemustbegrounded. If itshouldmalfunctionorbreakdown, grounding providesapath

ofleastresistanceforelectriccurrenttoreducetherisk of electric shock. This applianceisequipped

withacordhavinganequipment-groundingconductorandgroundingplug.Theplugmustbeplugged

intoan appropriate outletthat is properlyinstalled and groundedin accordancewith all localcodes

andordinances.

DANGER

Improper connection of the equipment-grounding conductor can result in a risk of electric shock.

Check with a qualified electrician or service person if you are in doubt as to whether the outlet is

properly grounded. Do not modify the plug provided with the appliance — if it will not fit the outlet,

havea proper outletinstalled by aqualified electrician.

Thismachineis for use on anominal120voltcircuitandhasagroundingplugthatlooksliketheplug

illustrated in Sketch A. Make sure that the machine is connected to an outlet having the same

configurationasthe plug.No adapter shouldbe used withthis appliance.

WARNING

Thisvacuummaycontainpotentially hazardousdustdependingonitsapplication.Specialhandling

of contaminated disposal bags and filters is recommended. Disposal must be in compliance with

localEPAregulations

USER MAINTENANCE INSTRUCTIONS

All service and repair should be performed by qualified vacuum service representative or electri-

cian.Nouserserviceablecomponentsare employed in the electrical vacuum lid head assembly.No

lubricationof the motoris required.

CLOTH BAG & HOSE ASSEMBLY

Clothbagandhoseassemblyareusermaintenance items and canbereplacedwhenwornout.For

optimumperformance,emptyandcleanfilterbagregularly.Acloggedand dirty bag restrictstheflow

of air and results in reduced vacuum. The hose assembly can be maintained by wiping off with a

dampenedcloth of mildliquid soap and water,thenallowed todry.

CORD STORAGE

While not in use storage can be accomplished by winding cord around motor lid assembly. Cord

shouldbecompletelyunwoundfrom lid assembly duringoperation.

• Donot usewithdamagedcordorplug.Ifapplianceisnotworkingasit should,hasbeendropped,

damaged,leftoutdoors,ordropped into water,returnto servicecenter.

• Donotpull orcarryby cord,use cord ashandle, close adoor on cord,or pull cordaround sharp

edgesor corners. Do not run appliance over cord. Keep cord away from heated surfaces.

• Donotunplugbypulling cord.Tounplug,grasptheplug, not thecord.

• Donothandle plug orappliance with wethands.

• Alwaysunplugthemachine when removingthemotor head offthetank. This equipment should

be stored indoors and not exposed to rain.

Alwaysunplugthemachinewhenremoving the motor headoffthetank.Thisequipment should be

storedindoors and not exposed to rain.

OPERATION AND FILTER CARE INSTRUCTIONS

TheMinuteman Critical FilterVacuum has beenspecifically designedto clean upfibrous asbestos,

mold,and lead dustof all types.Special filtersreduce the incidenceof airborne dustthat wouldbe

createdbyanyothermethodofcleaning.

· Duringthe removalofhazardousdust,donotsweep,scoop, shovel,orinanymannerhandleother

thanbyvacuuming.

· Donotatanytimeattempttobypass,remove,substitute,orby any other means change the filters

usedinthisvacuum.Use only approved Minutemanvacuumfiltersandfilter bags.

· Beforeattemptingtouse and beforecleaning,be certain that youfullyunderstand

· theinstructionsgivenforthe setting uporcleaning/changingoffilters of thisvacuum.

· Since each facility has its own individual and unique cleaning problems, it is suggested that you

usethefollowing guidelines indeterminingthe length oftimebetween filter changes.

· Inlightcleaningsituationschangefilters once a dayunlessyouhavedetermined by checking that

ashorter orlonger periodof timewould benecessary tomeet 10 pounds of material.

TANK/FILTER SET-UP PROCEDURE

1. Takethe paperbag thathas the cardboardcollar attachedandopen it bygently pulling

thefoldsapart.

2. Youwillnoticetwocreasesonthetopsideofthecollar; carefullybendtheendsdown(toward)the

bag.

3. Insertthis bag intothetank and pushit to thebottom.

4. Locatethecardboard collar around theintaketubeandgentlywork it up pasttheraisedringthat

runsaround thetube.

5. Placethe optional clothfilter bag ontoand into thetank.

6. Position the lidon the tankas shown onthe nextpage.

7. Snap the lidlatches into place.

For proper cleaning of tank and removal/changing of filters, see “Procedure for Removing

ContaminatedFilters andfor Cleaning ofContaminatedTank”.

Raised tab Latch

PROCEDURE FOR REMOVING CONTAMINATED FILTERS

AND FOR CLEANING OF CONTAMINATED TANK

Forthe benefit ofyour health, youshould always wearpersonal protectiveclothing and respiratory

protectionanytimeyou are using orcleaningthis vacuum.

1. Unplugmachinefrom power source.

2. Carefullyandslowlyremovelidonly(besureyouhavenotaccidentallyliftedtheclothfilterbag

atthe same time). Set the lid/filter assemblyaside.

3. Gently tap the inside of the cloth bag to loosen any particles that may be on the opposite

surface.Do this allaround theinside surface ofthe bag.

4. Gentlyremove the clothbagand setaside.

5. Usingacloth,dampenedwithwater(notsoakingwet),wipedownallof the exposed surfaces

insideof the tank; put the cloth aside, do notdiscard.

6. Carefully and “very” slowly, push the paper bag down and off of the intake tube, using the

attached cardboard collar.After the collar is removed from the intake tube, take the damp

cloth and wipe off any surfaces that were not previously cleaned; at this time, re-wipe the

entire inside of the tank and dispose of cloth in the plastic bag.

7. CAUTION: Hazardous materials must be disposed of properly. Never throw contaminated

debris in your usual trash receptacle. Place debris in a plastic bag or can marked

“HAZARDOUSMATERIALS” and taketo ahazardouswaste handler.

8. Forproper assembly ofnew filters, see“Tank/Filter Set-Up Procedure”.

CHANGING THE BLACK FOAM PREFILTER

The black filter should be changed, using all of the precautions previously mentioned. The filter

shouldbechangedwhen any ofthefollowingtakes place:

1. Anytime there is an indication of a filter tear during normal operation of the unit. This tear

couldbein anyofthe filtersused.

a. paperdust containment bag

b. clothfilter bag

Thesetearswouldshowupduring the tankclean-outprocedure, or....

2. Everyothertank clean-out period.

To changethe prefilter,dothefollowing before youdo Step#3of the normalclean-out

procedure:

a. Wipedownall of theexposedsurfaceson the underside oftheremovedlid, using the

dampenedwiping cloth (see Step #6).

3. Toinstallprefilter Item1 simply slideblack foamsleeve over HEPAcanister.

PARTS LIST

ITEM PART NO. REQ'D DESCRIPTION

1 110025 1 FILTER, HEPA-MICROVAC

2 110027 1 PREFILTER SLEEVE, ALLERVAC - SINGLE

3 290017 2 MOLDED VAC MOTOR GASKET

4 290031 1 LID GASKET 294/6 DIECUT

5 290032 1 DOME SEAL 296

6 380001-4 1 MOTOR-VAC BYPASS 120V (ECM) W/ WIRES

7 740088 1 SWITCH-VAC LIGHT SENSOR

8 380064 1 RING, FOAM

9 381020 1 CORD-16GA-3 50FT MED GREY

10 829091 1 COVER-MOTOR 4G DRY

11 460001 1 HANDLE BASIC 460 BLACK

12 460101 1 MOTOR CAP- BLACK

13 460104MCH 1 MOTOR HOLDOWN 829SERIES

14 460120 1 MOTOR PAN ASY 829SERIES

15 700287 1 GROMMET

16 829099 1 TUBE SS .125 X 1.5

17 800071 1 CLEAR TUBBING 12" LONG

18 711125 3 SCR-ST-B 10 X .50 NI

19 711160 9 SCR-HI/LO #10 X 5/8 ZINC

20 711161 8 SCR-HI/LO #10 X 3/4 ZINC

21 711162 2 SCR-HI/LO #10 X 1 1/2 ZINC

22 715029 1 DECAL-NAME PLATE SERIAL

23 715446 1 DECAL-HEPA FILTER

24 715009 1 DECAL-WARNING TO AVOID

25 809754 1 SWITCH-ROCKER

26 828893 1 RIVET-BAP KTR64BX

27 831801-2 1 RECEPTACLE ASY, FEMALE W/PIGGYBACKS

28 380005 1 CARBON BRUSH REPLACEMENT (ECM)

Table des matières

Autres manuels Minuteman Aspirateur

Minuteman

Minuteman Parker LV02675BM Manuel utilisateur

Minuteman

Minuteman C82985-06 Manuel de la liste des pièces

Minuteman

Minuteman V14 PRO Manuel utilisateur

Minuteman

Minuteman MPV C37115-14 Mode d’emploi

Minuteman

Minuteman X829 Asbestos Series Manuel de la liste des pièces

Minuteman

Minuteman CRV Manuel de la liste des pièces

Minuteman

Minuteman Parker LV02675B Mode d’emploi

Minuteman

Minuteman CC-3 Series Mode d’emploi

Minuteman

Minuteman C29485-02 Mode d’emploi

Minuteman

Minuteman V10 Pro Plus Manuel utilisateur

Minuteman

Minuteman C80704-01 SS Mode d’emploi

Minuteman

Minuteman mc827854 Manuel d'utilisation

Minuteman

Minuteman C84790-00 Mode d’emploi

Minuteman

Minuteman C82917-00 Mode d’emploi

Minuteman

Minuteman X839 Asbestos Series Manuel de la liste des pièces

Minuteman

Minuteman X839 Asbestos Series Manuel de la liste des pièces

Minuteman

Minuteman C82908-00 Mode d’emploi

Minuteman

Minuteman 290 Series Manuel de la liste des pièces

Minuteman

Minuteman C27120-00 Mode d’emploi

Minuteman

Minuteman X839 Asbestos Series Manuel de la liste des pièces

Minuteman

Minuteman Phenom L1518 Manuel utilisateur

Minuteman

Minuteman C29085-05 Manuel de la liste des pièces

Minuteman

Minuteman Bio-Haz Vacuum Manuel de la liste des pièces

Minuteman

Minuteman Asbestos 839 Series Manuel utilisateur

Manuels Aspirateur populaires d'autres marques

Bissell

Bissell LittleGreen Proheat 1425 Series Manuel utilisateur

Panasonic

Panasonic MC-YL637S147-AE Manuel utilisateur

NEFF

NEFF N17XH10 0 Series Manuel utilisateur

LG A9 Series Manuel utilisateur

Oreck

Oreck Cordless Captura BK51700 Series Manuel utilisateur

Kogan

Kogan KAVACROBVWA Manuel utilisateur

Kränzle

Kränzle VENTOS 50 ID Guide de l'utilisateur

EVVO

EVVO Ai35 Manuel utilisateur

DeWalt

DeWalt DWH200D Manuel utilisateur

Pontec

Pontec Pondomatic Vacuum Cleaner Manuel utilisateur

Cleanmaxx

Cleanmaxx PC-P007E Manuel utilisateur

Exido

Exido 240-114 Manuel utilisateur

RIDGID

RIDGID WD1685AU0 Manuel utilisateur

Ezviz

Ezviz RE4P Manuel utilisateur

STG global

STG global TANVAC HDV3000 Manuel utilisateur

Shark

Shark ROTATOR PRO COMPLETE NV550 Series Manuel utilisateur

Factory

Factory M3340 Manuel utilisateur

Shop-Vac

Shop-Vac VN92 SERIES Manuel utilisateur