Manitowoc BG0260 Manuel utilisateur

Technician’s

Handbook

This manual is updated as new information and models are released.

Visit our website for the latest manual. www.manitowocfsg.com

America’s #1 Selling Ice Machine

BG0260

Spray Cube

Part Number STH48 6/15

General Information

Model Numbers ...................................5

BG0260A .............................................5

Model/Serial Number ...........................5

Manitowoc Cleaner and Sanitizer ........5

Installation

Location of Ice Machine ......................7

Installation Requirements ....................7

Potable Water Requirements ..............8

Drain Connections ...............................8

Ice Machine Clearance Requirements 8

Electrical Service .................................9

Operation

Ice Making Sequence of Operation .........11

Thermostat settings .............................13

Maintenance

Cleaning & Sanitizing Procedure .........16

Cleaning the Condenser .....................20

Removal from Service/Winterization ...21

Troubleshooting

Electrical Flowcharts ................................23

Electrical Flowchart Ice Machine Will Not

Run ......................................................24

Will Not cycle Into Harvest ...................28

Prematurely Cycles Into Harvest .........31

Refrigeration Troubleshooting ................34

Ice Production/Quality Check ..............35

Component Specifications

Thermostat Settings ............................41

Fan Cycle Control Settings ..................41

Total System Refrigerant Charge ........41

Filter-Driers ..........................................42

Suction Cleanup Filter-Drier ................42

Charts

Cycle Times/24-Hour Ice Production/

Refrigerant Pressure Charts ....................43

BG0260A .............................................44

Diagrams

Wiring Diagram .........................................45

BG0260 ...............................................46

Refrigeration Tubing Schematics ...........47

Part Number STH48 6/15 5

General Information

MODEL NUMBERS

BG0260A

MODEL/SERIAL NUMBER

These numbers are required when requesting

information from your local Manitowoc Distributor, or

Manitowoc Ice. The model and serial number are

listed on the MODEL/SERIAL NUMBER DECAL

affixed to the ice machine.

MANITOWOC CLEANER AND SANITIZER

Manitowoc Ice Machine Cleaner and Sanitizer are

available in 16 oz. (473 ml) bottles. These are the only

cleaners and sanitizer approved for use with

Manitowoc products.

Cleaner Part Number Sanitizer Part Number

16 oz. 000000084 16 oz. 9405653

1 gal N/A 1 gal. 9405813

6 Part Number STH48 6/15

This Page Intentionally Left Blank

Part Number STH48 6/15 7

Installation

LOCATION OF ICE MACHINE

The location selected for the ice machine must meet

the following criteria. If any of these criteria are not

met, select another location.

• The location must be free of airborne and other

contaminants.

• The location must not be near heat-generating

equipment or in direct sunlight.

• The location must be capable of supporting the

weight of the ice machine and a full bin of ice.

• The location must allow enough clearance for

water, drain and electrical connections in the rear

of the ice machine.

• The location must not obstruct airflow through or

around the ice machine.

INSTALLATION REQUIREMENTS

• The air temperature must be at least 50°F (10°C),

but must not exceed 110°F (43°C).

• The water temperature must be at least 50°F

(10°C), but must not exceed 100°F (38°C).

• The ice machine and bin must be level

• Vent the ice machine and bin drains separately

• Bin drain termination must have an air gap

• A back flow preventer is required on water inlet

lines

• Routine adjustments and maintenance procedures

outlined in this manual are not covered by the

warranty.

8 Part Number STH48 6/15

POTABLE WATER REQUIREMENTS

• Plumbing must conform to local codes

• Do not connect the ice machine to a hot water

supply. Be sure all hot water restrictors installed for

other equipment are working. (Check valves on

sink faucets, dishwashers, etc.)

• If water pressure exceeds maximum pressure (6

bar) obtain a water pressure regulator from your

Manitowoc distributor.

• A union for both the ice making and condenser

water lines is required

• Water inlet lines require insulation to prevent

condensation.

DRAIN CONNECTIONS

• Drain lines must have a 1.5 inch drop per 5 feet of

run (2.5 cm per meter), and must not create traps

• The floor drain must be large enough to

accommodate drainage from all drains.

• Separate insulated bin and water-cooled

condenser drain lines are required

• The bin and ice machine drains require a vent.

ICE MACHINE CLEARANCE REQUIREMENTS

Air-Cooled Water-Cooled

Top/Sides 5" (13 cm) 5" (13 cm)

Back 8" (20 cm) 8" (20 cm)

Part Number STH48 6/15 9

ELECTRICAL SERVICE

Voltage

The maximum allowable voltage variation is ± 10% of

the rated voltage on the ice machine model/serial

number plate at compressor start-up.

Fuse/Circuit Breaker

A separate fuse/circuit breaker must be provided for

each ice machine.

Ground Fault Interrupter Circuit (GFIC)

A GFCI/GFI circuit protection is not recommended

with our equipment. If a GFCI/GFI is required by code

a GFCI/GFI breaker rather than outlet must be used to

avoid intermittent nuisance trips.

Warning

All wiring must conform to local and national codes.

Warning

The ice machine must be grounded in accordance

with national and local electrical codes.

10 Part Number STH48 6/15

This Page Intentionally Left Blank

Table des matières

Autres manuels Manitowoc Machine à glaçons

Manitowoc

Manitowoc QR0320A Manuel utilisateur

Manitowoc

Manitowoc CNF0201 Manuel utilisateur

Manitowoc

Manitowoc RF2300 Mode d’emploi

Manitowoc

Manitowoc C-0200 Manuel utilisateur

Manitowoc

Manitowoc Q 7628973 Manuel utilisateur

Manitowoc

Manitowoc SN12 Instructions d'utilisation

Manitowoc

Manitowoc 30" Q-MODEL ICE MACHINES MYLAR STRIP 7600153 Manuel utilisateur

Manitowoc

Manitowoc Indigo Guide de démarrage rapide

Manitowoc

Manitowoc F Series Instructions d'utilisation

Manitowoc

Manitowoc STH042 7/15 Manuel utilisateur

Manitowoc

Manitowoc RF Mode d’emploi

Manitowoc

Manitowoc B Series Manuel utilisateur

Manitowoc

Manitowoc S600M Manuel utilisateur

Manitowoc

Manitowoc 1100 series Manuel utilisateur

Manitowoc

Manitowoc QM20 Series Manuel du propriétaire

Manitowoc

Manitowoc QM45A Manuel utilisateur

Manitowoc

Manitowoc B200 Series Manuel utilisateur

Manitowoc

Manitowoc MAC 6 K058 Manuel utilisateur

Manitowoc

Manitowoc QM 20 Manuel utilisateur

Manitowoc

Manitowoc Q130 series Manuel

Manitowoc

Manitowoc Indigo NXT Manuel utilisateur

Manitowoc

Manitowoc FLARE NUT TXV REPLACEMENT (Z100) 7625563 Manuel utilisateur

Manitowoc

Manitowoc M-90 Instructions d'utilisation

Manitowoc

Manitowoc Marine Q800 Mode d’emploi

Manuels Machine à glaçons populaires d'autres marques

Hoshizaki

Hoshizaki KMD-460MWJ Manuel utilisateur

Sub-Zero

Sub-Zero 315I Instructions d'utilisation

Unold

Unold 48945 Manuel utilisateur

Kenmore

Kenmore 2217402A Manuel utilisateur

Cornelius

Cornelius WM600 Mode d'emploi

GE XPIO43SCSS Manuel utilisateur

Hoshizaki

Hoshizaki KMD-901MAH Manuel utilisateur

Whynter

Whynter FIM-450HA Manuel utilisateur

U-Line

U-Line UMCR014-SC01A Manuel d'installation

Andrew James

Andrew James AJ000522 Manuel utilisateur

Scotsman

Scotsman CME1356 Manuel utilisateur

Scotsman

Scotsman ACM 25 Manuel utilisateur

Kärcher

Kärcher IP 120 Manuel utilisateur

U-Line

U-Line SS1095 Manuel utilisateur

Maytag

Maytag MIM1554WRS - Ice Maker Manuel utilisateur

Hoshizaki

Hoshizaki KM-630MAH Manuel utilisateur

Princess

Princess Yonanas Manuel utilisateur

Unold

Unold 48946 Manuel utilisateur