MacroAir Technologies X Series Manuel utilisateur
Operation Manual
MacroAir Local
Override Remote
Table of Contents
© 2020 MacroAir Technologies Toll Free: 866 668-3247 Fax: 909 890-2313 www.macroairfans.com
Local Override Remote Operation Manual 90-30059-00 Rev A-01 Date: 060120
1
Introduction
Wiring the Fan
Wiring Diagrams
Operation
Appendices
Caution & Safety .........................................2
Remote Enclosure,
Control Panel Enclosure ..............................3
Remote Panel Overview,
Control Panel Overview ..............................4
Remote Panel Schematic ............................7
Control Panel Schematic
Single Phase (Low Voltage) .........................8
Control Panel Schematic
Three Phase (Low Voltage) .........................9
Control Panel Schematic
Three Phase (High Voltage) ...................... 10
Basic Operation ......................................... 11
Warranty ................................................. 12
Technical Support .................................... 13
2Introduction
© 2020 MacroAir Technologies Toll Free: 866 668-3247 Fax: 909 890-2313 www.macroairfans.com
Local Override Remote Operation Manual 90-30059-00 Rev A-01 Date: 060120
Caution and Safety
ATTENTION: Safety. READ THE ENTIRE MANUAL BEFORE OPERATING THE FAN. Ensure that
all safety practices and instructions are followed during the installation, operation, and servicing
of the fan. Failure to apply these safety practices could result in death or serious injury. If you do
not understand the instructions, please call our Technical Department for guidance.
ATTENTION: Qualified Technicians. All fan controls and incoming power should only be
installed by qualified technicians familiar with the requirements of the National Electrical Code
(NEC) and local codes. Refer to appropriate portions of this manual for other important
ATTENTION: Damp and Corrosive Environments. MacroAir provides a stainless-steel fan
alternative especially for excessively damp, caustic, or corrosive environments. It is
recommended that the environmental conditions acting on a fan installation be reviewed to
insure the proper choice of a fan purchase and special warranty considerations.
ATTENTION: Code Compliance. Installation is to be in accordance with the NEC, ANDSI/NFPA
70-1999 and local codes.
Hazard of Electrical Shock, Explosion or Arc Flash:
ATTENTION: Read. Read and understand this manual before installing or operating a fan unit.
Installation, adjustment, repair, and maintenance must be performed by qualified personnel.
ATTENTION: Code Compliance. The user is responsible for compliance with all international
and National Electrical Code requirements with respect to grounding of all equipment.
WARNING: Do Not Touch. Many of the parts of this unit operate at line voltage. DO NOT
TOUCH.
WARNING: Covers. Install all covers before applying power or starting and stopping the unit.
Installation and Service
WARNING: Damage. Do not operate or install any fans or fan accessories that appear to be
damaged.
WARNING: Death and Injury. Failure to follow this instruction can result in death, serious
injury, or equipment damage.
WARNING: Disconnect Power. If the fan does not operate properly using the procedures in
this manual. BE CERTAIN TO REMOVE ALL POWER TO THE UNIT and contact our technical
department for further assistance.
CAUTION: Moving Parts. Keep all body parts clear of moving parts at all times.
ATTENTION: Qualified Technicians. All electrical troubleshooting and repair must be done by
a qualified technician and meet all applicable codes.
REFER TO FAN INSTALLATION MANUAL(S) FOR FURTHER MAINTENANCE INFORMATION.
3Introduction
© 2020 MacroAir Technologies Toll Free: 866 668-3247 Fax: 909 890-2313 www.macroairfans.com
Local Override Remote Operation Manual 90-30059-00 Rev A-01 Date: 060120
Remote Enclosure
Control Panel Enclosure
Images are not to scale
4Wiring the Fan
© 2020 MacroAir Technologies Toll Free: 866 668-3247 Fax: 909 890-2313 www.macroairfans.com
Local Override Remote Operation Manual 90-30059-00 Rev A-01 Date: 060120
Remote Panel Overview
Control Panel Overview
1 Phase (Low Voltage)
Wiring the Fan
© 2020 MacroAir Technologies Toll Free: 866 668-3247 Fax: 909 890-2313 www.macroairfans.com
Local Override Remote Operation Manual 90-30059-00 Rev A-01 Date: 060120
5
Control Panel Overview, cont.
3 Phase (Low Voltage)
3 Phase (High Voltage)
Wiring the Fan
© 2020 MacroAir Technologies Toll Free: 866 668-3247 Fax: 909 890-2313 www.macroairfans.com
Local Override Remote Operation Manual 90-30059-00 Rev A-01 Date: 060120
6
Control Panel Overview, cont.
1. Control Panels come pre-wired, as illustrated on pages 4-5.
2. Make sure the control wiring is CAT5e shielded, stranded or greater.
3. If removed from the enclosure, the disconnect switch must be in the OFF position when
removed, and in the OFF position when reinstalled to prevent misalignment of switch.
4. The Motor Cable Gland and the Cable Gland for Analog Control do not come pre-installed.
Use a unibit to drill installation holes.
5. Shielded motor cable is provided and must be used with no additional cable to maintain
factory warranty.
6. Mounting hardware for mounting enclosure to an I-beam, Glulam or wall is not supplied by
MacroAir.
7. Connect CAT5e ntroller.
This control panel overview supersedes and replaces that found in your fan Operation Manual.
7Wiring Diagrams
© 2020 MacroAir Technologies Toll Free: 866 668-3247 Fax: 909 890-2313 www.macroairfans.com
Local Override Remote Operation Manual 90-30059-00 Rev A-01 Date: 060120
Remote Panel Schematic
Wiring Diagrams
© 2020 MacroAir Technologies Toll Free: 866 668-3247 Fax: 909 890-2313 www.macroairfans.com
Local Override Remote Operation Manual 90-30059-00 Rev A-01 Date: 060120
8
Control Panel Schematic - Single Phase (Low Voltage)
This control panel schematic supersedes and replaces that found in your fan Operation Manual.
Ce manuel convient aux modèles suivants
7
Table des matières
Autres manuels MacroAir Technologies Ventilateur
MacroAir Technologies
MacroAir Technologies AirVolution D3 Manuel utilisateur
MacroAir Technologies
MacroAir Technologies EnergyLogic AVD3 Manuel utilisateur
MacroAir Technologies
MacroAir Technologies 370 Airvolution D Manuel utilisateur
MacroAir Technologies
MacroAir Technologies Diamond HVLS Series Manuel utilisateur
MacroAir Technologies
MacroAir Technologies AirStar Manuel utilisateur
MacroAir Technologies
MacroAir Technologies airelite Manuel utilisateur
MacroAir Technologies
MacroAir Technologies AirVolution D3 Manuel utilisateur
MacroAir Technologies
MacroAir Technologies 370 Airvolution D Manuel utilisateur
MacroAir Technologies
MacroAir Technologies AirEco Manuel utilisateur
MacroAir Technologies
MacroAir Technologies AirStar Manuel utilisateur
MacroAir Technologies
MacroAir Technologies airelite Manuel utilisateur
MacroAir Technologies
MacroAir Technologies WhisperFoil Manuel utilisateur
MacroAir Technologies
MacroAir Technologies AirVolution-D 550 Manuel utilisateur
MacroAir Technologies
MacroAir Technologies AVD370 Manuel utilisateur
MacroAir Technologies
MacroAir Technologies AirVolution 550 Manuel utilisateur
MacroAir Technologies
MacroAir Technologies AirVolution-D 370 Manuel utilisateur
MacroAir Technologies
MacroAir Technologies AVD 370/2 Manuel utilisateur
